• Author / Uploaded
• lucian_pil

Citation preview

Design of wiring diagrams No.1/2

Circuit complex (function-oriented with consecutive No.)

Battery, Ignition/starter switch, Fuse holder on battery Designation of the circuit shown on this page

J519 - Onboard supply control unit marked by a grey field (furthermore this control unit is no longer shown in the Current Flow Diagrams)

Load circuits with cable guide All switches and contacts are marked in mechanical rest position.

Key to cable colours ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

Vehicle mass Numbers in chalk mark the fitting location (see Legends). Current path No. In order to easily find the combinations. A B D J519 T3a T18a

-

Battery Starter Ignition/starter switch Onboard supply control unit 3-pin connector, at left of bulkhead (grey) 18-pin connector, at electrical system control unit (brown)

11

- Earth point, left in engine compartment

A1

- Positive connection (30a), in wiring loom behind dash panel

P1

- Positive connection (30), in fuse holder on battery

Edition 07.03 S00.5324.00.20

Legend The same part designations are used in all the current flow diagrams for the same components, e.g. always A for battery.

Design of wiring diagrams

I

Explanation of symbols

II

Explanation of symbols

Edition 07.03 S00.5324.00.20

Explanation of symbols 1 -

The arrow points to the next circuit forming part of the current flow diagram.

2 -

Designation of a connector at onboard supply control unit If there is an assignment of a multipin connector with a cable, e. g. T6o/4 - 6-pin connector, T6o, contact 4.

3 -

Reference to continuation of cable The number within a frame indicates the current path in which the cable is continued.

4 -

Designation of a fuse e. g. Fuse No. 3 (15 amps) in fuse holder.

5 -

Designation of a plug connection at a component Indicates the designation of the multipin connector, the number of contacts and the assigned contact number, e.g. T32a/15 - Multipin connector T32a - 32-pin, contact 15.

6 -

Designation for connection in wiring loom You can find information in the legend regarding the wiring loom in which this non-detachable connection (cable weld point) is located.

7 -

Reference to continuation of internal connection The number indicates the point at which the connection is continued in the next section of the current flow diagram.

8 -

Symbol for component (refer to p. IV, V)

9 -

The arrow refers to continuation of the component in the next current flow diagram.

10 -

Designation of a plug connection in wiring harness Indicates the designation of the multipin connector, the number of contacts and the assigned contact number, e.g. T3k/2 - Multipin connector T3k, 3-pin, contact 2.

11 -

Designation of a terminal Terminal designation indicated on the original part and/or contact number of a multipin connector.

12 -

Designation of connection - Relay in relay holder It indicates the individual contact of relay, e.g. 30 = contact 30 at relay.

13 -

Relay position - Designation in relay holder

14 -

Cable cross section (mm2) and cable colour (the abbreviations are explained in the key for cable colours next to the current flow diagram).

15 -

Parts designation You can find in the legend the name of the part.

16 -

Internal connection (thin line) This connection does not exist as a cable. Internal connections are electrically conductive connections, however. They make it possible to trace the current flow within components and wiring looms.

17 -

Designation of an earth point You can find information in the legend regarding the position of the earth point in the vehicle.

Edition 07.03 S00.5324.00.20

Explanation of symbols

III

Symbols for current flow diagrams

Plug connection in wiring loom

Bulb

Bulb (twin-filament bulb) Plug connection at component

Screw connection at component

Electric motor

Connection, nondetachable

Diode

Internal connection in component

Zener diode

Light-emitting diode Fuse Electronic control unit/ component Switch, manually operated

Pushbutton switch, manually operated

Relay (electronically controlled)

Gauge

Switch, mechanically operated Cigar lighter Switch, pressure operated Spark plug Switch, temperaturedependent Relay Switch, multi-pin manually operated Screening Resistor Coil Resistor, variable Lambda probe Resistance, temperature dependent

IV

Symbols for current flow diagrams

Edition 07.03 S00.5324.00.20

Symbols for current flow diagrams

Battery

Wiper motor, 2-stage

Heated rear window

Starter Heating resistor/glow plug

Alternator

Solenoid valve

Aerial

Ignition coil

Digital clock

Multifunction display

Loudspeaker

Thermo-fuse

Knock sensor

Hall sender Speedometer sender

Interior light Coil spring in steering wheel

Horn

Edition 07.03 S00.5324.00.20

Wiring junction

Symbols for current flow diagrams

V

Terminal designations Terminal 15

Switched positive behind battery (output contact from ignition/starter switch)

15a

Switched positive from ignition/starter switch (behind fuse)

30

Output directly from battery positive

30a

Output directly from battery positive (behind fuse)

30al

Positive of onboard supply control unit for interior lights switched off

31

Battery negative, or vehicle earth

50

Output contact from ignition/starter switch for starter

53c

Wash system with automatic wipe

54

Brake lights

56a

Main beam

56aL

Left main beam

56b

Dipped beam

56bL

Left dipped beam

56bR

Right dipped beam

57L

Left side and tail light or parking light

57R

Right side and tail light or parking light

58

Side and tail light, licence plate light

58b

Illumination of switches and dash panel insert (set illumination intensity)

58L

Left side light, tail light and parking light

58R

Right side light, tail light and parking light

71

Input for horn

75

Output contact from ignition/starter switch for switching off consumers to relieve battery when starting

75al

Positive switched off via heater switch or ignition/starter switch when starting engine

75x

Switched-off positive behind relief relay of battery when starting (relay controlled via ignition/starter switch)

86s

Switched-off positive by ignition/starter switch when key removed completely from ignition/ starter switch

87

Output contact from fuel pump relay or from diesel direct injection system relay

87a

Output contact from fuel pump relay or from diesel direct injection system relay behind fuse

CAN - H CAN - L

K

Data bus between drive control units (engine, automatic gearbox, ABS, dash panel insert, onboard supply control unit,...)

}

CAN - H, Komfort CAN - L, Komfort

VI

Meaning

}

Convenience data bus between convenience system control units (door control units, air conditioning system, dash panel insert, onboard supply control unit,...) Diagnostic cable between control units

Terminal designations

Edition 07.03 S00.5324.00.20

Structure and explanation of the fault finding programs Starting from the reported complaint, it is shown step by step what and how it is checked, in order to be sure to find the fault in a rational manner. The fault finding programs in their written and symbolic form always have the same structure.

Structure of a test step: What is checked/ Fault assertion How it is checked Test results

▼

▼

Cause of fault/Repair instruction

for next test

An example for a fault finding program: Check voltage supply of terminal 30 -

Connect battery-earth strap. Switch on side light and low beam light switch. Switch steering column switch into low beam position. Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Connect black measuring tip to the vehicle mass. Connect red measuring tip to contact 2 of connector at wiring harness. Voltage O.K.

Voltage N.O.K.

▼

▼

Check wiring from the connector to the lamp or replace defective lamp -M29-

for next test

Edition 07.03 S00.5324.00.20

Structure and explanation of the fault finding programs

VII

Service Supplement

.)*1)

Binder No. 10

Workshop Manual: Current Flow Diagrams, Electrical Fault Finding and Fitting Locations Model Year 2003 þ

No. 1

Edition: 06.04

Please note the following points regarding this supplement: -

Replace the pages 1, 5, 7, 11 of the previous table of contents. File in the pages 13, 15, 17, 19 of the table of contents. Replace Current Flow Diagrams 1/11, 7/5, 32/1, 36/1, 37/1, 53/5, 59/5. File Current Flow Diagrams 61 - 75. Replace Fitting Locations 1/1, 1/3, 1/5, 2/3, 2/5, 2/9. File Fitting Locations 1/7, 1/9.

Repairs to the wiring looms must only be carried out by using the service case.

Printed in Czech Republic S00.5324.01.20

___

1

___

Contents

Model Year 2003

Model Year 2003 Fitting Locations

No.

● Fuse holder, fuse holder on battery, relay holder ......................................................................................................... 1/1 ● Multi-pin connectors ........................................................................................................................................................ 2/1 ● Earth points ....................................................................................................................................................................... 3/1

Fault Finding Programmes

No.

Note: Measures for rectifying current faults of specific models see „Technical Service Handbook“. ● Battery discharges by itself ............................................................................................................................................. 1/1 ● Starter does not rotate ..................................................................................................................................................... 2/1 ● Windscreen wiper system faulty ..................................................................................................................................... 3/1 ● Windscreen washer system faulty ................................................................................................................................. 4/1 ● Wiper intermittent operation faulty ................................................................................................................................ 5/1 ● Testing rear window wiper .............................................................................................................................................. 6/1 ● Heated rear window does not operate ........................................................................................................................... 7/1 ● Testing fresh air blower ................................................................................................................................................... 8/1 ● Testing fresh and recirculated air flap positioning motor ........................................................................................... 9/1 ● Testing heater element for additional heater (PTC) -Z35- ......................................................................................... 10/1 ● Electrically adjustable and heated exterior mirrors (without power windows) .............................................................................................................................................. 11/1 ● Testing electric sliding roof .......................................................................................................................................... 12/1 ● Testing seat heater ......................................................................................................................................................... 13/1 ● Testing headlight washer system ................................................................................................................................. 14/1 ● Testing light failure indicator ........................................................................................................................................ 15/1

___

2

___

Edition 07.03 S00.5324.00.20

Model Year 2003

Contents

Current Flow Diagrams

No.

● Basic equipment - FABIA, from August 2002

1/1

-

Battery, fuse holder on battery ....................................................................................................................................... 1/2 Ignition/starter switch, fuse holder ................................................................................................................................. 1/3 Relief relay for X contact, fuse holder on battery .......................................................................................................... 1/4 Light switch .................................................................................................................................................................... 1/5 Headlight dipper/flasher switch, Headlight, Fuse holder (not valid for vehicles with gas discharge lamps) .............. 1/6 Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light ........................ 1/7 Lighting rheostat - switches and instruments, headlamp beam control adjuster, headlamp beam control, headlamp beam control adjuster, fuse holder (does not apply to models with gas discharge bulbs) ........................ 1/8 Brake light switch, left tail light, fuse holder .................................................................................................................. 1/9 Right tail light, centre high-mounted brake light, licence plate light ........................................................................... 1/10 Glove box light, luggage compartment light ................................................................................................................. 1/11 Windshield wiper and rear window wiper switch, windshield wiper motor (not applicable to Notchback) ................ 1/12 Windshield wiper and rear window wiper switch, windshield wiper motor (applicable only to Notchback) .............. 1/13 Rear window wiper motor, windscreen and rear window washer pump .................................................................... 1/14 Button for heated rear window, heated rear window ................................................................................................... 1/15 Heating ......................................................................................................................................................................... 1/16 Front interior light, door contact switch (does not apply to models with central locking) .......................................... 1/17 Horn .............................................................................................................................................................................. 1/18 Socket, cigarette lighter, ashtray illumination, glove box light, fuse holder ............................................................... 1/19 Reversing lights switch, luggage compartment socket, fuse holder .......................................................................... 1/20 Dash panel insert, control unit in dash panel insert, warning lights, digital clock ...................................................... 1/21 Dash panel insert, Control unit in dash panel insert, Warning lamps, Coolant temperature gauge, Rev. Counter, Driver side belt switch ........................................................................................................................... 1/22 Immobiliser, dash panel insert, control unit in dash panel insert, warning lights, buzzer/gong ................................ 1/23 Dash panel insert, Control unit in dash panel insert, Warning lamps, Handbrake warning switch, Brake fluid level warning contact, Coolant shortage indicator sender, Windscreen washer fluid level sender ....... 1/24 Dash panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Brake lining/pad wear sender ...................................................................................................................................... 1/25 Plug connection for radio or navigation system control unit, plug connection for diagnostic socket, databus diagnostic interface ........................................................................................................................................ 1/26

Current Flow Diagrams

No.

● 1.2 l - Simos 3 PD/40 kW), engine code AWY, from August 2002 until October 2002

2/1

-

Starter, alternator, fuse holder on battery, radiator fan (models without trailer coupling) ............................................ 2/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan, (models with trailer coupling) ............................... 2/3 Simos control unit, injectors, engine speed sender, coolant temperature sender ....................................................... 2/4 Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................... 2/5 Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................ 2/6 Simos control unit, knock sensor I, camshaft position sender ..................................................................................... 2/7 Simos control unit, throttle valve control unit, Simos power supply relay .................................................................... 2/8 Simos control unit, Oil level/oil temperature sender, Ignition system .......................................................................... 2/9 Fuel pump relay, fuse holder ....................................................................................................................................... 2/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display .......................................................... 2/11

Edition 07.03 S00.5324.00.20

___

3

___

Contents

Model Year 2003

Current Flow Diagrams

No.

● 1.4 l - Simos 3 PB/44 kW, engine code AZE, from August 2002 up to October 2002

3/1

● 1.4 l - Simos 3 PB/50 kW, engine code AME, from August 2002 up to October 2002

3/1

- Starter, alternator, radiator fan, fuse holder on battery ................................................................................................. - Simos control unit, injectors, engine speed sender, coolant temperature sender ....................................................... - Simos control unit, lambda probe, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve ............................................................................................................................ - Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................ - Simos control unit, knock sensor I, camshaft position sender ..................................................................................... - Simos control unit, throttle valve control unit, ignition system ...................................................................................... - Fuel pump relay, fuse holder ......................................................................................................................................... - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...........................................................

3/2 3/3 3/4 3/5 3/6 3/7 3/8 3/9

Current Flow Diagrams

No.

● 1.4 l - Simos 3 PA/44 kW, engine code AZF, from August 2002 up to October 2002

4/1

● 1.4 l - Simos 3 PA/50 kW, engine code AQW, from August 2002 up to October 2002

4/1

- Starter, alternator, radiator fan, fuse holder on battery ................................................................................................. - Simos control unit, injectors, engine speed sender, coolant temperature sender ....................................................... - Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................... - Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................ - Simos control unit, knock sensor I, camshaft position sender ..................................................................................... - Simos control unit, throttle valve control unit, ignition system ...................................................................................... - Fuel pump relay, fuse holder ......................................................................................................................................... - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...........................................................

4/2 4/3 4/4 4/5 4/6 4/7 4/8 4/9

Current Flow Diagrams

No.

● 1.4 l - 4MV/55 kW, engine code BBY, from August 2002 up to October 2002

5/1

● 1.4 l - 4MV/74 kW, engine code BBZ, from August 2002 up to October 2002

5/1

- Starter, alternator, radiator fan, fuse holder on battery ................................................................................................. 5/2 - 4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas recirculation potentiometer ....................................................................................................................... 5/3 - 4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, actuated charcoal filter system solenoid valve .......................................... 5/4 - 4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................... 5/5 - 4MV control unit, knock sensor I, camshaft position sender ........................................................................................ 5/6 - 4MV control unit, throttle valve control unit ................................................................................................................... 5/7 - 4MV control unit, ignition system ................................................................................................................................... 5/8 - Fuse holder .................................................................................................................................................................... 5/9 - Fuel pump relay, fuel feed relay .................................................................................................................................. 5/10 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display .......................................................... 5/11

___

4

___

Edition 07.03 S00.5324.00.20

Model Year 2003

Contents

Current Flow Diagrams

No.

l 2.0 l - Motronic/85 kW), engine code AZL, from August 2002 up to October 2002

6/1

-

Starter, alternator, fuse holder on battery ................................................................................................................... 6/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan .............................................................................. 6/3 Motronic control unit, injectors, engine speed sender, coolant temperature sender .................................................. 6/4 Motronic control unit, lambda probe, lambda probe downstream of catalytic converter, air mass meter and intake manifold temperature sender, activated charcoal filter system solenoid valve ............................................... 6/5 Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ............................ 6/6 Motronic control unit, knock sensor I, knock sensor II, camshaft position sender ..................................................... 6/7 Motronic control unit, throttle valve control unit, secondary air pump motor .............................................................. 6/8 Motronic control unit, ignition system, secondary air pump relay ............................................................................... 6/9 Fuse holder ............................................................................................................................................................... 6/10 Fuel pump relay, fuel feed relay ................................................................................................................................ 6/11 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ....................................................... 6/12

Current Flow Diagrams

No.

l 1.9 l - SDI/47 kW, engine code ASY, from August 2002 up to October 2002

7/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................... - Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve .................................................. - Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch ......................................................................................................... - Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity positioner ...................................................................................................................................................... - Diesel direct injection system control unit, Engine speed sender, Coolant temperature sender, Needle lift sender, Intake manifold flap motor ............................................................................................................................. - Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder .................................................................................................................................................................. - Diesel direct injection system relay, fuse holder ......................................................................................................... - Dash Panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Speedometer sender, Fuel gauge, Speedometer, Odometer display ................................................................................................................................

7/2 7/3 7/4 7/5 7/6 7/7 7/8 7/9

Current Flow Diagrams

No.

l 1.9 l - TDI with unit injector/74 kW, engine identification characters ATD, from August 2002 up to October 2002

8/1

-

Starter, alternator, fuse holder on battery ................................................................................................................... 8/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan .............................................................................. 8/3 Diesel direct injection system control unit, glow plug relay, glow plugs ..................................................................... 8/4 Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .......................................................................................................................................................................... 8/5 Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve ...................................................................................................................................................... 8/6 Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ........................................................................... 8/7 Diesel direct injection system control unit, unit injectors ............................................................................................ 8/8 Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder .................................................................................................................................................................. 8/9 Fuel pump relay, diesel direct injection system relay, fuse holder ........................................................................... 8/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ........................................................ 8/11

Edition 06.04 S00.5324.01.20

___

5

___

Contents

Model Year 2003

Current Flow Diagrams

No.

● 1.2 l - Simos 3 Unit Injection/40 kW, engine code AWY, from November 2002 -

48/1

Starter, alternator, fuse holder on battery, radiator fan (models without trailer coupling) .......................................... 48/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan, (models with trailer coupling) ............................. 48/3 Simos control unit, injectors, engine speed sender, coolant temperature sender ..................................................... 48/4 Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................. 48/5 Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .............................. 48/6 Simos control unit, knock sensor I, camshaft position sender ................................................................................... 48/7 Simos control unit, throttle valve control unit, Simos power supply relay .................................................................. 48/8 Simos control unit, Oil level/oil temperature sender, Ignition system ........................................................................ 48/9 Fuel pump relay, fuse holder ..................................................................................................................................... 48/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ....................................................... 48/11

-

Current Flow Diagrams

No.

● 1.4 l - Simos 3 PB/44 kW, engine code AZE, from August 2002 up to October 2003

49/1

● 1.4 l - Simos 3 PB/50 kW, engine code AME, from August 2002 up to October 2003

49/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................... - Simos control unit, injectors, engine speed sender, coolant temperature sender ..................................................... - Simos control unit, Lambda probe, Intake manifold pressure and intake manifold temperature sender, Activated charcoal filter system solenoid valve .......................................................................................................... - Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .............................. - Simos control unit, knock sensor I, camshaft position sender ................................................................................... - Simos control unit, throttle valve control unit, ignition system .................................................................................... - Fuel pump relay, fuse holder ....................................................................................................................................... - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display .........................................................

Current Flow Diagrams

49/2 49/3 49/4 49/5 49/6 49/7 49/8 49/9

No.

● 1.4 l - Simos 3 PA/44 kW, engine code AZF, from November 2002 up to October 2003

50/1

● 1.4 l - Simos 3 PA/50 kW, engine code AQW, from November 2002 up to October 2003

50/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................... - Simos control unit, injectors, engine speed sender, coolant temperature sender ..................................................... - Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................. - Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .............................. - Simos control unit, knock sensor I, camshaft position sender ................................................................................... - Simos control unit, throttle valve control unit, ignition system .................................................................................... - Fuel pump relay, fuse holder ....................................................................................................................................... - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display .........................................................

___

6

___

50/2 50/3 50/4 50/5 50/6 50/7 50/8 50/9

Edition 07.03 S00.5324.00.20

Model Year 2003

Contents

Current Flow Diagrams

No.

l 1.4 l - 4MV/55 kW, engine identification letters BBY, form November 2002

51/1

l 1.4 l - 4MV/74 kW, engine identification letters BBZ, from November 2002

51/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................. 51/2 - 4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas recirculation potentiometer ........................................................................................................ 51/3 - 4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, actuated charcoal filter system solenoid valve ....................................... 51/4 - 4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................ 51/5 - 4MV control unit, knock sensor I, camshaft position sender .................................................................................... 51/6 - 4MV control unit, throttle valve control unit ............................................................................................................... 51/7 - 4MV control unit, ignition system .............................................................................................................................. 51/8 - Fuse holder ............................................................................................................................................................... 51/9 - Fuel pump relay, fuel feed relay ............................................................................................................................. 51/10 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...................................................... 51/11

Current Flow Diagrams

No.

l 2.0 l - Motronic/85 kW, engine identification letters AZL, from November 2002 -

52/1

Starter, alternator, fuse holder on battery ................................................................................................................. 52/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan ............................................................................ 52/3 Motronic control unit, injectors, engine speed sender, coolant temperature sender ................................................ 52/4 Motronic control unit, Lambda probe, Lambda probe after catalytic converter, Air mass meter and intake manifold temperature sender, Activated charcoal filter system solenoid valve ........................................................ 52/5 Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .......................... 52/6 Motronic control unit, knock sensor I, knock sensor II, camshaft position sender ................................................... 52/7 Motronic control unit, throttle valve control unit, secondary air pump motor ............................................................ 52/8 Motronic control unit, ignition system, secondary air pump relay ............................................................................. 52/9 Fuse holder ............................................................................................................................................................. 52/10 Fuel pump relay, fuel feed relay .............................................................................................................................. 52/11 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ..................................................... 52/12

Current Flow Diagrams

No.

l 1.9 l - SDI/47 kW, engine identification letters ASY, from November 2002

53/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................. - Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve ................................................ - Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch ....................................................................................................... - Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity positioner .................................................................................................................................................... - Diesel direct injection system control unit, Engine speed sender, Coolant temperature sender, Needle lift sender, Intake manifold flap motor ........................................................................................................................... - Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................ - Diesel direct injection system relay, fuse holder ....................................................................................................... - Dash Panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Speedometer sender, Fuel gauge, Speedometer, Odometer display ..............................................................................................................................

Edition 06.04 S00.5324.01.20

___

7

53/2 53/3 53/4 53/5 53/6 53/7 53/8 53/9

___

Contents

Model Year 2003

Current Flow Diagrams

No.

● 1.9 l - TDI with Pump nozzle unit/74 kW, engine identification characters ATD, from November 2002 -

54/1

Starter, alternator, fuse holder on battery .................................................................................................................... 54/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan .............................................................................. 54/3 Diesel direct injection system control unit, glow plug relay, glow plugs ..................................................................... 54/4 Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ....................................................................................................................................................... 54/5 Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve ........................................................................................................................................................ 54/6 Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ........................................................................... 54/7 Diesel direct injection system control unit, unit injectors ............................................................................................ 54/8 Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................... 54/9 Fuel pump relay, diesel direct injection system relay, fuse holder ........................................................................... 54/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ....................................................... 54/11

-

-

Current Flow Diagrams ● 1.2 l - Simos 3 PB/47 kW, engine code AZQ, from February 2003 -

No. 58/1

Starter, alternator, fuse holder on battery, radiator fan (models without trailer coupling) .......................................... 58/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan, (models with trailer coupling) ............................. 58/3 Simos control unit, injectors, engine speed sender, coolant temperature sender ..................................................... 58/4 Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................. 58/5 Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .............................. 58/6 Simos control unit, knock sensor I, camshaft position sender ................................................................................... 58/7 Simos control unit, throttle valve control unit, Simos power supply relay .................................................................. 58/8 Simos control unit, exhaust gas recirculation valve, exhaust gas recirculation potentiometer, oil level/oil temperature sender, ignition system ......................................................................................................... 58/9 Fuse holder ................................................................................................................................................................ 58/10 Fuel pump relay, fuel feed relay ................................................................................................................................ 58/11 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ....................................................... 58/12

-

Current Flow Diagrams ● 1.4 l - TDI with unit injector/55 kW, engine identification characters AMF, from May 2003

No. 59/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................... 59/2 - Diesel direct injection system control unit, glow plug relay, glow plugs ..................................................................... 59/3 - Control unit for Diesel direct injection system, Accelerator pedal position sender, Brake pedal switch, Clutch pedal switch, Oil level/oil temperature sender ................................................................................................. 59/4 - Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve ........................................................................................................................................................ 59/5 - Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ........................................................................... 59/6 - Diesel direct injection system control unit, unit injectors ............................................................................................ 59/7 - Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................... 59/8 - Fuel pump relay, diesel direct injection system relay, fuse holder ............................................................................. 59/9 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ....................................................... 59/10

___

8

___

Edition 07.03 S00.5324.00.20

Model Year 2003

Contents

Current Flow Diagrams

No.

● 1.9 l - TDI with unit injector/96 kW, engine identification characters ASZ, from June 2003 -

-

60/1

Starter, alternator, fuse holder on battery .................................................................................................................... 60/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan .............................................................................. 60/3 Diesel direct injection system control unit, glow plug relay, glow plugs ..................................................................... 60/4 Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................................................................................................................................................. 60/5 Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve ........................................................................................................................................................ 60/6 Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ........................................................................... 60/7 Control unit for Diesel direct injection system, Unit injector valves, Oil level/oil temperature sender ...................... 60/8 Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................... 60/9 Fuel pump relay, diesel direct injection system relay, fuse holder ........................................................................... 60/10 Dash Panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Fuel pump, Fuel gauge, Speedometer sender, Odometer display ....................................................................................................................................................... 60/11

Edition 07.03 S00.5324.00.20

___

9

___

Contents Current Flow Diagrams

Model Year 2003 No.

