• Author / Uploaded
• lervinjc

Citation preview

Ford explorer 97 1996 F150-F350 PCM 104 Pin Connector (4.9L, 5.0L, 5.8L Only)

The fuel injection computer (known in tech speak as the PCM = Powertrain Control Module) is located on the firewall (driver side near the top) of your Ford pickup. The EEC-V PCM has a 104 pin connector and on the back side of the connector (wire side) are embossed a few numbers (on the back side) to further aid you in correctly identifying the pins (circuits). IMPORTANT: The illustration above and pin-out table below apply only to: 1996 Ford pickup with 4.9L, 5.0L, 5.8L engine with 4R70W or E4OD automatic transmission with EEC V engine management system. 1996 Ford F150-F350 104 Pin Connector (4.9L, 5.0L, 5.8L) Pin

Wire Color

Description

1

PPL/ORG

Transmission Shift Solenoid 2

2

PNK/LT GRN

Malfunction Indicator Light (MIL) -Check Engine Light (CEL)

3

---

Not Used

4

---

Not Used

5

---

Not Used

6

BLK/YEL

Misfire Sense

7

---

Not Used

8

---

Not Used

9

---

Not Used

10

---

Not Used

11

---

Not Used

12

---

Not Used

13

PPL

Data Link FEPS

14

LT BLU/BLK

Low Range 4X4

15

PNK/LT BLU

Data Link (-)

16

TAN/ORG

Data Link (+)

17

--

Not Used

18

---

Not Used

19

---

Not Used

20

---

Not Used

21

---

Not Used

22

---

Not Used

23

ORG/RED

Ignition Ground

24

BLK/WHT

Power Ground

25

BLK/LT BLU

Case Ground

26

---

Not Used

27

ORG/YEL

Transmission Shift Solenoid 1

28

---

Not Used

29

TAN/WHT

Trans Control Switch

30

---

Not Used

31

---

Not Used

32

---

Not Used

33

PNK/ORG

Vehicle Speed Sensor (VSS) (-)

34

---

Not Used

35

RED/LT GRN

Right Rear Oxygen Sensor Signal

36

TAN/LT BLU

MAF Sensor Signal Return (Ground)

37

ORG/BLK

Trans Temp

38

LT GRN/RED

Engine Coolant Temp (ECT) Sensor

39

GRY

Intake Air Temp (IAT) Sensor

40

DK GRN/YEL Fuel Pump Monitor (FPM)

41

DK GRN/ORG A/C Clutch Signal

42

---

Not Used

43

---

Not Used

44

BRN ---

AIRD Solenoid (4.9L, 5.0L Only) Not Used (5.8L Only)

45

---

Not Used

46

---

Not Used

47

BRN/PNK

EGR Solenoid Control

48

YEL/BLK

Ignition Diagnostic Monitor (IDM)

49

GRY/ORG

Crankshaft Position (CKP) Sensor

50

PNK

SPOUT

51

BLK/WHT

Power Ground

52

---

Not Used

1996 F150-F350 PCM 104 Pin Connector (4.9L, 5.0L, 5.8L Only)

1996 Ford F150-F350 104 Pin Connector (4.9L, 5.0L, 5.8L) 53

--BRN/ORG

Not Used (5.0L w/ 4R70W Only) Coast Clutch (4.9L, 5.0L and 5.8L w/ E4OD Only)

54

PPL/YEL

Torque Converter Clutch Solenoid

55

YEL

Battery

56

LT GRN/BLK

Vapor Valve

57

--YEL/RED

Not Used (5.0L, 5.8L Only) Knock Sensor Input (4.9L Only)

58

GRY/BLK

Vehicle Speed Sensor (VSS) (+)

59

DK GRN/LT GRN

Misfire In

60

GRY/LT BLU

Right Front Oxygen Sensor Signal

61

---

Not Used

62

---

Not Used

63

---

Not Used

64

LT BLU/YEL

TR Sens In

65

BRN/LT GRN

DPFE Sens

66

---

Not Used

67

---

Not Used

68

---

Not Used

69

---

Not Used

70

WHT/ORG ---

AIRB Solenoid (4.9L, 5.0L Only) Not Used (5.8L Only)

71

RED

Power

72

--TAN/RED

Not Used (4.9L Only) Fuel Injector #7 (5.0L, 5.8L Only)

73

TAN/BLK

Fuel Injector #5

74

BRN/YEL

Fuel Injector #3

75

TAN

Fuel Injector #1

76

BLK/WHT

Power Ground

77

BLK/WHT

Power Ground

78

---

Not Used

79

WHT/LT GRN

Trans Control Indicator

80

LT BLU/ORG

Fuel Pump Control

81

WHT/YEL

EPC Solenoid

82

---

Not Used

83

WHT/LT BLU

Idle Air Control (IAC) Solenoid

84

DK BLU/YEL ---

Trans Shft Spd (5.0L w/ 4R70W Only) Not Used (4.9L, 5.0L and 5.8L w/ E4OD Only)

85

---

Not Used

86

---

Not Used

87

RED/BLK

Left Front Oxygen Sensor Signal

88

LT BLU/RED

MAF Sensor In

89

GRY/WHT

Throttle Position Sensor Signal

90

BRN/WHT

REF Volt

91

GRY/RED

Signal Return (Sensor Ground)

92

LT GRN

Brank On/Off Switch

93

RED/WHT

Oxygen Sensor Heater Control

94

YEL/LT BLU

Oxygen Sensor Heater Control

95

WHT/BLK

Oxygen Sensor Heater Control

96

---

Not Used

97

RED

Power

98

--LT BLU

Not Used (4.9L Only) Fuel Injector #8 (5.0L, 5.8L Only)

99

LT GRN/ORG

Fuel Injector #6

100 BRN/LT BLU

Fuel Injector #4

101 WHT

Fuel Injector #2

102 ---

Not Used

103 BLK/WHT

Power Ground

104 ---

Not Used