● Air conditioning, from August 2002 ............................................................................................................................. 32/1 ● Anti-lock brake system (ABS) with electronic differential lock (EDL), traction control system (TCS), electronic stabilisation program (ESP), from August 2002 ...................................................................................... 12/1 ● Antilock brake system (ABS) Antilock brake system (ABS) with electronic differential lock (EDL) and traction control system (TCS), from August 2002 ...................................................................................................... 11/1 ● Anti-theft alarm system, from August 2002 ................................................................................................................ 24/1 ● Automatic gearbox, from August 2002 ........................................................................................................................ 17/1 ● Bulb failure indicator, from August 2002 ..................................................................................................................... 29/1 ● CAN databus networking - Drive, from August 2002 ................................................................................................. 46/1 ● CAN-Bus Networking - Convenience, from August 2002 .......................................................................................... 47/1 ● Central locking Door warning lamps, from November 2002 ................................................................................................................ 55/1 ● Central locking Door warning lamps, from August 2002 up to October 2002 ................................................................................... 18/1 ● Cruise control system, from August 2002 ................................................................................................................... 22/1 ● Daytime running lights- gas discharge lights, from August 2002 ............................................................................ 27/1 ● Daytime running lights, from August 2002 (does not apply to models with gas discharge lights) ............................................................................................... 26/1 ● Driver and Front passenger airbag, from August 2002 ............................................................................................. 13/1 (Without deactivation of the front passenger airbag) ● Driver and Front passenger airbag, from August 2002 ............................................................................................. 14/1 (With deactivation of the front passenger airbag) ● Electric sliding roof, from August 2002 ....................................................................................................................... 30/1 ● Fog light, from November 2002 .................................................................................................................................... 56/1 ● Fog light, from August 2002 up to October 2002 ....................................................................................................... 28/1 ● Front and rear power windows Heated and adjustable exterior mirrors, from August 2002 ...................................................................................... 20/1 ● Front power windows Heated and adjustable exterior mirrors, from August 2002 ...................................................................................... 19/1 ● Gas discharge lights, from August 2002 ..................................................................................................................... 25/1 ● Headlight range control for vehicles Junior and Classic, from August 2002 ......................................................... 43/1 ● Headlight washer system, from August 2002 ............................................................................................................. 38/1 ● Heated and adjustable exterior mirrors (without power windows), from August 2002 ............................................................................................................. 21/1 ● Heated seats, from August 2002 .................................................................................................................................. 31/1 ● Heated washer nozzles, from August 2002 ................................................................................................................. 39/1

___

10

___

Edition 07.03 S00.5324.00.20

Model Year 2003

Contents

Current Flow Diagrams

No.

● Luggage compartment light - Praktik, from August 2002 ......................................................................................... 44/1 ● Mobile telephone preinstallation, from August 2002 ................................................................................................. 36/1 ● Multifunction display (MFD), from August 2002 ......................................................................................................... 23/1 ● Navigation system with CD changer, from August 2002 ........................................................................................... 35/1 ● Parking aid, from August 2002 ..................................................................................................................................... 41/1 ● Power assisted steering (KOYO), from August 2002 ................................................................................................. 10/1 ● Power assisted steering (TRW), from August 2002 ..................................................................................................... 9/1 ● Radio system with CD changer, from August 2002 ................................................................................................... 34/1 ● Radio system, from August 2002 ................................................................................................................................. 33/1 ● Rear reading lights, from November 2002 .................................................................................................................. 57/1 ● Rear reading lights, from August 2002 up to October 2002 ..................................................................................... 42/1 ● Side airbag, from August 2002 ..................................................................................................................................... 15/1 (Without deactivation of the front passenger airbag) ● Side airbag, from August 2002 ..................................................................................................................................... 16/1 (With deactivation of the front passenger airbag) ● Telephone preinstallation 2 - Cullmann, from August 2002 ...................................................................................... 37/1 ● Trailer coupling, from August 2002 .............................................................................................................................. 40/1 ● Windscreen wiper motor for 1.4 l/50 kW with Cruise control system without ABS, from August 2002 up to April 2003 ............................................................................................................................... 45/1

Edition 07.03 S00.5324.00.20

___

11

___

Contents

Model Year 2004

Model Year 2004 Fitting Locations

No.

l Fuse holder, fuse holder on battery, relay holder ...................................................................................................... 1/1 l Multi-pin connectors ..................................................................................................................................................... 2/1 l Earth points ................................................................................................................................................................... 3/1

Fault Finding Programmes

No.

Note: Measures for rectifying current faults of specific models see „Technical Service Handbook“. l Battery discharges by itself .......................................................................................................................................... 1/1 l Starter does not rotate .................................................................................................................................................. 2/1 l Windscreen wiper system faulty .................................................................................................................................. 3/1 l Windscreen washer system faulty ............................................................................................................................... 4/1 l Wiper intermittent operation faulty .............................................................................................................................. 5/1 l Testing rear window wiper ........................................................................................................................................... 6/1 l Heated rear window does not operate ........................................................................................................................ 7/1 l Testing fresh air blower ................................................................................................................................................ 8/1 l Testing fresh and recirculated air flap positioning motor ......................................................................................... 9/1 l Testing heater element for additional heater (PTC) -Z35- ....................................................................................... 10/1 l Electrically adjustable and heated exterior mirrors (without power windows) ..................................................... 11/1 l Testing electric sliding roof ........................................................................................................................................ 12/1 l Testing seat heater ...................................................................................................................................................... 13/1 l Testing headlight washer system .............................................................................................................................. 14/1 l Testing light failure indicator ..................................................................................................................................... 15/1

___

12

___

Edition 06.04 S00.5324.01.20

Model Year 2004

Contents

Current Flow Diagrams

No.

l Basic equipment - FABIA, from August 2003 -

61/1

Battery, fuse holder on battery .................................................................................................................................. 61/2 Ignition/starter switch, fuse holder ............................................................................................................................ 61/3 Relief relay for X contact, fuse holder on battery ..................................................................................................... 61/4 Light switch ............................................................................................................................................................... 61/5 Headlight dipper/flasher switch, Headlight, Fuse holder (not valid for vehicles with gas discharge lamps) ............ 61/6 Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light ..................... 61/7 Lighting rheostat - switches and instruments, headlamp beam control adjuster, headlamp beam control, headlamp beam control adjuster, fuse holder (does not apply to models with gas discharge bulbs) ...................... 61/8 Brake light switch, left tail light, fuse holder .............................................................................................................. 61/9 Right tail light, centre high-mounted brake light, licence plate light ....................................................................... 61/10 Glove box light, luggage compartment light ............................................................................................................ 61/11 Windshield wiper and rear window wiper switch, windshield wiper motor (not applicable to Notchback) ............. 61/12 Windshield wiper and rear window wiper switch, windshield wiper motor (applicable only to Notchback) ............ 61/13 Rear window wiper motor, windscreen and rear window washer pump ................................................................. 61/14 Button for heated rear window, heated rear window .............................................................................................. 61/15 Heating ................................................................................................................................................................... 61/16 Front interior light, door contact switch (does not apply to models with central locking) ....................................... 61/17 Horn ........................................................................................................................................................................ 61/18 Socket, cigarette lighter, ashtray illumination, glove box light, fuse holder ............................................................ 61/19 Reversing lights switch, luggage compartment socket, fuse holder ....................................................................... 61/20 Dash panel insert, control unit in dash panel insert, warning lights, digital clock .................................................. 61/21 Dash panel insert, Control unit in dash panel insert, Warning lamps, Coolant temperature gauge, Rev. Counter, Driver side belt switch ...................................................................................................................... 61/22 Immobiliser, dash panel insert, control unit in dash panel insert, warning lights, buzzer/gong .............................. 61/23 Dash panel insert, Control unit in dash panel insert, Warning lamps, Handbrake warning switch, Brake fluid level warning contact, Coolant shortage indicator sender, Windscreen washer fluid level sender .... 61/24 Dash panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Brake lining/pad wear sender ................................................................................................................................. 61/25 Plug connection for radio or navigation system control unit, plug connection for diagnostic socket, databus diagnostic interface (Gateway) ............................................................................................................................... 61/26

Current Flow Diagrams

No.

l 1.2 l - Simos 3 Unit Injection/40 kW, engine code AWY, from August 2003 -

62/1

Starter, alternator, fuse holder on battery, radiator fan (models without trailer coupling) ......................................... 62/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan, (models with trailer coupling) ............................ 62/3 Simos control unit, injectors, engine speed sender, coolant temperature sender ................................................... 62/4 Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................ 62/5 Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ............................. 62/6 Simos control unit, knock sensor I, camshaft position sender ................................................................................. 62/7 Simos control unit, throttle valve control unit, Simos power supply relay ................................................................. 62/8 Simos control unit, Oil level/oil temperature sender, Ignition system ....................................................................... 62/9 Fuel pump relay, fuse holder .................................................................................................................................. 62/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...................................................... 62/11

Edition 06.04 S00.5324.01.20

___

13

___

Contents Current Flow Diagrams l 1.2 l - Simos 3 PB/47 kW, engine code AZQ, from August 2003 -

Model Year 2004 No. 58/1

Starter, alternator, fuse holder on battery, radiator fan (models without trailer coupling) ......................................... 58/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan, (models with trailer coupling) ............................ 58/3 Simos control unit, injectors, engine speed sender, coolant temperature sender ................................................... 58/4 Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure intake manifold temperature sender , activated charcoal filter system solenoid valve ............................................ 58/5 Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ............................. 58/6 Simos control unit, knock sensor I, camshaft position sender ................................................................................. 58/7 Simos control unit, throttle valve control unit, Simos power supply relay ................................................................. 58/8 Simos control unit, exhaust gas recirculation valve, exhaust gas recirculation potentiometer, oil level/oil temperature sender, ignition system ....................................................................................................... 58/9 Fuse holder ............................................................................................................................................................. 58/10 Fuel pump relay, fuel feed relay .............................................................................................................................. 58/11 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ..................................................... 58/12

Current Flow Diagrams

No.

l 1.4 l - 4MV/55 kW, engine identification letters BBY, form August 2003

63/1

l 1.4 l - 4MV/74 kW, engine identification letters BBZ, form August 2003

63/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................. 63/2 - 4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas recirculation potentiometer ........................................................................................................ 63/3 - 4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, actuated charcoal filter system solenoid valve ....................................... 63/4 - 4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch ................................ 63/5 - 4MV control unit, knock sensor I, camshaft position sender .................................................................................... 63/6 - 4MV control unit, throttle valve control unit ............................................................................................................... 63/7 - 4MV control unit, Ignition system, Oil level/oil temperature sender ......................................................................... 63/8 - Fuse holder ............................................................................................................................................................... 63/9 - Fuel pump relay, fuel feed relay ............................................................................................................................. 63/10 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...................................................... 63/11

Current Flow Diagrams l 2.0 l - Motronic/85 kW, engine identification letters AZL, from August 2003

No. 64/1

- Starter, alternator, fuse holder on battery ................................................................................................................. 64/2 - Radiator fan control unit, radiator fan thermoswitch, radiator fan ............................................................................ 64/3 - Motronic control unit, Injectors, Engine speed sender, Coolant temperature sender, Oil level/oil temperature sender ....................................................................................................................................................................... 64/4 - Motronic control unit, Lambda probe, Lambda probe after catalytic converter, Air mass meter and intake manifold temperature sender, Activated charcoal filter system solenoid valve ........................................................ 64/5 - Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .......................... 64/6 - Motronic control unit, knock sensor I, knock sensor II, camshaft position sender ................................................... 64/7 - Motronic control unit, throttle valve control unit, secondary air pump motor ............................................................ 64/8 - Motronic control unit, ignition system, secondary air pump relay ............................................................................. 64/9 - Fuse holder ............................................................................................................................................................. 64/10 - Fuel pump relay, fuel feed relay .............................................................................................................................. 64/11 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ..................................................... 64/12

___

14

___

Edition 06.04 S00.5324.01.20

Model Year 2004

Contents

Current Flow Diagrams

No.

l 1.4 l - TDI with unit injector/55 kW, engine identification characters AMF, from August 2003

59/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................. 59/2 - Diesel direct injection system control unit, glow plug relay, glow plugs ................................................................... 59/3 - Control unit for Diesel direct injection system, Accelerator pedal position sender, Brake pedal switch, Clutch pedal switch, Oil level/oil temperature sender .......................................................................................................... 59/4 - Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve .................................................................................................................................................... 59/5 - Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ......................................................................... 59/6 - Diesel direct injection system control unit, unit injectors .......................................................................................... 59/7 - Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................ 59/8 - Fuel pump relay, diesel direct injection system relay, fuse holder ........................................................................... 59/9 - Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ..................................................... 59/10 Current Flow Diagrams

No.

l 1.9 l - SDI/47 kW, engine identification letters ASY, from August 2003

65/1

- Starter, alternator, radiator fan, fuse holder on battery ............................................................................................. 65/2 - Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve ................................................ 65/3 - Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch ....................................................................................................... 65/4 - Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity positioner .................................................................................................................................................... 65/5 - Diesel direct injection system control unit, engine speed sender, coolant temperature sender, needle motion sender ....................................................................................................................................................................... 65/6 - Diesel direct injection system control unit, Intake manifold flap motor, Oil level/oil temperature sender ................. 65/7 - Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................ 65/8 - Diesel direct injection system relay, fuse holder ....................................................................................................... 65/9 - Dash Panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Speedometer sender, Fuel gauge, Speedometer, Odometer display ............................................................................................................................ 65/10

Current Flow Diagrams

No.

l 1.9l - TDI with unit injection system/74 kW, engine code ATD, from August 2003 -

66/1

Starter, alternator, fuse holder on battery ................................................................................................................. 66/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan ............................................................................ 66/3 Diesel direct injection system control unit, glow plug relay, glow plugs ................................................................... 66/4 Control unit for Diesel direct injection system, Accelerator pedal position sender, Brake pedal switch, Clutch pedal switch, Oil level/oil temperature sender .......................................................................................................... 66/5 Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve .................................................................................................................................................... 66/6 Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ......................................................................... 66/7 Diesel direct injection system control unit, unit injectors .......................................................................................... 66/8 Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................ 66/9 Fuel pump relay, diesel direct injection system relay, fuse holder ......................................................................... 66/10 Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display ...................................................... 66/11

Edition 06.04 S00.5324.01.20

___

15

___

Contents

Model Year 2004

Current Flow Diagrams l 1.9 l - TDI with unit injector/96 kW, engine identification characters ASZ, from August 2003 -

___

No. 60/1

Starter, alternator, fuse holder on battery ................................................................................................................. 60/2 Radiator fan control unit, radiator fan thermoswitch, radiator fan ............................................................................ 60/3 Diesel direct injection system control unit, glow plug relay, glow plugs ................................................................... 60/4 Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch .............................................................................................................................................................. 60/5 Control unit for Diesel direct injection system, Coolant temperature sender, Fuel temperature sender, Exhaust gas recirculation valve, Charge pressure control solenoid valve, Variable intake manifold flap change-over valve .................................................................................................................................................... 60/6 Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender ......................................................................... 60/7 Control unit for Diesel direct injection system, Unit injector valves, Oil level/oil temperature sender ...................... 60/8 Low heating capacity relay, high heating capacity relay, additional heater heating element (PTC), additional fuse holder ................................................................................................................................................................ 60/9 Fuel pump relay, diesel direct injection system relay, fuse holder ......................................................................... 60/10 Dash Panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Fuel pump, Fuel gauge, Speedometer sender, Odometer display ..................................................................................................................................................... 60/11

16

___

Edition 06.04 S00.5324.01.20

Model Year 2004

Contents

Current Flow Diagrams

No.

l Trailer coupling, from August 2002 ........................................................................................................................... 40/1 l Antilock brake system (ABS) Antilock brake system (ABS) with electronic differential lock (EDL) and traction control system (TCS), from August 2003 .................................................................................................... 67/1 l Anti-lock brake system (ABS) with electronic differential lock (EDL), traction control system (TCS), electronic stabilisation program (ESP), from August 2003 ..................................................................................... 68/1 l Heated and adjustable exterior mirrors (without power windows), from August 2002 ........................................................................................................... 21/1 l Automatic gearbox, from August 2002 ..................................................................................................................... 17/1 l Heated washer nozzles, from August 2002 .............................................................................................................. 39/1 l CAN databus networking - Drive, from August 2002 ............................................................................................... 46/1 l CAN-Bus Networking - Convenience, from August 2003 ........................................................................................ 73/1 l Anti-theft alarm system, from August 2002 .............................................................................................................. 24/1 l Parking aid, from August 2002 ................................................................................................................................... 41/1 l Front power windows Heated and adjustable exterior mirrors, from August 2002 .................................................................................... 19/1 l Front and rear power windows Heated and adjustable exterior mirrors, from August 2002 .................................................................................... 20/1 l Electric sliding roof, from August 2002 .................................................................................................................... 30/1 l Driver and Front passenger airbag, from August 2002 ........................................................................................... 13/1 (Without deactivation of the front passenger airbag) l Driver and Front passenger airbag, from August 2002 ........................................................................................... 14/1 (With deactivation of the front passenger airbag) l Gas discharge lights, from August 2002 .................................................................................................................. 25/1 l Cruise control system, from August 2002 ................................................................................................................ 22/1 l Air conditioning, from August 2003 .......................................................................................................................... 69/1 l Luggage compartment light - Praktik, from August 2002 ....................................................................................... 44/1 l Bulb failure indicator, from August 2002 .................................................................................................................. 29/1 l Inspection of the rear seat backrest lock, as of August 2003 ................................................................................ 75/1 l Rear reading lights, from August 2003 ..................................................................................................................... 74/1 l Headlight range control for vehicles Junior and Classic, from August 2002 ....................................................... 43/1 l Multifunction display (MFD), from August 2002 ....................................................................................................... 23/1 l Navigation system with CD changer, from August 2003 ......................................................................................... 72/1 l Fog light, from November 2002 .................................................................................................................................. 56/1

Edition 06.04 S00.5324.01.20

___

17

___

Contents Current Flow Diagrams

Model Year 2004 No.

l Radio system, from August 2003 ............................................................................................................................... 70/1 l Radio system with CD changer, from August 2003 ................................................................................................. 71/1 l Side airbag, from August 2002 ................................................................................................................................... 15/1 (Without deactivation of the front passenger airbag) l Side airbag, from August 2002 ................................................................................................................................... 16/1 (With deactivation of the front passenger airbag) l Power assisted steering (KOYO), from August 2002 ............................................................................................... 10/1 l Power assisted steering (TRW), from August 2002 ................................................................................................... 9/1 l Headlight washer system, from August 2002 ........................................................................................................... 38/1 l Heated seats, from August 2002 ................................................................................................................................ 31/1 l Daytime running lights, from August 2002 (does not apply to models with gas discharge lights) ............................................................................................ 26/1 l Daytime running lights- gas discharge lights, from August 2002 .......................................................................... 27/1 l Mobile telephone preinstallation, from August 2002 ............................................................................................... 36/1 l Telephone preinstallation 2 - Cullmann, from August 2002 .................................................................................... 37/1 l Central locking Door warning lamps, from November 2002 .............................................................................................................. 55/1

___

18

___

Edition 06.04 S00.5324.01.20

Model Year 2004

Contents

List of Current Flow Diagrams, Fault Finding Programmes and Fitting Locations published so far Current Flow Diagram No.

Fault Finding Programme No.

Fitting Locations No.

Published under Article No.

1 - 60

1 - 15

1-3

S00.5324.00.20

61 - 75

-

-

S00.5324.01.20

Please always quote the Article No. when ordering Current Flow Diagrams, Fault Finding Programmes and Fitting Locations.

Edition 06.04 S00.5324.01.20

___

19

___

FABIA

Current Flow Diagram

Base equipment - FABIA, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 11

Edition 07.03 S00.5324.00.20

- X contact relief relay

No.1/1

No.1/2

Current Flow Diagram

FABIA

Battery, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B J359 J360 S163 T3a T12a T18a TV2

white black red brown green blue grey purple yellow orange

Battery Starter Low heating capacity relay High heating capacity relay Fuse -2- (30), in fuse holder on battery 3-pin connector, at left of bulkhead (grey) 12-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Terminal 30 junction, behind dash panel on left

11

-

12 14 A1 A32 A56 A57 A98 P1

*

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth point, in left of engine compartment, below battery (at side member) - Earth point, on gearbox - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Positive connection (30), in fuse holder on battery - Applies only to models with heating element (PTC)

Edition 07.03 S00.5324.00.20

FABIA

No.1/3

Current Flow Diagram

Ignition/starter switch, fuse holder

ws sw ro br gn bl gr li ge or

B D J361 T8a T11b T18a

-

Starter Ignition/starter switch Simos control unit 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (red) 18-pin connector, at electrical system control unit (brown)

A1

- Positive panel A2 - Positive panel A15 - Positive panel A21 - Positive panel A41 - Positive panel A56 - Positive panel A139 - Positive panel

*♦

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

connection (30a), in wiring loom behind dash connection (15), in wiring loom behind dash connection (15), in wiring loom behind dash connection (86s), in wiring loom behind dash connection (50), in wiring loom behind dash connection (30a), in wiring loom behind dash connection (15), in wiring loom behind dash

- applies only to engine codes AZQ - Does not apply to models with daytime running lights

No.1/4

Current Flow Diagram

FABIA

Relief relay for X contact, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J59 - Relief relay for X contact S268 - Fuse -10- (30), in fuse holder on battery T5a - 5-pin connector, at electrical system control unit (black) T6j - 6-pin connector, at electrical system control unit (brown) T12a - 12-pin connector, at left of bulkhead (white) T18a - 18-pin connector, at electrical system control unit (brown) 80 81 135

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel

199 332 335 354 357 606 A33 A34 P1

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Positive connection (30), in fuse holder on battery

Edition 07.03 S00.5324.00.20

FABIA

No.1/5

Current Flow Diagram

Light switch

ws sw ro br gn bl gr li ge or

E1 E23 L9 T6c

-

Light switch Front and rear fog light switch Lighting switch illumination bulb 6-pin connector, at electrical system control unit (black) T17a - 17-pin connector, at light switch

81

white black red brown green blue grey purple yellow orange

A43

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A56

- Positive connection (30a), in wiring loom behind dash panel

A11 A33 A34

♦

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- Does not apply to models with daytime running lights

No.1/6

Current Flow Diagram

FABIA

Low beam and headlight flasher switch, headlights, fuse holder, (does not apply to models with gas discharge lights)

ws sw ro br gn bl gr li ge or

E4 M1 M3 M5 M7 M29 M30 M31 M32 T10a T10b T11a T12a T12b 29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Headlight dipper/flasher switch Side light bulb, left Side light bulb, right Turn signal bulb, front left Turn signal bulb, front right Headlight dipped beam bulb, left Headlight main beam bulb, left Headlight dipped beam bulb, right Headlight main beam bulb, right 10-pin connector, at left headlight 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) 12-pin connector, at headlight dipper/flasher switch

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting)

85 A9

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

- Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom D152

*♦

- Does not apply to models with bulb failure indicator - Does not apply to models with daytime running lights

Edition 07.03 S00.5324.00.20

FABIA

No.1/7

Current Flow Diagram

Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light

ws sw ro br gn bl gr li ge or

E2 E19 E229 K6 L76 M18 M19 T2b T2c T6c

-

T6e T11a T12b T16a

-

Turn signal switch Parking light switch Button for hazard warning lights Hazard warning light system warning lamp Switch/button illumination Side turn signal bulb, left Side turn signal bulb, right 2-pin connector, at left side turn signal light 2-pin connector, at right side turn signal light 6-pin connector, at electrical system control unit (black) 6-pin connector, at hazard warning light pushbutton 11-pin connector, at left of bulkhead (white) 12-pin connector, at turn signal light switch 16-pin connector, at electrical system control unit (black)

white black red brown green blue grey purple yellow orange

81

- Earth connection, in wiring harness behind dash panel

85

A43

- Earth connection -1-, in wiring loom in left of engine compartment - Earth connection, in wiring harness behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

D57

- Connection (right turn signal light), in right engine compartment wiring loom - Connection (left turn signal light), in left engine compartment wiring loom

332 A5 A6

D58 ♦

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- Does not apply to models with daytime running lights

No.1/8

Current Flow Diagram

FABIA

Lighting rheostat - switches and instruments, headlight range control adjuster, headlight range control, headlight range control adjuster, fuse holder (does not apply to models fitted with gas discharge bulbs)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E20 E102 L54 T6d

-

T10a T10b T12a V48 V49

-

Switches and instruments lighting control Headlight range control adjuster Headlight range control regulator illumination 6-pin connector, at lighting control and headlight range control adjuster 10-pin connector, at left headlight 10-pin connector, at right headlight 12-pin connector, at left of bulkhead (white) Headlight range control motor, left Headlight range control motor, right

81 85 A3 A4 A9

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in wiring loom in left of engine compartment - Positive connection (58), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (56b), in wiring loom behind dash panel

A11

- Positive connection (58b), in wiring loom behind dash panel D96 - Connection (headlight range control), in engine compartment wiring loom D152 - Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.1/9

Current Flow Diagram

Brake light switch, left tail light, fuse holder

ws sw ro br gn bl gr li ge or

F F47 J... M6 M9 M16 M41 T4d T6l U10 61

-

Brake light switch Brake pedal switch Engine control units Turn signal bulb, rear left Brake light bulb, left Reversing light bulb left Left tail light and rear fog light bulb 4-pin connector, at brake pedal switch 6-pin connector, at left tail light Trailer socket

- Earth point, C-pillar left

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in rear interior wiring loom

A6 A18

- Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

=== -

* ** ♦

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to models with trailer coupling applies only to models with trailer coupling

No.1/10

FABIA

Current Flow Diagram

Right tail light, centre high-mounted brake light, licence plate light

ws sw ro br gn bl gr li ge or

M8 M10 M17 M25 M42 T2i T2j T2k T5d T6m T6o X 61

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Turn signal bulb, rear right Brake light bulb, right Reversing light bulb right Centre high-mounted brake light bulb Right tail light and rear fog light bulb 2-pin connector, at centre high-mounted brake light 2-pin connector, at licence plate light (left) 2-pin connector, at licence plate light (right) 5-pin connector, at left C pillar (pink) 6-pin connector, at right tail light 6-pin connector, at electrical system control unit (black) - Number plate light

86

- Earth connection -1-, in rear interior wiring loom

98

A18

- Earth connection, in engine compartment wiring harness - Positive connection (right turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

W11

- Connection (58), in tailgate wiring loom

A5

- Earth point, C-pillar left === -

* ** ♦

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to Saloon models applies only to Saloon models

Edition 07.03 S00.5324.00.20

FABIA

No.1/11

Current Flow Diagram

Glove box light, luggage compartment light

ws sw ro br gn bl gr li ge or

F5 F218 T2e T2f T2g T2o T4c T5e T6k W3 W6 W18 W35

-

Luggage compartment light switch Central locking switch, in tailgate lock 2-pin connector, at glove box light 2-pin connector, at left luggage compartment light 2-pin connector, at right luggage compartment light Connector, 2-pin, at luggage compartment light 4-pin connector, at boot/tailgate lock 5-pin connector, at left C pillar (black) 6-pin connector, at electrical system control unit (red) Luggage compartment light Glove box light Luggage compartment light, left Luggage compartment light, right

Edition 06.04 S00.5324.01.20

98 335 A23 Q22 W15

white black red brown green blue grey purple yellow orange

- Earth connection, in engine compartment wiring harness - Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection -1-, in tailgate wiring loom - Connection -1- (luggage compartment light), in rear wiring loom

nnn === -

* ** ♦

= = = = = = = = = =

Applies to tailgate models only with central locking Applies only to Estate applies only to Combi models with optional equipment Applies only to models with optional equipment applies only to Saloon models

No.1/12

Current Flow Diagram

FABIA

Windshield wiper and rear window wiper switch, windshield wiper motor (does not apply to Notchback models)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E22 E34 E38 T4a T5a

-

T5c

-

T6a

-

T6v T8b

-

T12a T16a T18a V

-

Intermittent wiper switch Rear wiper switch Intermittent wiper control 4-pin connector, at windscreen wiper motor 5-pin connector, at electrical system control unit (black) 5-pin connector, at electrical system control unit (brown) 6-pin connector, at windscreen wiper intermittent switch 6-pin connector, at left of bulkhead (green) 8-pin connector, at windscreen wiper intermittent switch 12-pin connector, at left of bulkhead (white) 16-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (brown) Windscreen wiper motor

80

- Earth connection, in wiring harness behind dash panel 81 - Earth connection, in wiring harness behind dash panel A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

*

- does not apply to 1.4/50 kW engine fitted with cruise control system but not fitted with ABS

Edition 07.03 S00.5324.00.20

FABIA

No.1/13

Current Flow Diagram

Windshield wiper and rear window wiper switch, windshield wiper motor (applies only to Notchback models)

ws sw ro br gn bl gr li ge or

E22 E38 T4a T5a

-

T5c

-

T6a

-

T6v T8b

-

T12a T16a T18a V

-

Intermittent wiper switch Intermittent wiper control 4-pin connector, at windscreen wiper motor 5-pin connector, at electrical system control unit (black) 5-pin connector, at electrical system control unit (brown) 6-pin connector, at windscreen wiper intermittent switch 6-pin connector, at left of bulkhead (green) 8-pin connector, at windscreen wiper intermittent switch 12-pin connector, at left of bulkhead (white) 16-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (brown) Windscreen wiper motor

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

80

- Earth connection, in wiring harness behind dash panel 81 - Earth connection, in wiring harness behind dash panel A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

*

- does not apply to 1.4/50 kW engine fitted with cruise control system but not fitted with ABS

No.1/14

FABIA

Current Flow Diagram

Rear window wiper motor, windscreen and rear window washer pump

ws sw ro br gn bl gr li ge or

T2a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- 2-pin connector, on windscreen and rear window washer pump T4b - 4-pin connector, at rear window wiper motor T5b - 5-pin connector, at left C pillar (brown) T12a - 12-pin connector, at left of bulkhead (white) V5 - Windscreen washer pump V12 - Rear window wiper motor V59 - Windscreen and rear window washer pump

98

- Earth connection, in engine compartment wiring harness A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

- applies only to Saloon models - does not apply to Saloon models ■ ■ ■ - does not apply to Notchback models

*♦

Edition 07.03 S00.5324.00.20

FABIA

No.1/15

Current Flow Diagram

Heated rear window pushbutton, heated rear window

ws sw ro br gn bl gr li ge or

E230 K10 L76 T5c

-

T5d T6b T6c

-

Z1

-

Button for heated rear window Heated rear window warning lamp Switch/button illumination 5-pin connector, at electrical system control unit (brown) 5-pin connector, at left C pillar (pink) 6-pin connector, at heated rear window button 6-pin connector, at electrical system control unit (black) Heated rear window

white black red brown green blue grey purple yellow orange

62

- Earth point, at right C pillar

98

- Earth connection, in engine compartment wiring harness - Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel

332 A11

*= = =

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- does not apply to Saloon models - applies only to Saloon models

No.1/16

Current Flow Diagram

FABIA

Heating

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E9 E159 F268 J248 J251 K114 L16 N24 T2u T4e T5h T6s

-

T10c T11c T16c V2 V154

-

Fresh air blower switch Fresh and recirculated air flap switch Heater element contact switch (PTC) Diesel direct injection system control unit Fresh/recirculating air flap control unit Fresh air and air recirculation operation warning lamp Fresh air control lighting Series resistor with overheating fuse 2-pin connector, at fresh air blower 4-pin connector, at fresh air blower series resistor 5-pin connector, at fresh air blower switch 6-pin connector, at fresh/recirculated air flap positioning motor 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (blue) 16-pin connector, at fresh air controls Fresh air blower Fresh and recirculated air flap motor

189

- Earth connection -1-, in fresh air blower wiring loom

606

- Earth point, under the centre console, near gear stick

A11

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (75al), in fresh air blower wiring loom

L13

*♦

- Applies only to models with heating element (PTC) - does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.1/17

Current Flow Diagram

Front interior light, door contact switch (does not apply to models with central locking)

ws sw ro br gn bl gr li ge or

F2 F3 J317 T3c T3d T3e T5a T6f T6g T6j T18a W W13 W19

-

Driver’s door contact switch Door contact switch, rear right Voltage supply relay terminal (30) 3-pin connector, at front interior light bulb 3-pin connector, at left front door contact switch 3-pin connector, at right front door contact switch 5-pin connector, at electrical system control unit (black) 6-pin connector, at left A pillar (brown) 6-pin connector, at right A pillar (brown) 6-pin connector, at electrical system control unit (brown) 18-pin connector, at electrical system control unit (brown) - Interior light, front - Front passenger’s reading light - Driver-side reading light

Edition 07.03 S00.5324.00.20

81 205 206 354 A23 A29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness of door assembly wiring driver side - Earth connection, in door wiring loom - passenger side - Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

- not valid for vehicles Junior - Applies only to models with heated and adjustable exterior mirrors (without power windows) ♦♦ - Applies only to models without optional equipment = = = - Applies only to models with optional equipment

*♦

No.1/18

FABIA

Current Flow Diagram

Horn

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F138 F231 H H1 H2 H7 T2l T2m T2n T5c

-

T5f

-

T5g T6p T12b T18a

-

Airbag coil connector Horn operation slip contact Horn plate Horn High tone horn Low tone horn 2-pin connector, at horn 2-pin connector, at low tone horn 2-pin connector, at high tone horn 5-pin connector, at electrical system control unit (brown) 5-pin connector, at airbag coil connector in steering wheel 5-pin connector, in steering wheel 6-pin connector, at left of bulkhead (red) 12-pin connector, at manual dipper switch 18-pin connector, at electrical system control unit (brown)

12a

- Earth point -2-, in engine compartment, on left below battery (at side member) 124 - Earth connection, in engine compartment wiring harness 335 - Earth connection, in wiring harness behind dash panel D143 - Connection (71), in left engine compartment wiring loom ■■■ -

* ** ♦

Applies Applies Applies Applies

only only only only

to models without optional equipment to models with airbag to models without airbag to models with optional equipment

Edition 07.03 S00.5324.00.20

FABIA

No.1/19

Current Flow Diagram

Socket, cigarette lighter, ashtray illumination, glove box light, fuse holder

ws sw ro br gn bl gr li ge or

J301 J560 L15 L42 T2d T3b U U1

-

AC control unit Door warning lights relay Earth point, at cylinder head Electric socket illumination bulb 2-pin connector, at bulb for ashtray illumination 3-pin connector, at socket Socket Cigarette lighter

white black red brown green blue grey purple yellow orange

80

- Earth connection, in wiring harness behind dash panel 354 - Earth connection, in wiring harness behind dash panel A4 - Positive connection (58b), in wiring loom behind dash panel A68 - Positive connection (30a, AC), in wiring loom behind dash panel A164 - Positive connection (30a), in wiring loom behind dash panel

* ** *** ♦ ♦♦ #

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

-

does not apply to models with air conditioning only for vehicles with door warning lamps (up to 10.02) not valid for vehicles Junior Applies only to models with air conditioning not valid for vehicles Junior und Classic Applies only to models with ESP

No.1/20

Current Flow Diagram

FABIA

Reversing lights switch, luggage compartment socket, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F4 - Reversing light switch J248 - Diesel direct injection system control unit J361 - Simos control unit T2h - 2-pin connector, at reversing light switch T3w - Plug connection, 3-pin, at 12 V socket, in luggage compartment T6n - 6-pin connector, at left of bulkhead (blue) T11b - 11-pin connector, at left of bulkhead (red) U5 - 12 V socket, in luggage compartment

86 A34 A70 A98

- Earth connection -1-, in rear interior wiring loom - Positive connection (75x), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system)

♦♦ === ■■■ -

* ** ♦

Applies only to engine codes AMF, ASY, ATD, ASZ Does not apply to models with automatic gearbox does not apply to models with air conditioning applies only to engine codes AZQ applies only to Combi and Notchback models does not apply to Notchback models

Edition 07.03 S00.5324.00.20

FABIA

No.1/21

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, digital clock

ws sw ro br gn bl gr li ge or

J285 K K1 K13 K17 K60 L10 T6r T8c T32a Y2

-

Control unit in dash panel insert Dash panel insert Main beam warning lamp Rear fog light warning lamp Fog light warning lamp Dipped beam and rear lights warning lamp Dash panel insert illumination bulb 6-pin connector, at left of bulkhead (brown) 8-pin connector, at dash panel insert 32-pin connector, at dash panel insert Digital clock

Edition 07.03 S00.5324.00.20

135

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A9

- Earth connection, in wiring harness behind dash panel - Earth connection (sender earth) -1-, in wiring harness behind dash panel - Earth connection (sender earth), in engine compartment wiring harness - Connection (56b), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

269 327

No.1/22

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, coolant temperature gauge, rev counter, driver side seat belt switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E24 G3 G5 J285 K K2 K18 K19 K47 K65 K75 K86 K92 K94 K116 K155 K166 T6w T16a

white black red brown green blue grey purple yellow orange

-

Driver side seat belt switch Coolant temperature gauge Rev counter Control unit in dash panel insert Dash panel insert Generator warning lamp Trailer operation warning lamp Seat belt warning system warning lamp ABS warning lamp Turn signal warning lamp, left Airbag warning lamp Traction control system warning lamp Servotronic warning lamp Turn signal warning lamp, right Tailgate unlocked warning light Warning lamp for stability programme Door open warning light 6-pin connector, below driver seat (red) 16-pin connector, at electrical system control unit (black) T32a - 32-pin connector, at dash panel insert

335

- Earth connection, in wiring harness behind dash panel A121 - Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel

*♦

♦♦

- Applies only to models with optional equipment - Applies only to models with TCS - Applies only to models with ESP

Edition 07.03 S00.5324.00.20

FABIA

No.1/23

Current Flow Diagram

Immobiliser, dash panel insert, control unit in dash panel insert, warning lights, buzzer/gong

ws sw ro br gn bl gr li ge or

D2 G17 H3 J285 J362 K K117 T2o T8c T16a

-

Immobiliser reader coil (at ignition/starter switch) Ambient temperature sensor Buzzer/gong Control unit in dash panel insert Immobiliser control unit Dash panel insert Immobiliser warning lamp 2-pin connector, at immobiliser reader coil 8-pin connector, at dash panel insert 16-pin connector, at electrical system control unit (black) T32a - 32-pin connector, at dash panel insert Y6 - Selector lever position indicator

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A43

- Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A83

- Connection (58, daytime running lights), in wiring loom behind dash panel on left

■■■ -

* ** ♦

Applies only to models with multifunction display Does not apply to models with daytime running lights Applies only to models with automatic gearbox applies only to models with daytime running lights

No.1/24

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, handbrake indicator switch, brake fluid level warning contact, low coolant level indicator sender, windscreen washer fluid level sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F9 F34 G32 G33 J285 K K7 K28 K106 T2p T2r T2s T2t T6p T11b T18b T32a

white black red brown green blue grey purple yellow orange

-

Handbrake warning switch Brake fluid level warning contact Coolant shortage indicator sender Windscreen washer fluid level sender Control unit in dash panel insert Dash panel insert Twin circuit brake and handbrake warning lamp Coolant temperature/coolant shortage warning lamp Washer water shortage warning lamp 2-pin connector, at low coolant level indicator sender 2-pin connector, at brake fluid level warning contact 2-pin connector, at handbrake indicator switch 2-pin connector, at windscreen washer fluid level sender 6-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (red) 18-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert

131

- Earth connection -2-, in engine compartment wiring harness 327 - Earth connection (sender earth), in engine compartment wiring harness 332 - Earth connection, in wiring harness behind dash panel A115 - Connection (handbrake indicator), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*♦

- Applies only to models with optional equipment - Applies only to models with ESP

Edition 07.03 S00.5324.00.20

FABIA

No.1/25

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, bonnet contact switch, brake pad wear sender

ws sw ro br gn bl gr li ge or

F266 G34 G37 J285 K K32 T2p T2r T2v T6p T6v T8c T16a

-

Vermin repellent system contact switch Left front brake wear indicator sender Rear right brake wear sender Control unit in dash panel insert Dash panel insert Brake pad warning lamp Connector, 2-pin, at rear right brake pad wear sender Connector, 2-pin, at front left brake pad wear sender 2-pin connector, at bonnet contact switch 6-pin connector, at left of bulkhead (red) 6-pin connector, at left of bulkhead (green) 8-pin connector, at dash panel insert 16-pin connector, at electrical system control unit (black)

Edition 07.03 S00.5324.00.20

13

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in front right of engine compartment

327

- Earth connection (sender earth), in engine compartment wiring harness B268 - Connection -1- (brake pad wear), in rear right wiring loom B269 - Connection -2- (brake pad wear), in rear right wiring loom ♦♦ === -

*♦

does not apply to models with anti-theft alarm system applies only to models fitted with disc brakes at rear applies only to models fitted with drum brakes at rear applies only to models with extended service interval (ESI)

No.1/26

Current Flow Diagram

FABIA

Plug connection for radio or navigation system control unit, plug connection for diagnostic socket, databus diagnostic interface

ws sw ro br gn bl gr li ge or

J533 T8d

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Databus diagnostic interface - 8-pin connector, for radio or navigation system control unit (black) T16a - 16-pin connector, at electrical system control unit (black) T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T18a - 18-pin connector, at electrical system control unit (brown)

335 606 A11 A21 A27 A46 A76

- Earth connection, in wiring harness behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.2/1

1.2 l - Simos 3 Unit Injection/40 kW, engine code AWY, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

4

- Fuel pump relay

12

- Simos power supply relay

No.2/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery, radiator fan (models not fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S177 S180 T1a T2v T3h T3i T6n T8a T11a T14a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T18a - 18-pin connector, at electrical system control unit (brown)

V7 12a P1

- Radiator fan - Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan dependent on optional

equipment (does not apply to models fitted with air conditioning or fitted with trailer coupling) = = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

Edition 07.03 S00.5324.00.20

FABIA

No.2/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan (models fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

= = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

No.2/4

Current Flow Diagram

FABIA

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 T2a T2b T2c T2y T3m T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

A121 A122 D140 D159 D160

- Connection panel on - Connection panel - Connection loom - Connection loom - Connection loom

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (injectors), in engine assembly wiring (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

Edition 07.03 S00.5324.00.20

FABIA

No.2/5

Current Flow Diagram

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4i T4k

-

T11a T11b T14a -

T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender 4-pin connector, close to lambda probe Connector, 4-pin, close to lambda probe downstream of catalytic converter 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom E28 - Connection (lambda probe heater), in engine compartment wiring loom A130

*■ ■ ■

- not valid for EU-2 DDK - Applies only to models with CCS

No.2/6

Current Flow Diagram

FABIA

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.2/7

Current Flow Diagram

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G163 J361 T2e T3j T6n T11b T14a

-

Knock sensor I Camshaft position sender Simos control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom

No.2/8

Current Flow Diagram

FABIA

Simos control unit, throttle valve control unit, Simos power supply relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit J363 - Simos power supply relay T6r - 6-pin connector, at left of bulkhead (brown) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T11c - 11-pin connector, at left of bulkhead (blue) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

354

- Earth connection -2-, in wiring loom behind dash panel A74 - Positive connection (15a), in wiring loom behind dash panel D106 - Connection -4- (87a), in wiring loom on left of engine compartment

Edition 07.03 S00.5324.00.20

FABIA

No.2/9

Current Flow Diagram

Simos control unit, Oil level/oil temperature sender, Ignition system

ws sw ro br gn bl gr li ge or

G266 J361 N70 N127 N291 Q T3f T4a T4b T4c T14a

-

Oil level/oil temperature sender Simos control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Spark plugs Connector, 3-pin, at oil level/oil temperature sender Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

19

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom - Earth connection -2-, in engine pre-assembly wiring loom - Earth connection (ignition coils), in engine preassembly wiring loom - Connection (87a), in engine preassembly wiring loom

283 304 F36

*

- applies only to models with extended service interval (ESI)

No.2/10

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A32 A98 A99 A139

D52

*

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom - applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.2/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

*

- applies only to models with extended service interval (ESI)

FABIA

Current Flow Diagram

No.3/1

1.4 l - Simos 3 PB/44 kW, engine code AZE, from August 2002 1.4 l - Simos 3 PB/50 kW, engine code AME, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 4

Edition 07.03 S00.5324.00.20

- Fuel pump relay

No.3/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.3/3

Current Flow Diagram

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 N33 T2a T2b T2c T2d T2x T2y T14a

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at engine speed sender 2-pin connector, at coolant temperature sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D140

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (injectors), in engine assembly wiring loom

No.3/4

Current Flow Diagram

FABIA

Simos control unit, lambda probe, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 - Lambda probe G71 - Intake manifold pressure sender G72 - Intake manifold temperature sender J361 - Simos control unit N80 - Activated charcoal filter system solenoid valve T2z - 2-pin connector, at activated charcoal filter system solenoid valve T4g - 4-pin connector, at intake manifold pressure and intake manifold temperature sender T4i - 4-pin connector, close to lambda probe T11a - 11-pin connector, at left of bulkhead (white) T11b - 11-pin connector, at left of bulkhead (red) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit Z19 - Lambda probe heater

A130

- Connection (CCS), in wiring loom behind dash panel on left

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.3/5

Current Flow Diagram

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.3/6

Current Flow Diagram

FABIA

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J361 T3j T3k T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Simos control unit 3-pin connector, at camshaft position sender 3-pin connector, at knock sensor I 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29 131 281 A76

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth connection -2-, in engine compartment wiring harness - Earth connection -1-, in engine pre-assembly wiring loom - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.3/7

Current Flow Diagram

Simos control unit, throttle valve control unit, ignition system

ws sw ro br gn bl gr li ge or

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit N152 - Ignition transformer (ignition terminal strip) Q - Spark plugs T4f - 4-pin connector, at ignition transformer (ignition terminal strip) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T14a - Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.3/8

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6n T6r T11b

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red)

A2 A15 A32 A98 A99 A139

D52

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.3/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

FABIA

Current Flow Diagram

No.4/1

1.4 l - Simos 3 PA/44 kW, engine code AZF, from August 2002 1.4 l - Simos 3 PA/50 kW, engine code AQW, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 4

Edition 07.03 S00.5324.00.20

- Fuel pump relay

No.4/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.4/3

Current Flow Diagram

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 N33 T2a T2b T2c T2d T2x T2y T14a

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at engine speed sender 2-pin connector, at coolant temperature sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D140

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (injectors), in engine assembly wiring loom

No.4/4

Current Flow Diagram

FABIA

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

A130

E28

- Connection (CCS), in wiring loom behind dash panel on left - Connection (lambda probe heater), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.4/5

Current Flow Diagram

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.4/6

Current Flow Diagram

FABIA

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J361 T3j T3k T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Simos control unit 3-pin connector, at camshaft position sender 3-pin connector, at knock sensor I 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29 131 281 A76

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth connection -2-, in engine compartment wiring harness - Earth connection -1-, in engine pre-assembly wiring loom - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.4/7

Current Flow Diagram

Simos control unit, throttle valve control unit, ignition system

ws sw ro br gn bl gr li ge or

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit N152 - Ignition transformer (ignition terminal strip) Q - Spark plugs T4f - 4-pin connector, at ignition transformer (ignition terminal strip) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T14a - Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.4/8

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6n T6r T11b

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red)

A2 A15 A32 A98 A99 A139

D52

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.4/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

FABIA

Current Flow Diagram

1.4 l - 4MV/55 kW, engine code BBY, from August 2002 1.4 l - 4MV/74 kW, engine code BBZ, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

4

- Fuel pump relay

9

- Fuel feed relay

No.5/1

No.5/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1 ♦

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery - Does not apply to models with automatic gearbox

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.5/3

Current Flow Diagram

4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas valve recirculation potentiometer

ws sw ro br gn bl gr li ge or

G28 G62 G212 J687 N18 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3m T6a T14a

-

Engine speed sender Coolant temperature sender Exhaust gas recirculation potentiometer 4MV control unit EGR valve Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender Connector, 6-pin, at EGR valve Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T40a - 40-pin connector, at engine control unit 220

- Earth connection (sender earth), in engine pre-wiring wiring harness D140 - Connection (injectors), in engine assembly wiring loom D141 - Connection (5V), in engine assembly wiring loom

No.5/4

Current Flow Diagram

FABIA

4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 G71 G72 G130 J687 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T14a

-

T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter 4MV control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

220

- Earth connection (sender earth), in engine pre-wiring wiring harness A130 - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom D141 - Connection (5V), in engine assembly wiring loom E28

- Connection (lambda probe heater), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.5/5

Current Flow Diagram

4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J687 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -24MV control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

*

- Does not apply to models with automatic gearbox

No.5/6

FABIA

Current Flow Diagram

4MV control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J217 J687 T2e T3j T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Automatic gearbox control unit 4MV control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 200 - Earth connection (screening), in engine pre-wiring wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom D166

- Connection (K diagnosis wire), in engine compartment wiring loom

*

- Applies only to models with automatic gearbox

Edition 07.03 S00.5324.00.20

FABIA

No.5/7

Current Flow Diagram

4MV control unit, throttle valve control unit

ws sw ro br gn bl gr li ge or

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J687 - 4MV control unit N79 - Crankcase breather heater element T2m - 2-pin connector, at crankcase breather heater element T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.5/8

Current Flow Diagram

FABIA

4MV control unit, ignition system

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J687 N70 N127 N291 N292 Q T4a T4b T4c T4d T14a

white black red brown green blue grey purple yellow orange

-

4MV control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Ignition coil 4 with output stage Spark plugs Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 4-pin, at ignition coil 4 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

19

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom - Earth connection (ignition coils), in engine preassembly wiring loom - Connection -2- (15a), in engine pre-assembly wiring loom

304 D33

Edition 07.03 S00.5324.00.20

FABIA

No.5/9

Current Flow Diagram

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99 A139

D25 D52

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Connection (15a), in engine pre-assembly wiring loom - Positive connection (15a), in engine compartment wiring loom

No.5/10

Current Flow Diagram

FABIA

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.5/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

FABIA

Current Flow Diagram

2.0 l - Motronic/85 kW, engine code AZL, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

1

- Secondary air pump relay

2

- Motronic power supply relay

4

- Fuel pump relay

9

- Fuel feed relay

No.6/1

No.6/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

■ ■ ■ - Does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.6/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

■ ■ ■ - Does not apply to models with air conditioning

No.6/4

Current Flow Diagram

FABIA

Motronic control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J220 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3m T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Motronic control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

220

- Earth connection (sender earth), in engine pre-wiring wiring harness D140 - Connection (injectors), in engine assembly wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.6/5

Current Flow Diagram

Motronic control unit, lambda probe, lambda probe downstream of catalytic converter, air mass meter and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G70 G72 G130 J220 N80 T2z

-

T4k

-

T5m

-

T6z T11b T14a -

T81a Z19 Z29 -

Lambda probe Air mass meter Intake manifold temperature sender Lambda probe downstream of catalytic converter Motronic control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve Connector, 4-pin, close to lambda probe downstream of catalytic converter Plug connection, 5-pin, at air mass meter and intake manifold temperature sender Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

D52

- Positive connection (15a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom E28 - Connection (lambda probe heater), in engine compartment wiring loom

*

- Applies only to models with optional equipment

No.6/6

Current Flow Diagram

FABIA

Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J220 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Motronic control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.6/7

Current Flow Diagram

Motronic control unit, knock sensor I, knock sensor II, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G66 G163 J220 T2e T2k T3j T6n T11b T40a T81a

-

Knock sensor I Knock sensor II Camshaft position sender Motronic control unit 2-pin connector, at knock sensor I 2-pin connector, at knock sensor II 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D145 - Connection (knock sensors), in engine pre-wiring wiring harness

No.6/8

Current Flow Diagram

FABIA

Motronic control unit, throttle valve control unit, secondary air pump motor

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J220 - Motronic control unit J338 - Throttle valve control unit T2g - 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) T2l - 2-pin connector, at secondary air pump motor T6t - 6-pin connector, at throttle valve control unit T6w - 6-pin connector, at left of bulkhead (grey) T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner V101 - Secondary air pump motor

131 A121 A122 A130 D159 D160

- Earth connection -2-, in engine compartment wiring harness - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CCS), in wiring loom behind dash panel on left - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.6/9

Current Flow Diagram

Motronic control unit, ignition system, secondary air pump relay

ws sw ro br gn bl gr li ge or

J220 J271 J299 N79 N152 P Q T2m

-

T4f T6r T6w T11a T11c T14a

-

T40a T81a -

Motronic control unit Motronic power supply relay Secondary air pump relay Crankcase breather heater element Ignition transformer Spark plug connector Spark plugs 2-pin connector, at crankcase breather heater element 4-pin connector, at ignition transformer 6-pin connector, at left of bulkhead (brown) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

131

- Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom D173 - Connection (87), in engine assembly wiring loom

*

- Applies only to models with optional equipment

No.6/10

Current Flow Diagram

FABIA

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel

- Positive connection (15), in wiring loom behind dash panel A177 - Connection (87), in wiring loom behind dash panel A139

D52

- Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.6/11

Current Flow Diagram

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

No.6/12

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel 281 - Earth connection -1-, in engine pre-assembly wiring loom A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

1.9 l/47 kW - SDI, engine code ASY, from August 2002

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

8

- Low heating capacity relay

b

- S277 - Fuse -2- for heating element

9

- High heating capacity relay

c

- S278 - Fuse -3- for heating element

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.7/1

No.7/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S176 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.7/3

Current Flow Diagram

Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve

ws sw ro br gn bl gr li ge or

J52 J248 N18 Q6 T2g

-

T2h T6w T11a T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit EGR valve Glow plugs 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 2-pin connector, at exhaust gas recirculation valve 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

D78

- Connection (87), in wiring loom behind dash panel

- Positive connection -1- (30a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom

No.7/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G72 G79 J248 SB2 T2i T4d T4h T6n T6u T11b T11c T81a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Intake manifold temperature sender Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 2-pin connector, at fuel gauge sender 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

328 A18

- Earth connection -2- (sender earth), in engine compartment wiring harness - Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.7/5

Current Flow Diagram

Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity adjuster

ws sw ro br gn bl gr li ge or

F268 G81 G149 J248 N108 N109 N146 SB14 T6n T10c T10e T11a T11b T11c T16c T40a T81a

-

Heater element contact switch (PTC) Fuel temperature sender Modulating piston movement sender Diesel direct injection system control unit Commencement of injection valve Fuel cut off valve Quantity (metering) adjuster Fuse, in fuse holder 6-pin connector, at left of bulkhead (blue) 10-pin connector, behind dash panel on right 10-pin connector, at injection pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 16-pin connector, at fresh air controls 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A130 - Connection (CCS), in wiring loom behind dash panel on left F25 - Connection -1-, in engine preassembly wiring loom F36

- Connection (87a), in engine preassembly wiring loom

- does not apply to models with air conditioning - Applies only to models with CCS = = = - Applies only to models with heating element (PTC)

*■ ■ ■

No.7/6

Current Flow Diagram

FABIA

Diesel direct injection system control unit, Engine speed sender, Coolant temperature sender, Needle lift sender, Intake manifold flap motor

ws sw ro br gn bl gr li ge or

G28 G62 G80 J248 T2j T2y T3m T4l T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Needle lift sender Diesel direct injection system control unit 2-pin connector, at needle lift sender 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold flap motor 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V157 - Intake manifold flap motor

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom F27 - Connection harness A121

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring (screening), in engine pre-wiring wiring

Edition 06.04 S00.5324.01.20

FABIA

No.7/7

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 07.03 S00.5324.00.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

No.7/8

Current Flow Diagram

FABIA

Diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J322 T3a T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.7/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G21 G22 J285 K K3 K29 K105 T1b T2f T3l T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 2-pin connector, at fuel gauge sender 3-pin connector, at speedometer sender 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

269

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

FABIA

Current Flow Diagram

No.8/1

1.9 l - TDI with unit injection system/74 kW, engine code ATD, from August 2002

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

4

- Fuel pump relay

b

- S277 - Fuse -2- for heating element

8

- Low heating capacity relay

c

- S278 - Fuse -3- for heating element

9

- High heating capacity relay

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.8/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

■ ■ ■ - Does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.8/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

■ ■ ■ - Does not apply to models with air conditioning

No.8/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, glow plug relay, glow plugs

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J52 J248 Q6 SB14 T2g

-

T6w T11a T11b T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit Glow plugs Fuse, in fuse holder 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

- Connection (87), in wiring loom behind dash panel

D78

- Positive connection -1- (30a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment

*

- Applies only to models with optional equipment

Edition 07.03 S00.5324.00.20

FABIA

No.8/5

Current Flow Diagram

Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G79 J248 SB2 T4d T4h T6n T6u T11b T11c T81a

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.8/6

FABIA

Current Flow Diagram

Diesel direct injection system control unit, coolant temperature sender, fuel temperature sender, exhaust gas recirculation valve, charge pressure control solenoid valve, intake manifold flap changeover valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F268 G62 G81 J248 N18 N75 N239 T2b T2y T6z T10c T11a T11c T14a

white black red brown green blue grey purple yellow orange

-

Heater element contact switch (PTC) Coolant temperature sender Fuel temperature sender Diesel direct injection system control unit EGR valve Boost pressure control solenoid valve Intake manifold flap changeover valve Plug connection, 2-pin, at fuel temperature sender 2-pin connector, at coolant temperature sender Connector, 6-pin, at valve block 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16c - 16-pin connector, at fresh air controls T40a - 40-pin connector, at engine control unit

T81a - 81-pin connector, at engine control unit - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom A130

- does not apply to models with air conditioning - Applies only to models with CCS = = = - Applies only to models with heating element (PTC)

*■ ■ ■

Edition 07.03 S00.5324.00.20

FABIA

No.8/7

Current Flow Diagram

Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender

ws sw ro br gn bl gr li ge or

G28 G40 G70 G71 G72 N79 J248 T2m

-

T3j T3m T4g

-

T5l T40a T81a -

Engine speed sender Camshaft position sender Air mass meter Intake manifold pressure sender Intake manifold temperature sender Crankcase breather heater element Diesel direct injection system control unit 2-pin connector, at crankcase breather heater element 3-pin connector, at camshaft position sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold pressure and intake manifold temperature sender 5-pin connector, at air mass meter 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D52 F27 F36

*

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15a), in engine compartment wiring loom - Connection (screening), in engine pre-wiring wiring harness - Positive connection (87a), in engine assembly wiring loom - Applies only to models with optional equipment

No.8/8

Current Flow Diagram

FABIA

Diesel direct injection system control unit, unit injectors

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J248 N240 N241 N242 N243 T2c T2d T2e T2f T6n T8o T11a T11c T40a T81a

white black red brown green blue grey purple yellow orange

-

Diesel direct injection system control unit Unit injector, cylinder 1 Unit injector, cylinder 2 Unit injector, cylinder 3 Unit injector, cylinder 4 2-pin connector at unit injector valves, No. 1 cyl Plug connection, 2-pin, at unit injector, cylinder 2 Plug connection, 2-pin, at unit injector, cylinder 3 Plug connection, 2-pin, at unit injector, cylinder 4 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at cylinder head 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

A76 A121 A122 D159 D160

F26

- Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Connection (earth), in cylinder head wiring loom

= = = - Applies only to models with heating element (PTC)

Edition 07.03 S00.5324.00.20

FABIA

No.8/9

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 07.03 S00.5324.00.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

No.8/10

Current Flow Diagram

FABIA

Fuel pump relay, diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 J322 T3a T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.8/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K29 K105 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

FABIA

Current Flow Diagram

Power assisted steering (TRW), from August 2002

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.9/1

No.9/2

Current Flow Diagram

FABIA

Power-assisted steering

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G250 J285 J500 K K92 S164 SB7 T2a

-

T3s

-

T4r

-

T11a T11b T16a T32a V119 -

Power-assisted steering sender Control unit in dash panel insert Power-assisted steering control unit Dash panel insert Servotronic warning lamp Fuse -3- (30), in fuse holder on battery Fuse, in fuse holder Plug connection, 2-pin, at power-assisted steering control unit Plug connection, 3-pin, at power-assisted steering control unit Plug connection, 4-pin, at power-assisted steering control unit 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 16-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert Power-assisted steering hydraulics pump

12a A121 A122

D52 D159 D160

P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Positive connection (30), in fuse holder on battery

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Power assisted steering (KOYO), from August 2002

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.10/1

No.10/2

Current Flow Diagram

FABIA

Power-assisted steering

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G250 J285 J500 K K92 S164 SB7 T2a

-

T4r

-

T4z T11a T11b T16a

-

T32a V119 -

Power-assisted steering sender Control unit in dash panel insert Power-assisted steering control unit Dash panel insert Servotronic warning lamp Fuse -3- (30), in fuse holder on battery Fuse, in fuse holder Plug connection, 2-pin, at power-assisted steering control unit Plug connection, 4-pin, at power-assisted steering control unit Connector, 4-pin, at power-assisted steering control unit 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 16-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert Power-assisted steering hydraulics pump

12a A121 A122

D52 D159 D160

P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Positive connection (30), in fuse holder on battery

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.11/1

Anti-lock brake system (ABS) Antilock brake system(ABS) with differential lock (EDL) and traction control system (TCS), from August 2002 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.11/2

Current Flow Diagram

FABIA

ABS/ABS with EDL and TCS control unit, fuse holder on battery, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F J104 J105 J503 N99 N100 N101 N102 S178 S179 T4d T8e T9a T11c T26a T42a V39

white black red brown green blue grey purple yellow orange

-

Brake light switch ABS/ABS with EDL and TCS control unit Return delivery pump relay - ABS Navigation system control unit ABS inlet valve, front right ABS outlet valve, front right ABS inlet valve, front left ABS outlet valve, front left Fuse -6- (30), in fuse holder on battery Fuse -7- (30), in fuse holder on battery 4-pin connector, at brake pedal switch Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (blue) 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS/ABS with EDL and TCS control unit - ABS return delivery pump

100 614

- Earth connection (ABS), in engine compartment wiring loom - Earth point -2-, in rear right of engine compartment

A18

- Connection (54), in wiring loom behind dash panel

A38

- Positive connection -2- (15a), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel D73 - Connection (54), in left of engine compartment wiring loom P1 - Positive connection (30), in fuse holder on battery

*= = =

- Applies only to models with TCS - applies only to models with navigation system

Edition 07.03 S00.5324.00.20

FABIA

No.11/3

Current Flow Diagram

ABS/ABS with EDL and TCS control unit, wheel speed sensors

ws sw ro br gn bl gr li ge or

G44 G45 G46 G47 J104 J106 N133 N134 N135 N136 T2k T2l T2m T2n T9a T42a

-

Wheel speed sensor, rear right Wheel speed sensor, front right Wheel speed sensor, rear left Wheel speed sensor, front left ABS/ABS with EDL and TCS control unit ABS solenoid valves relay ABS inlet valve, rear right ABS inlet valve, rear left ABS outlet valve, rear right ABS outlet valve, rear left 2-pin connector, at rear right wheel speed sensor 2-pin connector, at rear left wheel speed sensor 2-pin connector, at front right wheel speed sensor 2-pin connector, at front left wheel speed sensor Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS/ABS with EDL and TCS control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

J3

- Connection, in rear right wiring loom

J5

- Connection, in rear right wiring loom

J7

- Connection, in rear left wiring loom

J8

- Connection, in rear left wiring loom

white black red brown green blue grey purple yellow orange

No.11/4

Current Flow Diagram

FABIA

ABS/ABS with EDL and TCS control unit, TCS switch, dash panel insert

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E132 J104 J285 K K47 K86 L71 N166 N167 N168 N169 T5b T9a T11a T32a T42a

white black red brown green blue grey purple yellow orange

-

TCS switch ABS/ABS with EDL and TCS control unit Control unit in dash panel insert Dash panel insert ABS warning lamp Traction control system warning lamp TCS switch lighting Front right EDL changeover valve Front right EDL outlet valve Front left EDL changeover valve Front left EDL outlet valve Connector, 5-pin, at TCS switch Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (white) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS/ABS with EDL and TCS control unit

332 A4 A121 A122 D159 D160

*

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Applies only to models with TCS

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.12/1

Anti-lock brake system (ABS) with electronic differential lock (EDL), traction control system (TCS), electronic stabilisation program (ESP), from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.12/2

Current Flow Diagram

FABIA

ABS with EDL and TCS/ESP control unit, fuse holder on battery, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J104 J105 J503 N99 N100 N101 N102 S178 S179 T8e T9a T26a T42a V39

white black red brown green blue grey purple yellow orange

-

ABS with EDL and TCS/ESP control unit Return delivery pump relay - ABS Navigation system control unit ABS inlet valve, front right ABS outlet valve, front right ABS inlet valve, front left ABS outlet valve, front left Fuse -6- (30), in fuse holder on battery Fuse -7- (30), in fuse holder on battery Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS with EDL and TCS/ESP control unit - ABS return delivery pump

100 614

- Earth connection (ABS), in engine compartment wiring loom - Earth point -2-, in rear right of engine compartment

A38

- Positive connection -2- (15a), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel P1 - Positive connection (30), in fuse holder on battery = = = - applies only to models with navigation system

Edition 07.03 S00.5324.00.20

FABIA

No.12/3

Current Flow Diagram

ABS with EDL and TCS/ESP control unit, wheel speed sensors

ws sw ro br gn bl gr li ge or

G44 G45 G46 G47 J104 J106 N133 N134 N135 N136 T2k T2l T2m T2n T9a T42a

-

Wheel speed sensor, rear right Wheel speed sensor, front right Wheel speed sensor, rear left Wheel speed sensor, front left ABS with EDL and TCS/ESP control unit ABS solenoid valves relay ABS inlet valve, rear right ABS inlet valve, rear left ABS outlet valve, rear right ABS outlet valve, rear left 2-pin connector, at rear right wheel speed sensor 2-pin connector, at rear left wheel speed sensor 2-pin connector, at front right wheel speed sensor 2-pin connector, at front left wheel speed sensor Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS with EDL and TCS/ESP control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

J3

- Connection, in rear right wiring loom

J5

- Connection, in rear right wiring loom

J7

- Connection, in rear left wiring loom

J8

- Connection, in rear left wiring loom

white black red brown green blue grey purple yellow orange

No.12/4

Current Flow Diagram

FABIA

ABS with EDL and TCS/ESP control unit, brake pedal switch

ws sw ro br gn bl gr li ge or

F F9 F47 J104 K SB2 T4d T8e T11c T32a T42a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Brake light switch Handbrake warning switch Brake pedal switch ABS with EDL and TCS/ESP control unit Dash panel insert Fuse, in fuse holder 4-pin connector, at brake pedal switch Plug connection, 8-pin, at left of bulkhead (orange) 11-pin connector, at left of bulkhead (blue) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS with EDL and TCS/ESP control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

- Connection (handbrake indicator), in wiring loom behind dash panel D73 - Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom A115

Edition 07.03 S00.5324.00.20

FABIA

No.12/5

Current Flow Diagram

ABS with EDL and TCS/ESP control unit, brake pressure sender -1-, lateral acceleration sender, yaw rate sender

ws sw ro br gn bl gr li ge or

G200 G201 G202 J104 T3e

-

T6x

-

T8e T9a T42a -

Lateral acceleration sender, below driver seat Brake pressure sender -1-, at hydraulic unit Yaw rate sender, below driver seat ABS with EDL and TCS/ESP control unit Connector, 3-pin, at brake pressure sender -1-, at hydraulic unit Connector, 6-pin, at lateral acceleration and yaw rate sender Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS with EDL and TCS/ESP control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

No.12/6

Current Flow Diagram

FABIA

ABS with EDL and TCS/ESP control unit, steering angle sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G85 J104 K N225 N226 N227 N228 SB1 T6y T8c

white black red brown green blue grey purple yellow orange

-

Steering angle sender ABS with EDL and TCS/ESP control unit Dash panel insert Electronic stability programme, valve -1Electronic stability programme, valve -2Electronic stability programme high pressure valve -1Electronic stability programme high pressure valve -2Fuse, in fuse holder Connector, 6-pin, at steering angle sender 8-pin connector, at dash panel insert

- Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel A164 - Positive connection (30a), in wiring loom behind dash panel A121

Edition 07.03 S00.5324.00.20

FABIA

No.12/7

Current Flow Diagram

ABS with EDL and TCS/ESP control unit, TCS/ESP switch, dash panel insert

ws sw ro br gn bl gr li ge or

E256 J104 J285 K K47 K155 L115 T6b T9a T11a T32a T42a

-

TCS/ESP switch ABS with EDL and TCS/ESP control unit Control unit in dash panel insert Dash panel insert ABS warning lamp Warning lamp for stability programme TCS/ESP switch illumination Connector, 6-pin, at TCS/ESP switch Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (white) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS with EDL and TCS/ESP control unit

Edition 07.03 S00.5324.00.20

332 A4 A121 A122 D159 D160

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

FABIA

Current Flow Diagram

Driver and Front passenger airbag, from August 2002 (Without deactivation of the front passenger airbag)

Edition 07.03 S00.5324.00.20

No.13/1

No.13/2

Current Flow Diagram

FABIA

Airbag control unit, coil spring contact in steering wheel, front airbag igniter, dash panel insert

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F138 J234 J285 K K75 N95 N131 T2t T2u T3o T5f

white black red brown green blue grey purple yellow orange

-

Airbag coil connector Airbag control unit Control unit in dash panel insert Dash panel insert Airbag warning lamp Airbag igniter (driver side) Airbag igniter (passenger side) 2-pin connector, at airbag unit, driver side 2-pin connector, at airbag unit passenger side Connector, 3-pin, behind dash panel on right 5-pin connector, at airbag coil connector in steering wheel T5g - 5-pin connector, in steering wheel T32a - 32-pin connector, at dash panel insert T75a - 75-pin connector, at airbag control unit

- Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel A121

■ ■ ■ - Passenger airbag

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Driver and Front passenger airbag, from August 2002 (With deactivation of the front passenger airbag)

Edition 07.03 S00.5324.00.20

No.14/1

No.14/2

Current Flow Diagram

FABIA

Airbag control unit, Steering wheel coil connector, Driver side airbag igniter, Front passenger side airbag deactivated warning lamp

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F138 - Airbag coil connector J234 - Airbag control unit K145 - Front passenger side airbag deactivated warning lamp N95 - Airbag igniter (driver side) T2t - 2-pin connector, at airbag unit, driver side T5f - 5-pin connector, at airbag coil connector in steering wheel T5g - 5-pin connector, in steering wheel T6a - 6-pin connector at the driver side airbag deactivated warning lamp T75a - 75-pin connector, at airbag control unit

A139

- Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.14/3

Current Flow Diagram

Airbag control unit, Front passenger side airbag igniter, Front passenger side airbag deactivation key switch, Dash panel insert

ws sw ro br gn bl gr li ge or

E224 - Airbag disabling key switch, front passenger side, in glove box J234 - Airbag control unit J285 - Control unit in dash panel insert K - Dash panel insert K75 - Airbag warning lamp N131 - Airbag igniter (passenger side) T2u - 2-pin connector, at airbag unit passenger side T3o - Connector, 3-pin, behind dash panel on right T8r - 8-pin connector at driver side airbag deactivation key switch T32a - 32-pin connector, at dash panel insert T75a - 75-pin connector, at airbag control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel T3 - Connection panel T5 - Connection panel A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (airbag), in wiring loom behind dash -2- (airbag), in wiring loom behind dash

FABIA

Current Flow Diagram

Side airbag, from August 2002 (Without deactivation of the front passenger airbag)

Edition 07.03 S00.5324.00.20

No.15/1

No.15/2

Current Flow Diagram

FABIA

Airbag control unit, coil spring contact in steering wheel, front airbag igniter, belt tensioner igniter

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F138 J234 N95 N131 N153 N154 T2r

-

T2s

-

T2t T2u T3o T5f

-

T5g T75a -

Airbag coil connector Airbag control unit Airbag igniter (driver side) Airbag igniter (passenger side) Belt tensioner igniter - driver side Belt tensioner igniter - passenger side 2-pin connector at belt tensioner igniter, driver side 2-pin connector at belt tensioner igniter, front passenger side 2-pin connector, at airbag unit, driver side 2-pin connector, at airbag unit passenger side Connector, 3-pin, behind dash panel on right 5-pin connector, at airbag coil connector in steering wheel 5-pin connector, in steering wheel 75-pin connector, at airbag control unit

A139

- Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.15/3

Current Flow Diagram

Airbag control unit, side airbag igniter, side airbag crash sensor, dash panel insert

ws sw ro br gn bl gr li ge or

G179 G180 J234 J285 K K75 N199 N200 T2o

-

T2p

-

T3p T3r T32a T75a

-

Crash sensor for side airbag, driver side Crash sensor for side airbag, passenger side Airbag control unit Control unit in dash panel insert Dash panel insert Airbag warning lamp Side airbag igniter, driver side Side airbag igniter, passenger side 2-pin connector, at crash sensor for side airbag, driver side 2-pin connector, at side airbag crash sensor, passenger side 3-pin connector, below driver seat 3-pin connector, below passenger seat 32-pin connector, at dash panel insert 75-pin connector, at airbag control unit

Edition 07.03 S00.5324.00.20

109

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection (side airbag), in wiring loom behind dash panel A121 - Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel

FABIA

Current Flow Diagram

Side airbag, from August 2002 (With deactivation of the front passenger airbag)

Edition 07.03 S00.5324.00.20

No.16/1

No.16/2

Current Flow Diagram

FABIA

Airbag control unit, Steering wheel coil connector, Driver side airbag igniter, Belt tensioner igniter, Front passenger side airbag deactivated warning lamp

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F138 - Airbag coil connector J234 - Airbag control unit K145 - Front passenger side airbag deactivated warning lamp N95 - Airbag igniter (driver side) N153 - Belt tensioner igniter - driver side N154 - Belt tensioner igniter - passenger side T2r - 2-pin connector at belt tensioner igniter, driver side T2s - 2-pin connector at belt tensioner igniter, front passenger side T2t - 2-pin connector, at airbag unit, driver side T5f - 5-pin connector, at airbag coil connector in steering wheel T5g - 5-pin connector, in steering wheel T6a - 6-pin connector at the driver side airbag deactivated warning lamp T75a - 75-pin connector, at airbag control unit

A139

- Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.16/3

Current Flow Diagram

Airbag control unit, Front passenger side airbag igniter, Front passenger side - side airbag, Front passenger side airbag deactivation key switch

ws sw ro br gn bl gr li ge or

E224 - Front passenger side airbag deactivation key switch, in glove box J234 - Airbag control unit N131 - Airbag igniter (passenger side) N200 - Side airbag igniter, passenger side T3o - Connector, 3-pin, behind dash panel on right T3r - 3-pin connector, below passenger seat T8r - 8-pin connector at driver side airbag deactivation key switch T75a - 75-pin connector, at airbag control unit

Edition 07.03 S00.5324.00.20

T3 T5 T6

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (airbag), in wiring loom behind dash panel - Connection -2- (airbag), in wiring loom behind dash panel - Connection (side airbag), in wiring loom behind dash panel

No.16/4

Current Flow Diagram

FABIA

Airbag control unit, Front passenger side - side airbag igniter, Side airbag crash sensor, Dash panel insert

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G179 G180 J234 J285 K K75 N199 T2o

-

T2p

-

T3p T32a T75a -

Crash sensor for side airbag, driver side Crash sensor for side airbag, passenger side Airbag control unit Control unit in dash panel insert Dash panel insert Airbag warning lamp Side airbag igniter, driver side 2-pin connector, at crash sensor for side airbag, driver side 2-pin connector, at side airbag crash sensor, passenger side 3-pin connector, below driver seat 32-pin connector, at dash panel insert 75-pin connector, at airbag control unit

109

- Earth connection (side airbag), in wiring loom behind dash panel A121 - Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Automatic gearbox, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 7

Edition 07.03 S00.5324.00.20

- Starter lockout relay

No.17/1

No.17/2

Current Flow Diagram

FABIA

Starter, starter lockout relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B D J207 M16 M17 SB13 T1a T1c T6l T6m T6n T6o

white black red brown green blue grey purple yellow orange

-

Battery Starter Ignition/starter switch Starter lockout relay Reversing light bulb left Reversing light bulb right Fuse, in fuse holder 1-pin connector, at starter Connector, 1-pin, for starter, in bracket at gearbox 6-pin connector, at left tail light 6-pin connector, at right tail light 6-pin connector, at left of bulkhead (blue) 6-pin connector, at electrical system control unit (black) T8a - 8-pin connector, at ignition/starter switch T11b - 11-pin connector, at left of bulkhead (red) T18b - 18-pin connector, at electrical system control unit (black)

81

- Earth connection, in wiring harness behind dash panel B182 - Connection (RF), in interior wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.17/3

Current Flow Diagram

Automatic gearbox control unit, multifunction switch, fuse holder on battery, fuse holder

ws sw ro br gn bl gr li ge or

F125 J217 S271 T6n T8r

-

multifunction switch Automatic gearbox control unit Fuse -13- (30), in fuse holder on battery 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at automatic gearbox (connection to wiring loom in engine compartment) T10h - Plug connection, 10-pin, at multifunction switch T68a - 68-pin connector, at automatic gearbox control unit

14a

white black red brown green blue grey purple yellow orange

- Earth point -2-, at gearbox

131

- Earth connection -2-, in engine compartment wiring harness A139 - Positive connection (15), in wiring loom behind dash panel P1 - Positive connection (30), in fuse holder on battery U2

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- Connection (15), in automatic gearbox wiring loom

No.17/4

FABIA

Current Flow Diagram

Automatic gearbox control unit, vehicle speed sender, gearbox oil temperature sender, solenoid valves

ws sw ro br gn bl gr li ge or

G68 G93 J... J217 N88 N89 N90 N91 N92 N93 T2g T6n T8p T8r

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Road speed sender Gearbox oil (ATF) temperature sender Engine control unit Automatic gearbox control unit Solenoid valve 1 Solenoid valve 2 Solenoid valve 3 Solenoid valve 4 Solenoid valve 5 Solenoid valve 6 2-pin connector, at road speed sender 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at automatic gearbox Plug connection, 8-pin, at automatic gearbox (connection to wiring loom in engine compartment) T68a - 68-pin connector, at automatic gearbox control unit

14b

- Massepunkt -3-, am Getriebe

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left D166 - Connection (K diagnosis wire), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.17/5

Current Flow Diagram

Automatic gearbox control unit, gearbox speed sender, selector lever lock solenoid, dash panel insert

ws sw ro br gn bl gr li ge or

G38 J217 J285 K K142 L101 N110 T2h T2j T4x T8r

-

T11a T16a T18b T68a Y6

-

Gearbox speed sender Automatic gearbox control unit Control unit in dash panel insert Dash panel insert Selector lever position P/N indicator light Selector lever scale lighting Selector lever lock solenoid 2-pin connector, at gearbox speed sender 2-pin connector, at selector lever lock solenoid valve Plug connection, 4-pin, at selector lever scale lighting Plug connection, 8-pin, at automatic gearbox (connection to wiring loom in engine compartment) 11-pin connector, at left of bulkhead (white) 16-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (black) 68-pin connector, at automatic gearbox control unit Selector lever position indicator

Edition 07.03 S00.5324.00.20

354 A11 A109 A121 A122 D159 D160

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (selector lever of automatic gearbox), in wiring loom behind dash panel - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

FABIA

Current Flow Diagram

Central locking Door warning lights from August 2002 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 5

Edition 07.03 S00.5324.00.20

- Door warning lights relay

No.18/1

No.18/2

Current Flow Diagram

FABIA

Convenience electrics central control unit, tailgate handle release button, central locking switch, tailgate central locking motor, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E234 F5 S218 J393 T2y T2z

-

T4c T5c

-

T5e T6k T6o

-

T18b -

Tailgate handle release button Luggage compartment light switch Central locking switch, in tailgate lock Convenience electrics central control unit Connector, 2-pin, at tailgate handle release button 2-pin connector, at tailgate/boot lid central locking motor 4-pin connector, at boot/tailgate lock 5-pin connector, at electrical system control unit (brown) 5-pin connector, at left C pillar (black) 6-pin connector, at electrical system control unit (red) 6-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (black)

T23a - 23-pin connector, at convenience electrics central control unit V53 - Tailgate/boot lid central locking motor 61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

98

- Earth connection, in engine compartment wiring harness 135 - Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A98 - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.18/3

Current Flow Diagram

Convenience electrics central control unit, central locking locking unit - driver side, central locking warning light, left door warning light

ws sw ro br gn bl gr li ge or

F220 - Central locking lock unit, driver side (switch position released, door closed) J245 - Sliding roof adjustment control unit J393 - Convenience electrics central control unit K133 - Central locking warning lamp M27 - Left door warning light T2w - Connector, 2-pin, at left door warning light T2x - 2-pin connector, at central locking warning lamp T6e - 6-pin connector, at sliding roof adjustment control unit T6f - 6-pin connector, at left A pillar (brown) T6j - Connector, 6-pin, at left A pillar (white) T8f - 8-pin connector, at central locking locking unit, driver side T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T23a - 23-pin connector, at convenience electrics central control unit

Edition 07.03 S00.5324.00.20

81 205 A76

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness of door assembly wiring driver side - Connection (K diagnosis wire), in wiring loom behind dash panel on left

= = = - Applies only to models with electric sliding roof ■ ■ ■ - Applies only to models with door warning lights

No.18/4

Current Flow Diagram

FABIA

Convenience electrics central control unit, central locking locking unit - passenger side, right door warning light

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F221 - Central locking lock unit, front passenger side (switch position - released, door closed) J393 - Convenience electrics central control unit M28 - Right door warning light T2v - Connector, 2-pin, at right door warning light T6g - 6-pin connector, at right A pillar (brown) T6k - Connector, 6-pin, at right A pillar (white) T8g - 8-pin connector, at central locking locking unit, passenger side T23a - 23-pin connector, at convenience electrics central control unit

206 354

- Earth connection, in door wiring loom - passenger side - Earth connection, in wiring harness behind dash panel

■ ■ ■ - Applies only to models with door warning lights

Edition 07.03 S00.5324.00.20

FABIA

No.18/5

Current Flow Diagram

Convenience electrics central control unit, left rear central locking locking unit, right rear central locking locking unit

ws sw ro br gn bl gr li ge or

F222 - Central locking lock unit, rear left (switch position released, door closed) F223 - Central locking lock unit, rear right (switch position released, door closed) J393 - Convenience electrics central control unit T6c - 6-pin connector, at rear left central locking locking unit T6d - 6-pin connector, at rear right central locking locking unit T6h - 6-pin connector, at left B pillar (brown) T6i - 6-pin connector, at right B pillar (brown) T6l - 6-pin connector, at left B pillar (blue) T6m - 6-pin connector, at right B pillar (blue) T12c - Connector, 12-pin, at convenience electrics central control unit (black)

Edition 07.03 S00.5324.00.20

81 354

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel

No.18/6

Current Flow Diagram

FABIA

Convenience electrics central control unit, front interior light, door warning lights relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J317 - Terminal 30 voltage supply relay J393 - Convenience electrics central control unit J560 - Door warning lights relay SB4 - Fuse, in fuse holder SB5 - Fuse, in fuse holder T3c - 3-pin connector, at front interior light bulb T5a - 5-pin connector, at electrical system control unit (black) T6f - 6-pin connector, at left A pillar (brown) T6j - 6-pin connector, at electrical system control unit (brown) T18a - 18-pin connector, at electrical system control unit (brown) T23a - 23-pin connector, at convenience electrics central control unit W - Interior light, front W13 - Front passenger’s reading light W19 - Driver-side reading light

354

- Earth connection, in wiring harness behind dash panel A23 - Positive connection (30al), in wiring loom behind dash panel A52 - Positive connection (30a), in wiring loom behind dash panel on left B164 - Connection (30, door warning light), in interior wiring loom ■ ■ ■ - Applies only to models with door warning lights

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Front power windows Heated and adjustable exterior mirrors, from August 2002 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.19/1

No.19/2

Current Flow Diagram

FABIA

Electrical window for driver door, Fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E40 E81 E150 J386 L76 T4m T6n T8h T12d

white black red brown green blue grey purple yellow orange

-

Front left power window switch Front right power window switch, driver Interior locking switch, driver side Door control unit, driver’s side Power window central switch lighting 4-pin connector, at left A pillar (black) Connector, 6-pin, at left A-pillar (blue) Connector, 8-pin, at door control unit, driver side Connector, 12-pin, at door control unit, driver side (black) T16d - 16-pin connector, at central switch for window lifters, in driver’s door T18b - 18-pin connector, at electrical system control unit (black) V147 - Electric window motor, driver’s side

199

- Earth connection, in wiring harness behind dash panel 267 - Earth connection, in wiring harness of door assembly wiring driver side A57 - Positive connection (30a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*

- Applies only to models with central locking

Edition 07.03 S00.5324.00.20

FABIA

No.19/3

Current Flow Diagram

Heated and adjustable exterior mirror for driver door, fuse holder

ws sw ro br gn bl gr li ge or

E43 E48 E231 J386 L78 T6n T6x T8h T10f T12d

-

T12e V17 V149 Z4 -

Mirror adjustment switch Mirror adjustment changeover switch Exterior mirror heater pushbutton Door control unit, driver’s side Mirror adjustment switch illumination Connector, 6-pin, at left A-pillar (blue) 6-pin connector, at electrical system control unit (red) Connector, 8-pin, at door control unit, driver side Connector, 10-pin, at mirror adjustment switch Connector, 12-pin, at door control unit, driver side (black) Connector, 12-pin, at door control unit, driver side (brown) Mirror adjustment motor (driver’s side) Mirror adjustment motor (driver side) Heated exterior mirror, driver side

Edition 07.03 S00.5324.00.20

267 A98

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness of door assembly wiring driver side - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system)

= = = - applies only to models with heated and adjustable exterior mirrors

No.19/4

Current Flow Diagram

FABIA

Passenger door power window, passenger door heated and adjustable exterior mirror, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E107 J387 L53 T4n T5i

-

T6o T6p

-

T8i

-

T12f

-

V25 V148 V150 Z5

-

Power window switch, in front passenger door Door control unit, passenger’s side Window lifter switch illumination bulb 4-pin connector, at right A pillar (black) Connector, 5-pin, at power window switch, in front passenger door 6-pin connector, at right A pillar (blue) Connector, 6-pin, at door control unit, front passenger side Connector, 8-pin, at door control unit, front passenger side Connector, 12-pin, at door control unit, front passenger side Mirror adjustment motor (passenger side) Electric window motor (passenger side) Mirror adjustment motor (passenger side) Heated exterior mirror (passenger side)

199

- Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel = = = - applies only to models with heated and adjustable exterior mirrors

Edition 07.03 S00.5324.00.20

FABIA

No.19/5

Current Flow Diagram

Convenience electrics central control unit, fuse holder

ws sw ro br gn bl gr li ge or

J393 - Convenience electrics central control unit T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T23a - 23-pin connector, at convenience electrics central control unit

white black red brown green blue grey purple yellow orange

135

- Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*= = =

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- Applies only to models without central locking - Applies only to models without central locking

FABIA

Current Flow Diagram

Front and rear power windows Heated and adjustable exterior mirrors, from August 2002 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.20/1

No.20/2

Current Flow Diagram

FABIA

Driver-door power window, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E39 E40 E53 E55 E81 E150 J386 L76 T4m T6n T8h T12d

white black red brown green blue grey purple yellow orange

-

Rear power window locking switch Front left power window switch Rear left power window switch, driver Rear right power window switch, driver Front right power window switch, driver Interior locking switch, driver side Door control unit, driver’s side Power window central switch lighting 4-pin connector, at left A pillar (black) Connector, 6-pin, at left A-pillar (blue) Connector, 8-pin, at door control unit, driver side Connector, 12-pin, at door control unit, driver side (black) T16d - 16-pin connector, at central switch for window lifters, in driver’s door T18b - 18-pin connector, at electrical system control unit (black) V147 - Electric window motor, driver’s side

199

- Earth connection, in wiring harness behind dash panel 267 - Earth connection, in wiring harness of door assembly wiring driver side A57 - Positive connection (30a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.20/3

Current Flow Diagram

Heated and adjustable exterior mirror for driver door, fuse holder

ws sw ro br gn bl gr li ge or

E43 E48 E231 J386 L78 T6n T6x T8h T10f T12d

-

T12e V17 V149 Z4 -

Mirror adjustment switch Mirror adjustment changeover switch Exterior mirror heater pushbutton Door control unit, driver’s side Mirror adjustment switch illumination Connector, 6-pin, at left A-pillar (blue) 6-pin connector, at electrical system control unit (red) Connector, 8-pin, at door control unit, driver side Connector, 10-pin, at mirror adjustment switch Connector, 12-pin, at door control unit, driver side (black) Connector, 12-pin, at door control unit, driver side (brown) Mirror adjustment motor (driver’s side) Mirror adjustment motor (driver side) Heated exterior mirror, driver side

Edition 07.03 S00.5324.00.20

267 A98

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness of door assembly wiring driver side - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system)

= = = - applies only to models with heated and adjustable exterior mirrors

No.20/4

Current Flow Diagram

FABIA

Passenger door power window, passenger door heated and adjustable exterior mirror, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E107 J387 L53 T4n T5i

-

T6o T6p

-

T8i

-

T12f

-

V25 V148 V150 Z5

-

Power window switch, in front passenger door Door control unit, passenger’s side Window lifter switch illumination bulb 4-pin connector, at right A pillar (black) Connector, 5-pin, at power window switch, in front passenger door 6-pin connector, at right A pillar (blue) Connector, 6-pin, at door control unit, front passenger side Connector, 8-pin, at door control unit, front passenger side Connector, 12-pin, at door control unit, front passenger side Mirror adjustment motor (passenger side) Electric window motor (passenger side) Mirror adjustment motor (passenger side) Heated exterior mirror (passenger side)

199

- Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel = = = - applies only to models with heated and adjustable exterior mirrors

Edition 07.03 S00.5324.00.20

FABIA

No.20/5

Current Flow Diagram

Rear left electrical window, Rear right electrical window

ws sw ro br gn bl gr li ge or

E52 E54 J388 J389 L53 T4o T4p T5j T5k T6l T6m T6r T6s T8j T8k V26

-

Window lifter switch, rear left Window lifter switch, rear right Door control unit, rear left Door control unit, rear right Window lifter switch illumination bulb 4-pin connector, at left B pillar (black) 4-pin connector, at right B pillar (black) 5-pin connector, at left rear window lifter switch 5-pin connector, at rear right window lifter switch 6-pin connector, at left B pillar (blue) 6-pin connector, at right B pillar (blue) Connector, 6-pin, at rear left door control unit Connector, 6-pin, at rear right door control unit Connector, 8-pin, at rear left door control unit Connector, 8-pin, at rear right door control unit Electric window lifter motor, rear left

Edition 07.03 S00.5324.00.20

V27 199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Electric window lifter motor, rear right

- Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

No.20/6

Current Flow Diagram

FABIA

Convenience electrics central control unit, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J393 - Convenience electrics central control unit T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T23a - 23-pin connector, at convenience electrics central control unit

135

- Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*= = =

- Applies only to models without central locking - Applies only to models without central locking

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Heated and adjustable exterior mirrors (without power windows), from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.21/1

No.21/2

Current Flow Diagram

FABIA

Heated and adjustable exterior mirror

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E43 E48 E231 L78 T6f T6g T6n T6o T6x T10f T12g T12h V17 V25 V149 V150 Z4 Z5

white black red brown green blue grey purple yellow orange

-

Mirror adjustment switch Mirror adjustment changeover switch Exterior mirror heater pushbutton Mirror adjustment switch illumination 6-pin connector, at left A pillar (brown) 6-pin connector, at right A pillar (brown) Connector, 6-pin, at left A-pillar (blue) 6-pin connector, at right A pillar (blue) 6-pin connector, at electrical system control unit (red) Connector, 10-pin, at mirror adjustment switch Connector, 12-pin, in driver door Connector, 12-pin, in front passenger door Mirror adjustment motor (driver’s side) Mirror adjustment motor (passenger side) Mirror adjustment motor (driver side) Mirror adjustment motor (passenger side) Heated exterior mirror, driver side Heated exterior mirror (passenger side)

81 205 206 354 A11 A34 A98 R27

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness of door assembly wiring driver side - Earth connection, in door wiring loom - passenger side - Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (mirror adjustment), in driver-side door wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Cruise control system, from August 2002

Edition 07.03 S00.5324.00.20

No.22/1

No.22/2

Current Flow Diagram

FABIA

Cruise control system

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E45 E227 J... SB28 T6y

white black red brown green blue grey purple yellow orange

-

Cruise control system switch Cruise control button (Set) Engine control units Fuse, in fuse holder 6-pin connector, at electrical system control unit (brown) T10g - 10-pin connector, at CCS switch T11a - 11-pin connector, at left of bulkhead (white) T16a - 16-pin connector, at electrical system control unit (black)

A100

- Connection (87a), in wiring loom behind dash panel

A121

- Connection panel on - Connection panel - Connection on left - Connection loom - Connection loom

A122 A130 D159 D160

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CCS), in wiring loom behind dash panel (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Multifunction display (MFA), from August 2002

Edition 07.03 S00.5324.00.20

No.23/1

No.23/2

Current Flow Diagram

FABIA

Multifunction display (MFD)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E91 E92 G17 J119 J285 J... K T2d T6a

-

T6p T6r T11a T32a

-

Function selection switch Reset button Ambient temperature sensor Multifunction display Control unit in dash panel insert Engine control units Dash panel insert 2-pin connector, at ambient temperature sensor 6-pin connector, at windscreen wiper intermittent switch 6-pin connector, at left of bulkhead (red) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (white) 32-pin connector, at dash panel insert

269 327 A121 A122 D159 D160

- Earth connection (sender earth) -1-, in wiring harness behind dash panel - Earth connection (sender earth), in engine compartment wiring harness - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Anti-theft alarm system, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.24/1

No.24/2

Current Flow Diagram

FABIA

Anti-theft alarm

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F266 G273 H12 J393 T2v T3v T4w T6v T12i

white black red brown green blue grey purple yellow orange

-

Vermin repellent system contact switch Sensor for interior monitoring Alarm horn Convenience electrics central control unit 2-pin connector, at bonnet contact switch 3-pin connector, at alarm horn 4-pin connector, at interior motion sensor 6-pin connector, at left of bulkhead (green) 12-pin connector, at convenience electrics central control unit (brown) T16a - 16-pin connector, at electrical system control unit (black)

13

- Earth point, in front right of engine compartment

86

- Earth connection -1-, in rear interior wiring loom

A57 A66

- Positive connection (30a), in wiring loom behind dash panel - Connection (30a, anti-theft alarm system), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Gas discharge lights, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.25/1

No.25/2

Current Flow Diagram

FABIA

Light switch

ws sw ro br gn bl gr li ge or

E1 E23 L9 M41 T6c

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Light switch Front and rear fog light switch Lighting switch illumination bulb Left tail light and rear fog light bulb 6-pin connector, at electrical system control unit (black) T17a - 17-pin connector, at light switch

81 A9 A11

- Earth connection, in wiring harness behind dash panel - Connection (56b), in wiring loom behind dash panel

A43

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A56

- Positive connection (30a), in wiring loom behind dash panel

A33 A34

♦

- Does not apply to models with daytime running lights

Edition 07.03 S00.5324.00.20

FABIA

No.25/3

Current Flow Diagram

Headlight range adjustment control unit, headlight range adjustment, fuse holder

ws sw ro br gn bl gr li ge or

J431 - Headlight beam adjustment control unit (at rear axle) SB12 - Fuse, in fuse holder T8s - Connector, 8-pin, at headlight range adjustment control unit T10a - 10-pin connector, at left headlight T10b - 10-pin connector, at right headlight T12a - 12-pin connector, at left of bulkhead (white) V48 - Headlight range control motor, left V49 - Headlight range control motor, right

85

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in wiring loom in left of engine compartment - Earth connection -1-, in rear interior wiring loom

A9

- Connection (56b), in wiring loom behind dash panel

A27

- Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (headlight range control), in engine compartment wiring loom

A70 A76 D96

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

No.25/4

Current Flow Diagram

FABIA

Left gas discharge light, fuse holder

ws sw ro br gn bl gr li ge or

J426 L13 M1 M5 M30 T10a T11a T12a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Left headlight ballast unit (gas discharge) Left gas discharge light Side light bulb, left Turn signal bulb, front left Headlight main beam bulb, left 10-pin connector, at left headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white)

85 A9

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

D58

- Connection (left turn signal light), in left engine compartment wiring loom D152 - Positive connection (56bL), in left engine compartment wiring loom

*♦

- Does not apply to models with bulb failure indicator - Does not apply to models with daytime running lights

Edition 07.03 S00.5324.00.20

FABIA

No.25/5

Current Flow Diagram

Right gas discharge bulb, dimming and headlight flasher switch, fuse holder

ws sw ro br gn bl gr li ge or

E4 J427 L14 M3 M7 M32 T10b T11a T12a T12b

-

Headlight dipper/flasher switch Right headlight ballast unit (gas discharge) Right gas discharge light Side light bulb, right Turn signal bulb, front right Headlight main beam bulb, right 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) 12-pin connector, at headlight dipper/flasher switch

85 A9 A56

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A85

- Positive connection (30a), in wiring loom behind dash panel - Connection (58R), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

D57

- Connection (right turn signal light), in right engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom

*♦

Edition 07.03 S00.5324.00.20

- Does not apply to models with bulb failure indicator - Does not apply to models with daytime running lights

No.25/6

FABIA

Current Flow Diagram

Turn signal switch, parking light switch, lighting rheostat - switches and instruments

ws sw ro br gn bl gr li ge or

D E2 E19 E20 L105 T5d T6d T8a T12b T16a X

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Ignition/starter switch Turn signal switch Parking light switch Switches and instruments lighting control Illumination for lighting rheostat 5-pin connector, at left C pillar (pink) Connector, 6-pin, at switch lighting rheostat 8-pin connector, at ignition/starter switch 12-pin connector, at turn signal light switch 16-pin connector, at electrical system control unit (black) - Number plate light

81

A43

- Earth connection, in wiring harness behind dash panel - Positive connection (58), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A3 A4 A11

W11 - Connection (58), in tailgate wiring loom ♦

- Does not apply to models with daytime running lights

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Daytime running lights, from August 2002 (does not apply to models with gas discharge lights)

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.26/1

No.26/2

Current Flow Diagram

FABIA

Light switch

ws sw ro br gn bl gr li ge or

E1 E23 K L9 T6c

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Light switch Front and rear fog light switch Dash panel insert Lighting switch illumination bulb 6-pin connector, at electrical system control unit (black) T8c - 8-pin connector, at dash panel insert T17a - 17-pin connector, at light switch

81 A9 A11 A33 A34 A56 A83

- Earth connection, in wiring harness behind dash panel - Connection (56b), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel - Connection (58, daytime running lights), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.26/3

Current Flow Diagram

Headlight dipper/flasher switch, headlights, fuse holder

ws sw ro br gn bl gr li ge or

E4 M1 M3 M5 M7 M29 M30 M31 M32 T10a T10b T11a T12a T12b 29 85

-

Headlight dipper/flasher switch Side light bulb, left Side light bulb, right Turn signal bulb, front left Turn signal bulb, front right Headlight dipped beam bulb, left Headlight main beam bulb, left Headlight dipped beam bulb, right Headlight main beam bulb, right 10-pin connector, at left headlight 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) 12-pin connector, at headlight dipper/flasher switch

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth connection -1-, in wiring loom in left of engine compartment

white black red brown green blue grey purple yellow orange

A9

- Connection (56b), in wiring loom behind dash panel

A56

A84

- Positive connection (30a), in wiring loom behind dash panel - Connection (58, daytime running lights), in wiring loom behind dash panel on left - Connection (58L), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

A83

- Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom D152

* Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- Does not apply to models with bulb failure indicator

No.26/4

FABIA

Current Flow Diagram

Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E2 E19 E229 K6 L76 M18 M19 SB44 T2b T2c T6c

-

T6e T11a T12b T16a

-

Turn signal switch Parking light switch Button for hazard warning lights Hazard warning light system warning lamp Switch/button illumination Side turn signal bulb, left Side turn signal bulb, right Fuse, in fuse holder 2-pin connector, at left side turn signal light 2-pin connector, at right side turn signal light 6-pin connector, at electrical system control unit (black) 6-pin connector, at hazard warning light pushbutton 11-pin connector, at left of bulkhead (white) 12-pin connector, at turn signal light switch 16-pin connector, at electrical system control unit (black)

81 85 332 A5 A6 D57 D58

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in wiring loom in left of engine compartment - Earth connection, in wiring harness behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (right turn signal light), in right engine compartment wiring loom - Connection (left turn signal light), in left engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.26/5

Current Flow Diagram

Brake light switch, left tail light, fuse holder

ws sw ro br gn bl gr li ge or

F F4 F47 J... K13 M6 M9 M16 M41 T2h T4d T6l T32a

-

Brake light switch Reversing light switch Brake pedal switch Engine control units Rear fog light warning lamp Turn signal bulb, rear left Brake light bulb, left Reversing light bulb left Left tail light and rear fog light bulb 2-pin connector, at reversing light switch 4-pin connector, at brake pedal switch 6-pin connector, at left tail light 32-pin connector, at dash panel insert

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

A6 A18

- Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

* ** ♦

- Does not apply to models with bulb failure indicator - Does not apply to models with automatic gearbox - does not apply to models with trailer coupling

No.26/6

FABIA

Current Flow Diagram

Right tail light, centre high-mounted brake light, licence plate light, fuse holder

ws sw ro br gn bl gr li ge or

E20 M8 M10 M17 M25 M42 T2i T5d T6d T6m T6o X

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Switches and instruments lighting control Turn signal bulb, rear right Brake light bulb, right Reversing light bulb right Centre high-mounted brake light bulb Right tail light and rear fog light bulb 2-pin connector, at centre high-mounted brake light 5-pin connector, at left C pillar (pink) 6-pin connector, at lighting control and headlight range control adjuster - 6-pin connector, at right tail light - 6-pin connector, at electrical system control unit (black) - Number plate light

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

98

A18

- Earth connection, in engine compartment wiring harness - Positive connection (58), in wiring loom behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

W11

- Connection (58), in tailgate wiring loom

A3 A5

=== -

* ** ♦

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to Saloon models applies only to Saloon models

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Day driving light - Gas discharge lamps, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.27/1

No.27/2

Current Flow Diagram

FABIA

Light switch

ws sw ro br gn bl gr li ge or

E1 E23 K L9 T6c

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Light switch Front and rear fog light switch Dash panel insert Lighting switch illumination bulb 6-pin connector, at electrical system control unit (black) T8c - 8-pin connector, at dash panel insert T17a - 17-pin connector, at light switch

81 A9 A11 A33 A34 A56 A83

- Earth connection, in wiring harness behind dash panel - Connection (56b), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel - Connection (58, daytime running lights), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.27/3

Current Flow Diagram

Headlight range adjustment control unit, headlight range adjustment, fuse holder

ws sw ro br gn bl gr li ge or

J431 - Headlight beam adjustment control unit (at rear axle) SB12 - Fuse, in fuse holder T8s - Connector, 8-pin, at headlight range adjustment control unit T10a - 10-pin connector, at left headlight T10b - 10-pin connector, at right headlight T12a - 12-pin connector, at left of bulkhead (white) V48 - Headlight range control motor, left V49 - Headlight range control motor, right

85

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in wiring loom in left of engine compartment - Earth connection -1-, in rear interior wiring loom

A9

- Connection (56b), in wiring loom behind dash panel

A27

- Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (headlight range control), in engine compartment wiring loom

A70 A76 D96

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

No.27/4

Current Flow Diagram

FABIA

Left gas discharge light, fuse holder

ws sw ro br gn bl gr li ge or

J426 L13 M1 M5 M30 T10a T11a T12a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Left headlight ballast unit (gas discharge) Left gas discharge light Side light bulb, left Turn signal bulb, front left Headlight main beam bulb, left 10-pin connector, at left headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white)

85 A9 A83

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A84

- Connection (58, daytime running lights), in wiring loom behind dash panel on left - Connection (58L), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

D152

- Positive connection (56bL), in left engine compartment wiring loom

*

- Does not apply to models with bulb failure indicator

Edition 07.03 S00.5324.00.20

FABIA

No.27/5

Current Flow Diagram

Right gas discharge bulb, dimming and headlight flasher switch, fuse holder

ws sw ro br gn bl gr li ge or

E4 J427 L14 M3 M7 M32 T10b T11a T12a T12b

-

Headlight dipper/flasher switch Right headlight ballast unit (gas discharge) Right gas discharge light Side light bulb, right Turn signal bulb, front right Headlight main beam bulb, right 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) 12-pin connector, at headlight dipper/flasher switch

Edition 07.03 S00.5324.00.20

85 A9 A56

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A85

- Positive connection (30a), in wiring loom behind dash panel - Connection (58, daytime running lights), in wiring loom behind dash panel on left - Connection (58R), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

D153

- Positive connection (56bR), in right engine compartment wiring loom

*

- Does not apply to models with bulb failure indicator

A83

No.27/6

FABIA

Current Flow Diagram

Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E2 E19 E229 K6 L76 M18 M19 SB44 T2b T2c T6c

-

T6e T11a T12b T16a

-

Turn signal switch Parking light switch Button for hazard warning lights Hazard warning light system warning lamp Switch/button illumination Side turn signal bulb, left Side turn signal bulb, right Fuse, in fuse holder 2-pin connector, at left side turn signal light 2-pin connector, at right side turn signal light 6-pin connector, at electrical system control unit (black) 6-pin connector, at hazard warning light pushbutton 11-pin connector, at left of bulkhead (white) 12-pin connector, at turn signal light switch 16-pin connector, at electrical system control unit (black)

81 85 332 A5 A6 D57 D58

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in wiring loom in left of engine compartment - Earth connection, in wiring harness behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (right turn signal light), in right engine compartment wiring loom - Connection (left turn signal light), in left engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.27/7

Current Flow Diagram

Brake light switch, left tail light, fuse holder

ws sw ro br gn bl gr li ge or

F F4 F47 J... K13 M6 M9 M16 M41 T2h T4d T6l T32a

-

Brake light switch Reversing light switch Brake pedal switch Engine control units Rear fog light warning lamp Turn signal bulb, rear left Brake light bulb, left Reversing light bulb left Left tail light and rear fog light bulb 2-pin connector, at reversing light switch 4-pin connector, at brake pedal switch 6-pin connector, at left tail light 32-pin connector, at dash panel insert

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

A6 A18

- Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

* ** ♦

- Does not apply to models with bulb failure indicator - Does not apply to models with automatic gearbox - does not apply to models with trailer coupling

No.27/8

FABIA

Current Flow Diagram

Right tail light, centre high-mounted brake light, licence plate light, fuse holder

ws sw ro br gn bl gr li ge or

E20 M8 M10 M17 M25 M42 T2i T5d T6d T6m T6o X

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Switches and instruments lighting control Turn signal bulb, rear right Brake light bulb, right Reversing light bulb right Centre high-mounted brake light bulb Right tail light and rear fog light bulb 2-pin connector, at centre high-mounted brake light 5-pin connector, at left C pillar (pink) Connector, 6-pin, at switch lighting rheostat 6-pin connector, at right tail light 6-pin connector, at electrical system control unit (black) - Number plate light

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

98

A18

- Earth connection, in engine compartment wiring harness - Positive connection (58), in wiring loom behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

W11

- Connection (58), in tailgate wiring loom

A3 A5

=== -

* ** ♦

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to Saloon models applies only to Saloon models

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Fog lights, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.28/1

No.28/2

Current Flow Diagram

FABIA

Fog lights

ws sw ro br gn bl gr li ge or

E23 K17 L22 L23 T2b T2c T6p T17a T32a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Front and rear fog light switch Fog light warning lamp Front left fog light bulb Front right fog light bulb 2-pin connector, at left fog light 2-pin connector, at right fog light 6-pin connector, at left of bulkhead (red) 17-pin connector, at light switch 32-pin connector, at dash panel insert

124

- Earth connection, in engine compartment wiring harness B205 - Connection (fog lights), in wiring loom behind dash panel D59 - Connection (fog lights), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Bulb failure indicator, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

13

- Bulb failure control unit

14

- Bulb failure control unit

No.29/1

No.29/2

Current Flow Diagram

FABIA

Bulb failure indicator

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J571 L13 L14 M1 M3 M29 M31 M41 M42 T6l T6m T10a T10b T11a T12a SB33 SB34 SB50 SB54

white black red brown green blue grey purple yellow orange

-

Bulb failure control unit Left gas discharge light Right gas discharge light Side light bulb, left Side light bulb, right Headlight dipped beam bulb, left Headlight dipped beam bulb, right Left tail light and rear fog light bulb Right tail light and rear fog light bulb 6-pin connector, at left tail light 6-pin connector, at right tail light 10-pin connector, at left headlight 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) Fuse, in fuse holder Fuse, in fuse holder Fuse, in fuse holder Fuse, in fuse holder

335 A84

- Earth connection, in wiring harness behind dash panel - Connection (58L), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

A139

- Positive connection (15), in wiring loom behind dash panel - Connection -2- (58L), in wiring loom behind dash panel - Connection -2- (58R), in wiring loom behind dash panel - Positive connection (56bL), in left engine compartment wiring loom - Positive connection (56bR), in right engine compartment wiring loom

A169 A170 D152 D153

Edition 07.03 S00.5324.00.20

FABIA

No.29/3

Current Flow Diagram

Bulb failure indicator

ws sw ro br gn bl gr li ge or

F J285 J571 K K170 M9 M10 M25 T2i T4d T5d T6l T6m T32a

-

Brake light switch Control unit in dash panel insert Bulb failure control unit Dash panel insert Light failure indicator light Brake light bulb, left Brake light bulb, right Centre high-mounted brake light bulb 2-pin connector, at centre high-mounted brake light 4-pin connector, at brake pedal switch 5-pin connector, at left C pillar (pink) 6-pin connector, at left tail light 6-pin connector, at right tail light 32-pin connector, at dash panel insert

Edition 07.03 S00.5324.00.20

A18

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (54), in wiring loom behind dash panel

♦ - does not apply to Saloon models = = = - applies only to Saloon models

FABIA

Current Flow Diagram

Electric sliding roof, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.30/1

No.30/2

Current Flow Diagram

FABIA

Electric sliding roof

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E139 J245 J393 T6e T6f T18b

white black red brown green blue grey purple yellow orange

-

Sliding roof adjustment controller Sliding roof adjustment control unit Convenience electrics central control unit 6-pin connector, at sliding roof adjustment control unit 6-pin connector, at sliding roof adjustment controller 18-pin connector, at electrical system control unit (black) T23a - 23-pin connector, at convenience electrics central control unit V1 - Sliding roof motor

199 A27 A56

- Earth connection, in wiring harness behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel

■ ■ ■ - Applies only to models with central locking

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Seat heaters, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.31/1

No.31/2

Current Flow Diagram

FABIA

Driver heated seat

ws sw ro br gn bl gr li ge or

E94 G59 J131 L44 T2e T6g T6h T8l T18b Z6 Z7

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Heated driver’s seat switch with regulator Temperature sensor - driver’s seat Heated driver’s seat control unit Bulb for illuminating seat heater regulator 2-pin connector, below driver seat 6-pin connector, below driver seat (green) 6-pin connector, at seat heater adjuster 8-pin connector, at heated driver seat control unit 18-pin connector, at electrical system control unit (black) - Heated driver’s seat cushion - Heated driver’s seat backrest

96 110 199 A4 O2 O12

*

- Earth connection, in seat heater wiring loom driver side - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (15a, seat heater), in wiring loom behind dash panel - Connection -1-, in seat heater wiring loom driver side - Below driver seat

Edition 07.03 S00.5324.00.20

FABIA

No.31/3

Current Flow Diagram

Seat heater front passenger side, fuse holder

ws sw ro br gn bl gr li ge or

E95 G60 J132 L44 T2f T6i T6t T8m

-

Heated front passenger’s seat switch with regulator Temperature sensor - front passenger’s seat Heated passenger’s seat control unit Bulb for illuminating seat heater regulator 2-pin connector, below passenger seat 6-pin connector, below passenger seat (green) 6-pin connector, at seat heater adjuster 8-pin connector, at heated front passenger seat control unit T18b - 18-pin connector, at electrical system control unit (black) Z8 - Heated front passenger’s seat cushion Z9 - Heated front passenger’s seat backrest

110 136 A4 A15 O2 O13

*

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in seat heater wiring loom front passenger side - Positive connection (58b), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a, seat heater), in wiring loom behind dash panel - Connection -2-, in seat heater wiring loom front passenger side - Below front passenger seat

FABIA

Current Flow Diagram

Air conditioning, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.32/1

No.32/2

Current Flow Diagram

FABIA

Air conditioning control unit, fresh air blower, fresh and recirculated air flap positioning motor, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E9 E159 G56 G143

-

J301 K114 L16 N24 T2u T4e T5h T6s

-

T10c T18c V2 V42 V154

-

Fresh air blower switch Fresh and recirculated air flap switch Dash panel temperature sensor Fresh and recirculated air flap positioning motor potentiometer AC control unit Fresh air and air recirculation operation warning lamp Air conditioning control lighting Series resistor with overheating fuse 2-pin connector, at fresh air blower 4-pin connector, at fresh air blower series resistor 5-pin connector, at fresh air blower switch 6-pin connector, at fresh/recirculated air flap positioning motor 10-pin connector, behind dash panel on right 18-pin connector, at air conditioning control unit Fresh air blower Temperature sensor blower - dash panel Fresh and recirculated air flap motor

606

- Earth point, under the centre console, near gear stick

A34

- Positive connection (75x), in wiring loom behind dash panel - Connection (75al), in air conditioning wiring loom

L4 L5 L31

- Connection (sender earth), in air conditioning wiring loom - Connection (5V), in air conditioning wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.32/3

Current Flow Diagram

Air conditioning control unit, temperature flap positioning motor, temperature sender

ws sw ro br gn bl gr li ge or

E35 G92 G191 G192 G263 G267 J301 K84 SB3 T2h

-

T2i

-

T2j

-

T6u T16b T16e T18c V68 -

Air conditioner switch Temperature flap positioning motor potentiometer Centre outlet air temperature sender Footwell vent temperature sender Evaporator outlet air temperature sender Temperature selector rotary knob potentiometer AC control unit Air conditioning warning light Fuse, in fuse holder 2-pin connector at footwell vent temperatur sender 2-pin connector at evaporator out-flow temperature sender 2-pin connector at centre footwell vent temperatur sender 6-pin connector, at temperature flap positioning motor 16-pin connector, in glove box on driver’s side (diagnosis connection) 16-pin connector, at AC control unit 18-pin connector, at air conditioning control unit Temperature flap positioning motor

Edition 07.03 S00.5324.00.20

A68 L5 L6 L31

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a, AC), in wiring loom behind dash panel - Connection (sender earth), in air conditioning wiring loom - Connection (sender earth), in air conditioning wiring loom - Connection (5V), in air conditioning wiring loom

No.32/4

FABIA

Current Flow Diagram

Air conditioning control unit, AC compressor control valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J301 N280 SB12 T2k T2l T11d T14a

white black red brown green blue grey purple yellow orange

-

AC control unit AC compressor control valve Fuse, in fuse holder 2-pin connector, in bracket at gearbox 2-pin connector, at compressor 11-pin connector, at left of bulkhead (brown) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16e - 16-pin connector, at AC control unit T18b - 18-pin connector, at electrical system control unit (black)

82

- Earth connection, in front left wiring harness

281

- Earth connection -1-, in engine pre-assembly wiring loom 332 - Earth connection, in wiring harness behind dash panel A70 - Positive connection (15a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*= = =

- does not apply to engine code AWY - applies only to engine codes AWY

Edition 07.03 S00.5324.00.20

FABIA

No.32/5

Current Flow Diagram

Radiator fan control unit, fuse holder on battery, high-pressure sensor

ws sw ro br gn bl gr li ge or

G65 J293 S177 S180 S269 T3t T6v

-

High-pressure sensor Radiator fan control unit Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery Fuse -11- (30), in fuse holder on battery 3-pin connector, at high-pressure sensor 6-pin connector, at radiator fan control unit

Edition 07.03 S00.5324.00.20

12a 82 D155

P1

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness - Connection (15, high-pressure sender), in engine compartment wiring loom - Positive connection (30), in fuse holder on battery

No.32/6

Current Flow Diagram

FABIA

Radiator fan control unit, Radiator fan thermal switch, Radiator fan (not valid for engine code letters AMF)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

82

- Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

Edition 07.03 S00.5324.00.20

FABIA

No.32/7

Current Flow Diagram

Radiator fan control unit, Radiator fan thermal switch, Radiator fan (only for engine code letters AMF)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T4t T6v V7

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan

Edition 07.03 S00.5324.00.20

82

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in front left wiring harness

FABIA

Current Flow Diagram

Radio system, from August 2002

Edition 07.03 S00.5324.00.20

No.33/1

No.33/2

Current Flow Diagram

FABIA

Radio, front speakers, aerial

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

R R11 R20 R21 R22 R23 R24 S92 SB45 T2m T2n T4m T4n T4u T4v T8d T8n

white black red brown green blue grey purple yellow orange

-

Radio Aerial Treble loudspeaker, front left Bass loudspeaker, front left Treble loudspeaker, front right Bass loudspeaker, front right Aerial amplifier Radio fuse Fuse, in fuse holder 2-pin connector, at front left treble loudspeaker 2-pin connector, at front right treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at right A pillar (black) 4-pin connector, at left front woofer 4-pin connector, at right front woofer 8-pin connector, at radio (black) 8-pin connector, at radio (brown)

A11 A21 A27 A46 A76

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.33/3

Current Flow Diagram

Radio, rear speakers

ws sw ro br gn bl gr li ge or

J412 R R14 R15 R16 R17 T2o T2p T2r T2s T2t T2u T4o T4p T8d

- Control unit for telephone operating electronics (interface box) - Radio - Treble loudspeaker, rear left - Bass loudspeaker, rear left - Treble loudspeaker, rear right - Bass loudspeaker, rear right - 2-pin connector, at rear left treble loudspeaker - 2-pin connector, at rear right treble loudspeaker - 2-pin connector, at rear left bass loudspeaker - 2-pin connector, at rear left bass loudspeaker - 2-pin connector, at rear right bass loudspeaker - 2-pin connector, at rear right bass loudspeaker - 4-pin connector, at left B pillar (black) - 4-pin connector, at right B pillar (black) - 8-pin connector, at radio (black)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T8n - 8-pin connector, at radio (brown) T18d - 18-pin connector, at control unit for telephone operating electronics (interface box) T20a - 20-pin connector, at radio 606

*■ ■ ■

- Earth point, under the centre console, near gear stick - Applies only to models with 8 speakers - applies only to models with mobile phone preinstallation 2-Cullmann

FABIA

Current Flow Diagram

Radio system with CD changer, from August 2002

Edition 07.03 S00.5324.00.20

No.34/1

No.34/2

Current Flow Diagram

FABIA

Radio, front speakers, CD changer, aerial

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

R R11 R20 R21 R24 R41 S92 SB45 T2m T4m T4u T8d T8n T12k T20a

white black red brown green blue grey purple yellow orange

-

Radio Aerial Treble loudspeaker, front left Bass loudspeaker, front left Aerial amplifier CD changer Radio fuse Fuse, in fuse holder 2-pin connector, at front left treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at left front woofer 8-pin connector, at radio (black) 8-pin connector, at radio (brown) 12-pin connector, at CD changer 20-pin connector, at radio

A11 A21 A27 A46 A76

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.34/3

Current Flow Diagram

Radio, front speakers, CD changer

ws sw ro br gn bl gr li ge or

J412

- Operating electronics/telephone control unit (Interface box) R - Radio R22 - Treble loudspeaker, front right R23 - Bass loudspeaker, front right R41 - CD changer T2n - 2-pin connector, at front right treble loudspeaker T4n - 4-pin connector, at right A pillar (black) T4v - 4-pin connector, at right front woofer T8d - 8-pin connector, at radio (black) T8n - 8-pin connector, at radio (brown) T12k - 12-pin connector, at CD changer T18d - 18-pin connector, at control unit for telephone operating electronics (interface box) T20a - 20-pin connector, at radio

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

V14

- Connection (screening), in CD changer wiring loom

V45

- Connection -2- (screening), in CD changer wiring harness

■ ■ ■ - applies only to models with mobile phone

preinstallation 2-Cullmann

No.34/4

FABIA

Current Flow Diagram

Radio, rear speakers

ws sw ro br gn bl gr li ge or

R R14 R15 R16 R17 T2o T2p T2r T2s T2t T2u T4o T4p T8d T8n

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Radio Treble loudspeaker, rear left Bass loudspeaker, rear left Treble loudspeaker, rear right Bass loudspeaker, rear right 2-pin connector, at rear left treble loudspeaker 2-pin connector, at rear right treble loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear right bass loudspeaker 2-pin connector, at rear right bass loudspeaker 4-pin connector, at left B pillar (black) 4-pin connector, at right B pillar (black) 8-pin connector, at radio (black) 8-pin connector, at radio (brown)

255 606

*

- Earth connection -1-, in wiring loom behind dash panel - Earth point, under the centre console, near gear stick - Applies only to models with 8 speakers

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Navigation system with CD changer, from August 2002

Edition 07.03 S00.5324.00.20

No.35/1

No.35/2

FABIA

Current Flow Diagram

Navigation system control unit

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J412 J503 S258 SB45 T8d T18d T20a

white black red brown green blue grey purple yellow orange

- Control unit for telephone operating electronics (interface box) - Navigation system control unit - Fuse for navigation system - Fuse, in fuse holder - 8-pin connector, at navigation system control unit (black) - 18-pin connector, at control unit for telephone operating electronics (interface box) - 20-pin connector, at navigation system control unit

255 606 A11 A21 A27 A46 A76

- Earth connection -1-, in wiring loom behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

= = = - applies only to models with CD changer ■ ■ ■ - applies only to models with mobile phone

preinstallation 2-Cullmann

Edition 07.03 S00.5324.00.20

FABIA

No.35/3

Current Flow Diagram

Navigation system control unit, front speakers

ws sw ro br gn bl gr li ge or

J503 R20 R21 R22 R23 T2m T2n T4m T4n T4u T4v T8n

-

Navigation system control unit Treble loudspeaker, front left Bass loudspeaker, front left Treble loudspeaker, front right Bass loudspeaker, front right 2-pin connector, at front left treble loudspeaker 2-pin connector, at front right treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at right A pillar (black) 4-pin connector, at left front woofer 4-pin connector, at right front woofer 8-pin connector, at navigation system control unit (brown)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

No.35/4

FABIA

Current Flow Diagram

Navigation system control unit, rear speakers

ws sw ro br gn bl gr li ge or

J503 R14 R15 R16 R17 T2o T2p T2r T2s T2t T2u T4o T4p T8n

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Navigation system control unit Treble loudspeaker, rear left Bass loudspeaker, rear left Treble loudspeaker, rear right Bass loudspeaker, rear right 2-pin connector, at rear left treble loudspeaker 2-pin connector, at rear right treble loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear right bass loudspeaker 2-pin connector, at rear right bass loudspeaker 4-pin connector, at left B pillar (black) 4-pin connector, at right B pillar (black) 8-pin connector, at navigation system control unit (brown)

*

- Applies only to models with 8 speakers

Edition 07.03 S00.5324.00.20

FABIA

No.35/5

Current Flow Diagram

Navigation system control unit, aerial

ws sw ro br gn bl gr li ge or

F4 J104 J503 M16 M17 R50 R51 SB12 T8e T13b T26a T42a

-

Reversing light switch ABS/ABS with EDL and TCS/ESP control unit Navigation system control unit Reversing light bulb left Reversing light bulb right Navigation aerial (GPS) Radio/telephone aerial Fuse, in fuse holder Plug connection, 8-pin, at left of bulkhead (orange) 13-pin connector, for telephone 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS/ABS with EDL and TCS/ ESP control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A70

- Positive connection (15a), in wiring loom behind dash panel B182 - Connection (RF), in interior wiring loom ♦♦ ♦♦♦ -

* ** ♦

Does not apply to models with automatic gearbox Navigation system aerial cable Mobile phone aerial cable Radio aerial cable on Notchback models R50 is behind dash panel

No.35/6

FABIA

Current Flow Diagram

Navigation system control unit, CD changer

ws sw ro br gn bl gr li ge or

J503 R41 T12k T20a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Navigation system control unit CD changer 12-pin connector, at CD changer 20-pin connector, at navigation system control unit

V14

- Connection (screening), in CD changer wiring loom

V45

- Connection -2- (screening), in CD changer wiring harness

= = = - applies only to models with CD changer

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Mobile phone preinstallation, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.36/1

No.36/2

Current Flow Diagram

FABIA

Telephone preinstallation

ws sw ro br gn bl gr li ge or

E20 J503 R R51 T4s T6d

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Switches and instruments lighting control Navigation system control unit Radio Radio/telephone aerial 4-pin connector, behind radio (telephone preinstallation) - 6-pin connector, at lighting control and headlight range control adjuster

354 A11 A98

* **

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Radio aerial cable - Mobile phone aerial cable

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

Telephone preinstallation 2-Cullmann, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.37/1

No.37/2

Current Flow Diagram

FABIA

Operating electronics/mobile phone control unit (interface box), mobile phone microphone, aerial, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J412 J503 R R38 R51 SB12 T2y T8d T13b T18d T20a

white black red brown green blue grey purple yellow orange

- Control unit for telephone operating electronics (interface box) - Navigation system control unit - Radio - Microphone for telephone - Radio/telephone aerial - Fuse, in fuse holder - 2-pin connector, at telephone microphone - 8-pin connector, at radio or at navigation system control unit (black) - 13-pin connector, for telephone - 18-pin connector, at control unit for telephone operating electronics (interface box) - Plug connection, 20-pin, at radio or at navigation system control unit

332 A11 A27 A70 A98

* **

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Radio aerial cable - Mobile phone aerial cable

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

Headlight washer system, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 6

Edition 07.03 S00.5324.00.20

- Headlight washer system relay

No.38/1

No.38/2

Current Flow Diagram

FABIA

Headlight washer system relay, headlight washer system pump, fuse holder

ws sw ro br gn bl gr li ge or

E1 J39 T2g T3a T6c

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Light switch Headlight washer system relay 2-pin connector, at headlight wash system pump 3-pin connector, at left of bulkhead (grey) 6-pin connector, at electrical system control unit (black) T17a - 17-pin connector, at light switch T18b - 18-pin connector, at electrical system control unit (black) V11 - Headlight washer pump

12a 81 A56

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in wiring harness behind dash panel - Positive connection (30a), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Heated washer nozzles, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.39/1

No.39/2

Current Flow Diagram

FABIA

Heated washer nozzles

ws sw ro br gn bl gr li ge or

T2w T2x T6p Z20 Z21

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- 2-pin connector, at left washer nozzle heating resistor - 2-pin connector, at right washer nozzle heating resistor - 6-pin connector, at left of bulkhead (red) - Left washer nozzle heating resistor - Right washer nozzle heating resistor

13

- Earth point, in front right of engine compartment

132

- Earth connection -3-, in engine compartment wiring harness A139 - Positive connection (15), in wiring loom behind dash panel C14 - Positive connection (15, heated washer nozzles), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Trailer coupling, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.40/1

No.40/2

FABIA

Current Flow Diagram

Trailer coupling

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F - Brake light switch F216 - Rear fog light cutout, contact switch, in socket for trailer coupling J446 - Control unit for parking aid M41 - Left tail light and rear fog light bulb T3x - 3-pin connector, at rear fog light cutout contact switch T6l - 6-pin connector, at left tail light T13a - 13-pin socket T16f - Connector, 16-pin, at parking aid control unit U10 - Trailer socket

61

- Earth point, C-pillar left

87

- Earth connection -2-, in rear interior wiring loom

A5

- Positive connection (right turn signal light), in wiring loom behind dash panel - Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A6 A18 A57 A84

- Positive connection (30a), in wiring loom behind dash panel - Connection (58L), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Parking aid, from August 2002

Edition 07.03 S00.5324.00.20

No.41/1

No.41/2

FABIA

Current Flow Diagram

Parking aid

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F4 - Reversing light switch F216 - Rear fog light cutout, contact switch, in socket for trailer coupling G203 - Rear left parking aid sender G204 - Rear left, centre, parking aid sender H15 - Warning buzzer for rear parking aid J446 - Control unit for parking aid M16 - Reversing light bulb left M17 - Reversing light bulb right T2n - Connector, 2-pin, at parking aid warning buzzer T3a - Connector, 3-pin, at parking aid sender, rear left T3b - Connector, 3-pin, at parking aid sender, rear left, middle T3x - 3-pin connector, at rear fog light cutout contact switch T12l - Connector, 12-pin, at parking aid control unit T16f - Connector, 16-pin, at parking aid control unit

B182

- Connection (RF), in interior wiring loom

* **

- Does not apply to models with automatic gearbox - applies only to models with trailer coupling

Edition 07.03 S00.5324.00.20

FABIA

No.41/3

Current Flow Diagram

Parking aid

ws sw ro br gn bl gr li ge or

G205 G206 J446 SB12 T3c T3d T12l T16f

-

Rear right, centre, parking aid sender Rear right parking aid sender Control unit for parking aid Fuse, in fuse holder Connector, 3-pin, at parking aid sender, rear right, middle - Connector, 3-pin, at parking aid sender, rear right - Connector, 12-pin, at parking aid control unit - Connector, 16-pin, at parking aid control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in rear interior wiring loom

196

- Earth connection -3-, in rear interior wiring loom

A70

- Positive connection (15a), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

A76

FABIA

Current Flow Diagram

Rear reading lights, from August 2002

Edition 07.03 S00.5324.00.20

No.42/1

No.42/2

Current Flow Diagram

FABIA

Rear reading lights (does not apply to Notchback models)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J317 SB4 T3c T3y T3z T5a

-

T5b T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 5-pin connector, at left C pillar (brown) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

98

- Earth connection, in engine compartment wiring harness 354 - Earth connection, in wiring harness behind dash panel A23 - Positive connection (30al), in wiring loom behind dash panel A29 - Connection (interior light 31), in wiring loom behind dash panel Q150 - Connection (30al), in boot lid/tailgate wiring loom Q151

- Connection (interior light 31), in boot lid/tailgate wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.42/3

Current Flow Diagram

Rear reading lights (applies only to Notchback models)

ws sw ro br gn bl gr li ge or

J317 SB4 T3c T3y T3z T5a

-

T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in rear interior wiring loom

354

- Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

A23 A29

FABIA

Current Flow Diagram

Headlight range control for vehicles Junior and Classic, from August 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.43/1

No.43/2

Current Flow Diagram

FABIA

Headlight beam control adjuster, headlight beam control, fuse holder (does not apply to models fitted with gas discharge bulbs)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E1 E102 L54 T5d T6d

-

T10a T10b T12a T17a V48 V49 X

-

Light switch Headlight range control adjuster Headlight range control regulator illumination 5-pin connector, at left C pillar (pink) 6-pin connector, at lighting control and headlight range control adjuster 10-pin connector, at left headlight 10-pin connector, at right headlight 12-pin connector, at left of bulkhead (white) 17-pin connector, at light switch Headlight range control motor, left Headlight range control motor, right Number plate light

81 85 A3 A4 A9

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in wiring loom in left of engine compartment - Positive connection (58), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (56b), in wiring loom behind dash panel

A11

- Positive connection (58b), in wiring loom behind dash panel D96 - Connection (headlight range control), in engine compartment wiring loom D152 - Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Luggage compartment light - Praktik, from August 2002

Edition 07.03 S00.5324.00.20

No.44/1

No.44/2

Current Flow Diagram

FABIA

Luggage compartment light - Praktik

ws sw ro br gn bl gr li ge or

F5 T4c T4e T5b W3

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Luggage compartment light switch 4-pin connector, at boot/tailgate lock 4-pin connector at the luggage compartment lighting 5-pin connector, at left C pillar (brown) Luggage compartment light

61

- Earth point, C-pillar left

98

- Earth connection, in engine compartment wiring harness - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

A23 A29

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.45/1

Windscreen wiper motor for 1.4 l/50 kW with Cruise control system without ABS, from August 2002

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.45/2

Current Flow Diagram

FABIA

Windscreen wiper motor, windscreen wiper motor changeover relay, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J368 S272 SB41 T1d

-

T4a

-

T4y T5a

-

T5c

-

T6v T12a T18a V

-

Windscreen wiper motor changeover relay Fuse -14- (30), in fuse holder on battery Fuse, in fuse holder Connector, 1-pin, at windscreen wiper motor changeover relay Connector, 4-pin, at windscreen wiper motor changeover relay Connector, 4-pin, at windscreen wiper motor 5-pin connector, at electrical system control unit (black) 5-pin connector, at electrical system control unit (brown) 6-pin connector, at left of bulkhead (green) 12-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Windscreen wiper motor

80

606

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth point, under the centre console, near gear stick

P1

- Positive connection (30), in fuse holder on battery

357

*

- close to windscreen wiper motor

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

CAN databus networking - Drive, from August 2002

Edition 07.03 S00.5324.00.20

No.46/1

No.46/2

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, databus diagnostic interface, plug connection for diagnostic socket, connection for airbag control unit

ws sw ro br gn bl gr li ge or

J234 J285 J533 K T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

T16b T18a T32a T75a -

Airbag control unit Control unit in dash panel insert Databus diagnostic interface Dash panel insert 16-pin connector, at electrical system control unit (black) 16-pin connector, in glove box on driver’s side (diagnosis connection) 18-pin connector, at electrical system control unit (brown) 32-pin connector, at dash panel insert 75-pin connector, at airbag control unit

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A121 - Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.46/3

Current Flow Diagram

Connection for: ABS/ABS with EDL and TCS/ESP control unit, automatic gearbox control unit, power-assisted steering control unit, control units for engines, steering angle sender

ws sw ro br gn bl gr li ge or

G85 - Steering angle sender J104 - ABS/ABS with EDL and TCS/ESP control unit J217 - Automatic gearbox control unit J220 - Motronic control unit J248 - Diesel direct injection system control unit J361 - Simos control unit J500 - Power-assisted steering control unit J687 - 4MV control unit T4r - Plug connection, 4-pin, at power-assisted steering control unit T6y - Connector, 6-pin, at steering angle sender T8r - Plug connection, 8-pin, at automatic gearbox (connection to wiring loom in engine compartment) T11a - 11-pin connector, at left of bulkhead (white) T42a - Connector, 42-pin, at ABS/ABS with EDL and TCS/ ESP control unit T68a - 68-pin connector, at automatic gearbox control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

FABIA

Current Flow Diagram

CAN-Bus Networking - Convenience, from August 2002

Edition 07.03 S00.5324.00.20

No.47/1

No.47/2

Current Flow Diagram

FABIA

Dash panel insert, Control unit in dash panel insert, Data bus diagnostic interface, Connector for diagnostic connection, Connection for air conditioning system control unit

ws sw ro br gn bl gr li ge or

J285 J301 J533 K T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

T16b T16e T18a T18b T32a -

Control unit in dash panel insert AC control unit Databus diagnostic interface Dash panel insert 16-pin connector, at electrical system control unit (black) 16-pin connector, in glove box on driver’s side (diagnosis connection) 16-pin connector, at AC control unit 18-pin connector, at electrical system control unit (brown) 18-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.47/3

Current Flow Diagram

Connection for: Driver door control unit, Front passenger door control unit, Rear left door control unit

ws sw ro br gn bl gr li ge or

J386 J387 J388 T6l T6n T6o T8h T8i T8j

-

Door control unit, driver’s side Door control unit, passenger’s side Door control unit, rear left 6-pin connector, at left B pillar (blue) Connector, 6-pin, at left A-pillar (blue) 6-pin connector, at right A pillar (blue) Connector, 8-pin, at door control unit, driver side Connector, 8-pin, at door control unit, front passenger side - Connector, 8-pin, at rear left door control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

No.47/4

Current Flow Diagram

FABIA

Connection for: Rear right door control unit, Convenience system central control unit

ws sw ro br gn bl gr li ge or

J389 J393 T6m T8k T23a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Door control unit, rear right Convenience electrics central control unit 6-pin connector, at right B pillar (blue) Connector, 8-pin, at rear right door control unit 23-pin connector, at convenience electrics central control unit

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

1.2 l - Simos 3 Unit Injection/40 kW, engine code AWY, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

4

- Fuel pump relay

12

- Simos power supply relay

No.48/1

No.48/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery, radiator fan (models not fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S177 S180 T1a T2v T3h T3i T6n T8a T11a T14a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T18a - 18-pin connector, at electrical system control unit (brown)

V7 12a P1

- Radiator fan - Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan dependent on optional

equipment (does not apply to models fitted with air conditioning or fitted with trailer coupling) = = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

Edition 07.03 S00.5324.00.20

FABIA

No.48/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan (models fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

= = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

No.48/4

Current Flow Diagram

FABIA

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 T2a T2b T2c T2y T3m T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

A121 A122 D140 D159 D160

- Connection panel on - Connection panel - Connection loom - Connection loom - Connection loom

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (injectors), in engine assembly wiring (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

Edition 07.03 S00.5324.00.20

FABIA

No.48/5

Current Flow Diagram

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4i T4k

-

T11b T14a -

T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender 4-pin connector, close to lambda probe Connector, 4-pin, close to lambda probe downstream of catalytic converter 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 07.03 S00.5324.00.20

D103

E28

*

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection -3- (87a), in engine compartment wiring loom - Connection (lambda probe heater), in engine compartment wiring loom - not valid for EU-2 DDK

No.48/6

Current Flow Diagram

FABIA

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.48/7

Current Flow Diagram

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G163 J361 T2e T3j T6n T11b T14a

-

Knock sensor I Camshaft position sender Simos control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom

No.48/8

Current Flow Diagram

FABIA

Simos control unit, throttle valve control unit, Simos power supply relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit J363 - Simos power supply relay T6r - 6-pin connector, at left of bulkhead (brown) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T11c - 11-pin connector, at left of bulkhead (blue) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

354

- Earth connection -2-, in wiring loom behind dash panel A74 - Positive connection (15a), in wiring loom behind dash panel D106 - Connection -4- (87a), in wiring loom on left of engine compartment

Edition 07.03 S00.5324.00.20

FABIA

No.48/9

Current Flow Diagram

Simos control unit, Oil level/oil temperature sender, Ignition system

ws sw ro br gn bl gr li ge or

G266 J361 N70 N127 N291 Q T3f T4a T4b T4c T14a

-

Oil level/oil temperature sender Simos control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Spark plugs Connector, 3-pin, at oil level/oil temperature sender Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

19

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom 283 - Earth connection -2-, in engine pre-assembly wiring loom 304 - Earth connection (ignition coils), in engine preassembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness F36 - Connection (87a), in engine preassembly wiring loom

*

- applies only to models with extended service interval (ESI)

No.48/10

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A32 A98 A99 A139

D52

*

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom - applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.48/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.49/1

1.4 l - Simos 3 PB/44 kW, engine code AZE, from November 2002 1.4 l - Simos 3 PB/50 kW, engine code AME, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 4

Edition 07.03 S00.5324.00.20

- Fuel pump relay

No.49/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.49/3

Current Flow Diagram

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 N33 T2a T2b T2c T2d T2x T2y T14a

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at engine speed sender 2-pin connector, at coolant temperature sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D140

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (injectors), in engine assembly wiring loom

No.49/4

Current Flow Diagram

FABIA

Simos control unit, lambda probe, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 - Lambda probe G71 - Intake manifold pressure sender G72 - Intake manifold temperature sender J361 - Simos control unit N80 - Activated charcoal filter system solenoid valve T2z - 2-pin connector, at activated charcoal filter system solenoid valve T4g - 4-pin connector, at intake manifold pressure and intake manifold temperature sender T4i - 4-pin connector, close to lambda probe T11a - 11-pin connector, at left of bulkhead (white) T11b - 11-pin connector, at left of bulkhead (red) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit Z19 - Lambda probe heater

A130

- Connection (CCS), in wiring loom behind dash panel on left

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.49/5

Current Flow Diagram

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.49/6

Current Flow Diagram

FABIA

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J361 T3j T3k T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Simos control unit 3-pin connector, at camshaft position sender 3-pin connector, at knock sensor I 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29 131 281 A76

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth connection -2-, in engine compartment wiring harness - Earth connection -1-, in engine pre-assembly wiring loom - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.49/7

Current Flow Diagram

Simos control unit, throttle valve control unit, ignition system

ws sw ro br gn bl gr li ge or

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit N152 - Ignition transformer (ignition terminal strip) Q - Spark plugs T4f - 4-pin connector, at ignition transformer (ignition terminal strip) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T14a - Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.49/8

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6n T6r T11b

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red)

A2 A15 A32 A98 A99 A139

D52

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.49/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel ♦

- not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.50/1

1.4 l - Simos 3 PA/44 kW, engine code AZF, from November 2002 1.4 l - Simos 3 PA/50 kW, engine code AQW, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 4

Edition 07.03 S00.5324.00.20

- Fuel pump relay

No.50/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.50/3

Current Flow Diagram

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 N33 T2a T2b T2c T2d T2x T2y T14a

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at engine speed sender 2-pin connector, at coolant temperature sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D140

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (injectors), in engine assembly wiring loom

No.50/4

Current Flow Diagram

FABIA

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

A130

E28

- Connection (CCS), in wiring loom behind dash panel on left - Connection (lambda probe heater), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.50/5

Current Flow Diagram

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.50/6

Current Flow Diagram

FABIA

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J361 T3j T3k T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Simos control unit 3-pin connector, at camshaft position sender 3-pin connector, at knock sensor I 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29 131 281 A76

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth connection -2-, in engine compartment wiring harness - Earth connection -1-, in engine pre-assembly wiring loom - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 07.03 S00.5324.00.20

FABIA

No.50/7

Current Flow Diagram

Simos control unit, throttle valve control unit, ignition system

ws sw ro br gn bl gr li ge or

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit N152 - Ignition transformer (ignition terminal strip) Q - Spark plugs T4f - 4-pin connector, at ignition transformer (ignition terminal strip) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T14a - Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.50/8

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6n T6r T11b

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red)

A2 A15 A32 A98 A99 A139

D52

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.50/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel ♦

- not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

1.4 l - 4MV/55 kW, engine code BBY, from November 2002 1.4 l - 4MV/74 kW, engine code BBZ, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

4

- Fuel pump relay

9

- Fuel feed relay

No.51/1

No.51/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1 ♦

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery - Does not apply to models with automatic gearbox

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.51/3

Current Flow Diagram

4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas valve recirculation potentiometer

ws sw ro br gn bl gr li ge or

G28 G62 G212 J687 N18 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3m T6a T14a

-

Engine speed sender Coolant temperature sender Exhaust gas recirculation potentiometer 4MV control unit EGR valve Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender Connector, 6-pin, at EGR valve Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T40a - 40-pin connector, at engine control unit 220

- Earth connection (sender earth), in engine pre-wiring wiring harness D140 - Connection (injectors), in engine assembly wiring loom D141 - Connection (5V), in engine assembly wiring loom

No.51/4

Current Flow Diagram

FABIA

4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 G71 G72 G130 J687 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T14a

-

T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter 4MV control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

220

- Earth connection (sender earth), in engine pre-wiring wiring harness A130 - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom D141 - Connection (5V), in engine assembly wiring loom E28

- Connection (lambda probe heater), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.51/5

Current Flow Diagram

4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J687 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -24MV control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

*

- Does not apply to models with automatic gearbox

No.51/6

FABIA

Current Flow Diagram

4MV control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J217 J687 T2e T3j T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Automatic gearbox control unit 4MV control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 200 - Earth connection (screening), in engine pre-wiring wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom D166

- Connection (K diagnosis wire), in engine compartment wiring loom

*

- Applies only to models with automatic gearbox

Edition 07.03 S00.5324.00.20

FABIA

No.51/7

Current Flow Diagram

4MV control unit, throttle valve control unit

ws sw ro br gn bl gr li ge or

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J687 - 4MV control unit N79 - Crankcase breather heater element T2m - 2-pin connector, at crankcase breather heater element T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner

Edition 07.03 S00.5324.00.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.51/8

Current Flow Diagram

FABIA

4MV control unit, ignition system

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J687 N70 N127 N291 N292 Q T4a T4b T4c T4d T14a

white black red brown green blue grey purple yellow orange

-

4MV control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Ignition coil 4 with output stage Spark plugs Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 4-pin, at ignition coil 4 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

19

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom - Earth connection (ignition coils), in engine preassembly wiring loom - Connection -2- (15a), in engine pre-assembly wiring loom

304 D33

Edition 07.03 S00.5324.00.20

FABIA

No.51/9

Current Flow Diagram

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99 A139

D25 D52

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Connection (15a), in engine pre-assembly wiring loom - Positive connection (15a), in engine compartment wiring loom

No.51/10

Current Flow Diagram

FABIA

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.51/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

199

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel ♦

- not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.52/1

2.0 l - Motronic/85 kW, engine code AZL, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

1

- Secondary air pump relay

2

- Motronic power supply relay

4

- Fuel pump relay

9

- Fuel feed relay

No.52/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

■ ■ ■ - Does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.52/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

■ ■ ■ - Does not apply to models with air conditioning

No.52/4

Current Flow Diagram

FABIA

Motronic control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J220 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3m T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Motronic control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

220

- Earth connection (sender earth), in engine pre-wiring wiring harness D140 - Connection (injectors), in engine assembly wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.52/5

Current Flow Diagram

Motronic control unit, lambda probe, lambda probe downstream of catalytic converter, air mass meter and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G70 G72 G130 J220 N80 T2z

-

T4k

-

T5m

-

T6z T11b T14a -

T81a Z19 Z29 -

Lambda probe Air mass meter Intake manifold temperature sender Lambda probe downstream of catalytic converter Motronic control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve Connector, 4-pin, close to lambda probe downstream of catalytic converter Plug connection, 5-pin, at air mass meter and intake manifold temperature sender Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

D52

- Positive connection (15a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom E28 - Connection (lambda probe heater), in engine compartment wiring loom

*

- Applies only to models with optional equipment

No.52/6

Current Flow Diagram

FABIA

Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J220 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Motronic control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.52/7

Current Flow Diagram

Motronic control unit, knock sensor I, knock sensor II, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G66 G163 J220 T2e T2k T3j T6n T11b T40a T81a

-

Knock sensor I Knock sensor II Camshaft position sender Motronic control unit 2-pin connector, at knock sensor I 2-pin connector, at knock sensor II 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D145 - Connection (knock sensors), in engine pre-wiring wiring harness

No.52/8

Current Flow Diagram

FABIA

Motronic control unit, throttle valve control unit, secondary air pump motor

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J220 - Motronic control unit J338 - Throttle valve control unit T2g - 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) T2l - 2-pin connector, at secondary air pump motor T6t - 6-pin connector, at throttle valve control unit T6w - 6-pin connector, at left of bulkhead (grey) T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner V101 - Secondary air pump motor

131 A121 A122 A130 D159 D160

- Earth connection -2-, in engine compartment wiring harness - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CCS), in wiring loom behind dash panel on left - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

Edition 07.03 S00.5324.00.20

FABIA

No.52/9

Current Flow Diagram

Motronic control unit, ignition system, secondary air pump relay

ws sw ro br gn bl gr li ge or

J220 J271 J299 N79 N152 P Q T2m

-

T4f T6r T6w T11a T11c T14a

-

T40a T81a -

Motronic control unit Motronic power supply relay Secondary air pump relay Crankcase breather heater element Ignition transformer Spark plug connector Spark plugs 2-pin connector, at crankcase breather heater element 4-pin connector, at ignition transformer 6-pin connector, at left of bulkhead (brown) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

131

- Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom D173 - Connection (87), in engine assembly wiring loom

*

- Applies only to models with optional equipment

No.52/10

Current Flow Diagram

FABIA

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel

- Positive connection (15), in wiring loom behind dash panel A177 - Connection (87), in wiring loom behind dash panel A139

D52

- Positive connection (15a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.52/11

Current Flow Diagram

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

No.52/12

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G6 G21 G22 J285 K K3 K83 K105 K132 T1b T3l T4j T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel 281 - Earth connection -1-, in engine pre-assembly wiring loom A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.53/1

1.9 l - SDI/47 kW, engine code ASY, from November 2002

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

8

- Low heating capacity relay

b

- S277 - Fuse -2- for heating element

9

- High heating capacity relay

c

- S278 - Fuse -3- for heating element

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.53/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S176 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.53/3

Current Flow Diagram

Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve

ws sw ro br gn bl gr li ge or

J52 J248 N18 Q6 T2g

-

T2h T6w T11a T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit EGR valve Glow plugs 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 2-pin connector, at exhaust gas recirculation valve 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

D78

- Connection (87), in wiring loom behind dash panel

- Positive connection -1- (30a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom

No.53/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G72 G79 J248 SB2 T2i T4d T4h T6n T6u T11b T11c T81a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Intake manifold temperature sender Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 2-pin connector, at fuel gauge sender 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

328 A18

- Earth connection -2- (sender earth), in engine compartment wiring harness - Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.53/5

Current Flow Diagram

Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity adjuster

ws sw ro br gn bl gr li ge or

F268 G81 G149 J248 N108 N109 N146 SB14 T6n T10c T10e T11a T11b T11c T16c T40a T81a

-

Heater element contact switch (PTC) Fuel temperature sender Modulating piston movement sender Diesel direct injection system control unit Commencement of injection valve Fuel cut off valve Quantity (metering) adjuster Fuse, in fuse holder 6-pin connector, at left of bulkhead (blue) 10-pin connector, behind dash panel on right 10-pin connector, at injection pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 16-pin connector, at fresh air controls 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A130 - Connection (CCS), in wiring loom behind dash panel on left F25 - Connection -1-, in engine preassembly wiring loom F36

- Connection (87a), in engine preassembly wiring loom

- does not apply to models with air conditioning - Applies only to models with CCS = = = - Applies only to models with heating element (PTC)

*■ ■ ■

No.53/6

Current Flow Diagram

FABIA

Diesel direct injection system control unit, Engine speed sender, Coolant temperature sender, Needle lift sender, Intake manifold flap motor

ws sw ro br gn bl gr li ge or

G28 G62 G80 J248 T2j T2y T3m T4l T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Needle lift sender Diesel direct injection system control unit 2-pin connector, at needle lift sender 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold flap motor 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V157 - Intake manifold flap motor

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom F27 - Connection harness A121

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring (screening), in engine pre-wiring wiring

Edition 06.04 S00.5324.01.20

FABIA

No.53/7

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 07.03 S00.5324.00.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

No.53/8

Current Flow Diagram

FABIA

Diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J322 T3a T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.53/9

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G21 G22 J285 K K3 K29 K105 T1b T2f T3l T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 2-pin connector, at fuel gauge sender 3-pin connector, at speedometer sender 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

269

- Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel ♦

- not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.54/1

1.9 l - TDI with unit injection/74 kW, engine code ATD, from November 2002

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

4

- Fuel pump relay

b

- S277 - Fuse -2- for heating element

8

- Low heating capacity relay

c

- S278 - Fuse -3- for heating element

9

- High heating capacity relay

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.54/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

■ ■ ■ - Does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.54/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

■ ■ ■ - Does not apply to models with air conditioning

No.54/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, glow plug relay, glow plugs

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J52 J248 Q6 SB14 T2g

-

T6w T11a T11b T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit Glow plugs Fuse, in fuse holder 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

- Connection (87), in wiring loom behind dash panel

D78

- Positive connection -1- (30a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment

*

- Applies only to models with optional equipment

Edition 07.03 S00.5324.00.20

FABIA

No.54/5

Current Flow Diagram

Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G79 J248 SB2 T4d T4h T6n T6u T11b T11c T81a

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.54/6

FABIA

Current Flow Diagram

Diesel direct injection system control unit, coolant temperature sender, fuel temperature sender, exhaust gas recirculation valve, charge pressure control solenoid valve, intake manifold flap changeover valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F268 G62 G81 J248 N18 N75 N239 T2b T2y T6z T10c T11a T11c T14a

white black red brown green blue grey purple yellow orange

-

Heater element contact switch (PTC) Coolant temperature sender Fuel temperature sender Diesel direct injection system control unit EGR valve Boost pressure control solenoid valve Intake manifold flap changeover valve Plug connection, 2-pin, at fuel temperature sender 2-pin connector, at coolant temperature sender Connector, 6-pin, at valve block 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16c - 16-pin connector, at fresh air controls T40a - 40-pin connector, at engine control unit

T81a - 81-pin connector, at engine control unit - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom A130

- does not apply to models with air conditioning - Applies only to models with CCS = = = - Applies only to models with heating element (PTC)

*■ ■ ■

Edition 07.03 S00.5324.00.20

FABIA

No.54/7

Current Flow Diagram

Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender

ws sw ro br gn bl gr li ge or

G28 G40 G70 G71 G72 N79 J248 T2m

-

T3j T3m T4g

-

T5l T40a T81a -

Engine speed sender Camshaft position sender Air mass meter Intake manifold pressure sender Intake manifold temperature sender Crankcase breather heater element Diesel direct injection system control unit 2-pin connector, at crankcase breather heater element 3-pin connector, at camshaft position sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold pressure and intake manifold temperature sender 5-pin connector, at air mass meter 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D52 F27 F36

*

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15a), in engine compartment wiring loom - Connection (screening), in engine pre-wiring wiring harness - Positive connection (87a), in engine assembly wiring loom - Applies only to models with optional equipment

No.54/8

Current Flow Diagram

FABIA

Diesel direct injection system control unit, unit injectors

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J248 N240 N241 N242 N243 T2c

-

T2d T2e T2f T6n T8o T11a T11c T40a T81a

-

Diesel direct injection system control unit Unit injector, cylinder 1 Unit injector, cylinder 2 Unit injector, cylinder 3 Unit injector, cylinder 4 2-pin connector at unit injector valves, No. 1 cyl Plug connection, 2-pin, at unit injector, cylinder 2 Plug connection, 2-pin, at unit injector, cylinder 3 Plug connection, 2-pin, at unit injector, cylinder 4 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at cylinder head 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

A76 A121 A122 D159 D160

F26

- Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Connection (earth), in cylinder head wiring loom

= = = - Applies only to models with heating element (PTC)

Edition 07.03 S00.5324.00.20

FABIA

No.54/9

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 07.03 S00.5324.00.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

No.54/10

Current Flow Diagram

FABIA

Fuel pump relay, diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 J322 T3a T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.54/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K29 K105 T1b T3l T4j T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel ♦

- not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

Central locking Door warning lamps from November 2002 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.55/1

No.55/2

Current Flow Diagram

FABIA

Convenience electrics central control unit, tailgate handle release button, central locking switch, tailgate central locking motor, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E234 F5 S218 J393 T2y T2z

-

T4c T5c

-

T5e T6k T6o

-

T18b -

Tailgate handle release button Luggage compartment light switch Central locking switch, in tailgate lock Convenience electrics central control unit Connector, 2-pin, at tailgate handle release button 2-pin connector, at tailgate/boot lid central locking motor 4-pin connector, at boot/tailgate lock 5-pin connector, at electrical system control unit (brown) 5-pin connector, at left C pillar (black) 6-pin connector, at electrical system control unit (red) 6-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (black)

T23a - 23-pin connector, at convenience electrics central control unit V53 - Tailgate/boot lid central locking motor 61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

98

- Earth connection, in engine compartment wiring harness 135 - Earth connection, in wiring harness behind dash panel A57 - Positive connection (30a), in wiring loom behind dash panel A98 - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.55/3

Current Flow Diagram

Convenience system central control unit, Driver side central locking lock unit, Central locking warning lamp

ws sw ro br gn bl gr li ge or

F220 - Central locking lock unit, driver side (switch position released, door closed) J245 - Sliding roof adjustment control unit J393 - Convenience electrics central control unit K133 - Central locking warning lamp T2x - 2-pin connector, at central locking warning lamp T6e - 6-pin connector, at sliding roof adjustment control unit T6f - 6-pin connector, at left A pillar (brown) T6j - Connector, 6-pin, at left A pillar (white) T8f - 8-pin connector, at central locking locking unit, driver side T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T23a - 23-pin connector, at convenience electrics central control unit

Edition 07.03 S00.5324.00.20

81 205 A76

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness of door assembly wiring driver side - Connection (K diagnosis wire), in wiring loom behind dash panel on left

= = = - Applies only to models with electric sliding roof

No.55/4

Current Flow Diagram

FABIA

Convenience system central control unit, Front passenger side central locking lock unit

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F221 - Central locking lock unit, front passenger side (switch position - released, door closed) J393 - Convenience electrics central control unit T6g - 6-pin connector, at right A pillar (brown) T6k - Connector, 6-pin, at right A pillar (white) T8g - 8-pin connector, at central locking locking unit, passenger side T23a - 23-pin connector, at convenience electrics central control unit

206 354

- Earth connection, in door wiring loom - passenger side - Earth connection, in wiring harness behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.55/5

Current Flow Diagram

Convenience electrics central control unit, central locking locking unit - rear left, central locking locking unit - rear right

ws sw ro br gn bl gr li ge or

F222 - Central locking lock unit, rear left (switch position released, door closed) F223 - Central locking lock unit, rear right (switch position released, door closed) J393 - Convenience electrics central control unit T6c - 6-pin connector, at rear left central locking locking unit T6d - 6-pin connector, at rear right central locking locking unit T6h - 6-pin connector, at left B pillar (brown) T6i - 6-pin connector, at right B pillar (brown) T6l - 6-pin connector, at left B pillar (blue) T6m - 6-pin connector, at right B pillar (blue) T12c - Connector, 12-pin, at convenience electrics central control unit (black)

Edition 07.03 S00.5324.00.20

81 354

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel

No.55/6

Current Flow Diagram

FABIA

Front interior light, Left door warning light, Right door warning light

ws sw ro br gn bl gr li ge or

J317 M27 M28 SB4 T2v T2w T3c T5a T6f T6g T6j T18a W W13 W19

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Terminal 30 voltage supply relay Left door warning light Right door warning light Fuse, in fuse holder Connector, 2-pin, at right door warning light Connector, 2-pin, at left door warning light 3-pin connector, at front interior light bulb 5-pin connector, at electrical system control unit (black) 6-pin connector, at left A pillar (brown) 6-pin connector, at right A pillar (brown) 6-pin connector, at electrical system control unit (brown) 18-pin connector, at electrical system control unit (brown) - Interior light, front - Front passenger’s reading light - Driver-side reading light

354 A23 A29

- Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

■ ■ ■ - Applies only to models with door warning lights

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Fog light, from November 2002

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 07.03 S00.5324.00.20

-

green white yellow blue red brown beige

No.56/1

No.56/2

Current Flow Diagram

FABIA

Fog lights

ws sw ro br gn bl gr li ge or

E23 K17 L22 L23 T2b T2c T6p T17a T32a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Front and rear fog light switch Fog light warning lamp Front left fog light bulb Front right fog light bulb 2-pin connector, at left fog light 2-pin connector, at right fog light 6-pin connector, at left of bulkhead (red) 17-pin connector, at light switch 32-pin connector, at dash panel insert

12a 13

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth point, in front right of engine compartment

124

- Earth connection, in engine compartment wiring harness B205 - Connection (fog lights), in wiring loom behind dash panel D59 - Connection (fog lights), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

Rear reading lights, from November 2002

Edition 07.03 S00.5324.00.20

No.57/1

No.57/2

Current Flow Diagram

FABIA

Rear reading lights (does not apply to Notchback models)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J317 M27 M28 SB4 T3c T3y T3z T5a

-

T5b T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Left door warning light Right door warning light Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 5-pin connector, at left C pillar (brown) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

98

- Earth connection, in engine compartment wiring harness 354 - Earth connection, in wiring harness behind dash panel A23 - Positive connection (30al), in wiring loom behind dash panel A29 - Connection (interior light 31), in wiring loom behind dash panel Q150 - Connection (30al), in boot lid/tailgate wiring loom Q151

- Connection (interior light 31), in boot lid/tailgate wiring loom

■ ■ ■ - Applies only to models with door warning lights

Edition 07.03 S00.5324.00.20

FABIA

No.57/3

Current Flow Diagram

Rear reading lights (applies only to Notchback models)

ws sw ro br gn bl gr li ge or

J317 M27 M28 SB4 T3c T3y T3z T5a

-

T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Left door warning light Right door warning light Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in rear interior wiring loom

354

- Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

A23 A29

■ ■ ■ - Applies only to models with door warning lights

FABIA

Current Flow Diagram

No.58/1

1.2 l - Simos 3 PE/47 kW, engine code AZQ, from February 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 07.03 S00.5324.00.20

4

- Fuel pump relay

9

- Fuel feed relay

12

- Simos power supply relay

No.58/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery, radiator fan (models not fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S177 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan dependent on optional

equipment (does not apply to models fitted with air conditioning or fitted with trailer coupling) = = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

Edition 07.03 S00.5324.00.20

FABIA

No.58/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan (models fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

= = = - does not apply to models fitted with air conditioning or not fitted with trailer coupling

No.58/4

Current Flow Diagram

FABIA

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 T2a T2b T2c T2y T3m T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

220 A121 A122 D140 D159 D160

- Earth connection (sender earth), in engine pre-wiring wiring harness - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (injectors), in engine assembly wiring loom - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.58/5

Current Flow Diagram

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

220

- Earth connection (sender earth), in engine pre-wiring wiring harness A130 - Connection (CCS), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom E28

- Connection (lambda probe heater), in engine compartment wiring loom

■ ■ ■ - Applies only to models with CCS

No.58/6

Current Flow Diagram

FABIA

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 07.03 S00.5324.00.20

FABIA

No.58/7

Current Flow Diagram

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

D G61 G163 J361 T3j T3k T6n T8a T11b T14a

-

Ignition/starter switch Knock sensor I Camshaft position sender Simos control unit 3-pin connector, at camshaft position sender 3-pin connector, at knock sensor I 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A41 - Positive connection (50), in wiring loom behind dash panel A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom

No.58/8

Current Flow Diagram

FABIA

Simos control unit, throttle valve control unit, Simos power supply relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit J363 - Simos power supply relay SB14 - Fuse, in fuse holder T6r - 6-pin connector, at left of bulkhead (brown) T6t - 6-pin connector, at throttle valve control unit T11c - 11-pin connector, at left of bulkhead (blue) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

354 A56 A74

- Earth connection -2-, in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel

Edition 07.03 S00.5324.00.20

FABIA

No.58/9

Current Flow Diagram

Simos control unit, exhaust gas recirculation valve, exhaust gas recirculation potentiometer, oil level/oil temperature sender, ignition system

ws sw ro br gn bl gr li ge or

G212 G266 J361 N18 N70 N127 N291 Q T3f T4a T4b T4c T6a T14a

-

Exhaust gas recirculation potentiometer Oil level/oil temperature sender Simos control unit EGR valve Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Spark plugs Connector, 3-pin, at oil level/oil temperature sender Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 6-pin, at EGR valve Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

19

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom 304 - Earth connection (ignition coils), in engine preassembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness D141 - Connection (5V), in engine assembly wiring loom F36

*

- Connection (87a), in engine preassembly wiring loom - applies only to models with extended service interval (ESI)

No.58/10

Current Flow Diagram

FABIA

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11a T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

A99

- Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel

A101

- Connection (87), in wiring loom behind dash panel

A98

- Positive connection (15), in wiring loom behind dash panel D52 - Positive connection (15a), in engine compartment wiring loom D106 - Connection -4- (87a), in wiring loom on left of engine compartment A139

*

- applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.58/11

Current Flow Diagram

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

No.58/12

FABIA

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.59/1

1.4 l - TDI with unit injection system/55 kW, engine code AMF, from May 2003

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

4

- Fuel pump relay

b

- S277 - Fuse -2- for heating element

8

- Low heating capacity relay

c

- S278 - Fuse -3- for heating element

9

- High heating capacity relay

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.59/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S176 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

■ ■ ■ - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 07.03 S00.5324.00.20

FABIA

No.59/3

Current Flow Diagram

Diesel direct injection system control unit, glow plug relay, glow plugs

ws sw ro br gn bl gr li ge or

J52 J248 Q6 SB14 T2g

-

T6w T11a T11b T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit Glow plugs Fuse, in fuse holder 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

white black red brown green blue grey purple yellow orange

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

- Connection (87), in wiring loom behind dash panel

D78

- Positive connection -1- (30a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D173 - Connection (87), in engine assembly wiring loom

*

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

- applies only to models with extended service interval (ESI)

No.59/4

Current Flow Diagram

FABIA

Control unit for Diesel direct injection system, Accelerator pedal position sender, Brake pedal switch, Clutch pedal switch, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F8 F36 F47 F60 G79 G266 J248 SB2 T3f T4d T4h T6n T6u T11c T14a

white black red brown green blue grey purple yellow orange

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Accelerator position sender Oil level/oil temperature sender Diesel direct injection system control unit Fuse, in fuse holder Connector, 3-pin, at oil level/oil temperature sender 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T81a - 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness

*

- applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.59/5

Current Flow Diagram

Diesel direct injection system control unit, coolant temperature sender, fuel temperature sender, exhaust gas recirculation valve, charge pressure control solenoid valve, intake manifold flap changeover valve

ws sw ro br gn bl gr li ge or

F268 G62 G81 J248 N18 N75 N239 T2b T2y T6z T10c T11a T11b T11c T14a

-

Heater element contact switch (PTC) Coolant temperature sender Fuel temperature sender Diesel direct injection system control unit EGR valve Boost pressure control solenoid valve Intake manifold flap changeover valve Plug connection, 2-pin, at fuel temperature sender 2-pin connector, at coolant temperature sender Connector, 6-pin, at valve block 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16c - 16-pin connector, at fresh air controls

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom A130

■■■ === -

*♦

does not apply to models with air conditioning Applies only to models with optional equipment Applies only to models with CCS Applies only to models with heating element (PTC)

No.59/6

Current Flow Diagram

FABIA

Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G28 G40 G70 G71 G72 N79 J248 T2m

-

T3j T3m T4g

-

T5l T40a T81a -

Engine speed sender Camshaft position sender Air mass meter Intake manifold pressure sender Intake manifold temperature sender Crankcase breather heater element Diesel direct injection system control unit 2-pin connector, at crankcase breather heater element 3-pin connector, at camshaft position sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold pressure and intake manifold temperature sender 5-pin connector, at air mass meter 40-pin connector, at engine control unit 81-pin connector, at engine control unit

85 131 D52 F27

- Earth connection -1-, in wiring loom in left of engine compartment - Earth connection -2-, in engine compartment wiring harness - Positive connection (15a), in engine compartment wiring loom - Connection (screening), in engine pre-wiring wiring harness

♦

- Applies only to models with optional equipment

===

- valid as of 08.03

n n n - valid up to 07.03

Edition 06.04 S00.5324.01.20

FABIA

No.59/7

Current Flow Diagram

Diesel direct injection system control unit, unit injectors

ws sw ro br gn bl gr li ge or

J248 N240 N241 N242 T2c

-

T2d T2e T6n T8o T11a T11c T40a T81a

-

Diesel direct injection system control unit Unit injector, cylinder 1 Unit injector, cylinder 2 Unit injector, cylinder 3 2-pin connector at unit injector valves, No. 1 cyl Plug connection, 2-pin, at unit injector, cylinder 2 Plug connection, 2-pin, at unit injector, cylinder 3 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at cylinder head 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

A76 A121 A122 D159 D160

F26

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Connection (earth), in cylinder head wiring loom

= = = - Applies only to models with heating element (PTC)

No.59/8

Current Flow Diagram

FABIA

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J359 J360 S276 S277 S278 T3n TV2 Z35

white black red brown green blue grey purple yellow orange

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

606

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

Edition 07.03 S00.5324.00.20

FABIA

No.59/9

Current Flow Diagram

Fuel pump relay, diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 J322 T3a T6r T11b

-

Fuel pump relay Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red)

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

*

Edition 07.03 S00.5324.00.20

- applies only to models with extended service interval (ESI)

No.59/10

FABIA

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G6 G21 G22 J285 K K3 K29 K38 K83 K105 T1b T3l T4j T6v T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

Edition 07.03 S00.5324.00.20

FABIA

Current Flow Diagram

No.60/1

1.9 l - TDI with unit injection/96 kW, engine code ASZ, from June 2003

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

4

- Fuel pump relay

b

- S277 - Fuse -2- for heating element

8

- Low heating capacity relay

c

- S278 - Fuse -3- for heating element

9

- High heating capacity relay

15

- Diesel direct injection system relay

Edition 07.03 S00.5324.00.20

No.60/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

■ ■ ■ - Does not apply to models with air conditioning

Edition 07.03 S00.5324.00.20

FABIA

No.60/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 07.03 S00.5324.00.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

■ ■ ■ - Does not apply to models with air conditioning

No.60/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, glow plug relay, glow plugs

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J52 J248 Q6 SB14 T2g

-

T6w T11a T11b T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit Glow plugs Fuse, in fuse holder 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

- Connection (87), in wiring loom behind dash panel

D78

- Positive connection -1- (30a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment

* ♦

- applies only to models with extended service interval (ESI) - Applies only to models with optional equipment

Edition 07.03 S00.5324.00.20

FABIA

No.60/5

Current Flow Diagram

Diesel direct injection system control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G79 J248 SB2 T4d T4h T6n T6u T11b T11c T81a

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

No.60/6

FABIA

Current Flow Diagram

Diesel direct injection system control unit, coolant temperature sender, fuel temperature sender, exhaust gas recirculation valve, charge pressure control solenoid valve, intake manifold flap changeover valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F268 G62 G81 J248 N18 N75 N239 T2b T2y T6z T10c T11a T11c T14a

white black red brown green blue grey purple yellow orange

-

Heater element contact switch (PTC) Coolant temperature sender Fuel temperature sender Diesel direct injection system control unit EGR valve Boost pressure control solenoid valve Intake manifold flap changeover valve Plug connection, 2-pin, at fuel temperature sender 2-pin connector, at coolant temperature sender Connector, 6-pin, at valve block 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16c - 16-pin connector, at fresh air controls T40a - 40-pin connector, at engine control unit

T81a - 81-pin connector, at engine control unit - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom A130

- does not apply to models with air conditioning - Applies only to models with CCS = = = - Applies only to models with heating element (PTC)

*■ ■ ■

Edition 07.03 S00.5324.00.20

FABIA

No.60/7

Current Flow Diagram

Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender

ws sw ro br gn bl gr li ge or

G28 G40 G70 G71 G72 N79 J248 T2m

-

T3j T3m T4g

-

T5l T40a T81a -

Engine speed sender Camshaft position sender Air mass meter Intake manifold pressure sender Intake manifold temperature sender Crankcase breather heater element Diesel direct injection system control unit 2-pin connector, at crankcase breather heater element 3-pin connector, at camshaft position sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold pressure and intake manifold temperature sender 5-pin connector, at air mass meter 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 07.03 S00.5324.00.20

D52 F27 F36

♦

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15a), in engine compartment wiring loom - Connection (screening), in engine pre-wiring wiring harness - Positive connection (87a), in engine assembly wiring loom - Applies only to models with optional equipment

No.60/8

FABIA

Current Flow Diagram

Control unit for Diesel direct injection system, Unit injector valves, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G266 J248 N240 N241 N242 N243 T2c

-

T2d T2e T2f T3f T6n T8o T11a T14a

-

Oil level/oil temperature sender Diesel direct injection system control unit Unit injector, cylinder 1 Unit injector, cylinder 2 Unit injector, cylinder 3 Unit injector, cylinder 4 2-pin connector at unit injector valves, No. 1 cyl Plug connection, 2-pin, at unit injector, cylinder 2 Plug connection, 2-pin, at unit injector, cylinder 3 Plug connection, 2-pin, at unit injector, cylinder 4 Connector, 3-pin, at oil level/oil temperature sender 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at cylinder head 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit A76 A121 A122 D107 D159 D160

F26

*

- Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Connection (earth), in cylinder head wiring loom - applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.60/9

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 07.03 S00.5324.00.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

No.60/10

Current Flow Diagram

FABIA

Fuel pump relay, diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 J322 T3a T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A33 - Positive connection (75), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

*

- applies only to models with extended service interval (ESI)

Edition 07.03 S00.5324.00.20

FABIA

No.60/11

Current Flow Diagram

Dash panel insert, Control unit in dash panel insert, Warning lamps, Oil pressure switch, Fuel gauge sender, Fuel pump, Fuel gauge, Speedometer, Odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 J285 K K3 K29 K38 K83 K105 T1b T4j T6v T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display

Edition 07.03 S00.5324.00.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

*

- applies only to models with extended service interval (ESI)

FABIA

Current Flow Diagram

Base equipment - FABIA, from August 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment 11

Edition 06.04 S00.5324.01.20

- X contact relief relay

No.61/1

No.61/2

Current Flow Diagram

FABIA

Battery, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B J359 J360 S163 T3a T12a T18a TV2

white black red brown green blue grey purple yellow orange

Battery Starter Low heating capacity relay High heating capacity relay Fuse -2- (30), in fuse holder on battery 3-pin connector, at left of bulkhead (grey) 12-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Terminal 30 junction, behind dash panel on left

11

-

12 14 A1 A32 A56 A57 A98 P1

*

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) - Earth point, in left of engine compartment, below battery (at side member) - Earth point, on gearbox - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Positive connection (30), in fuse holder on battery - Applies only to models with heating element (PTC)

Edition 06.04 S00.5324.01.20

FABIA

No.61/3

Current Flow Diagram

Ignition/starter switch, fuse holder

ws sw ro br gn bl gr li ge or

B D J361 T8a T11b T18a

-

Starter Ignition/starter switch Simos control unit 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (red) 18-pin connector, at electrical system control unit (brown)

A1

- Positive panel A2 - Positive panel A15 - Positive panel A21 - Positive panel A41 - Positive panel A56 - Positive panel A139 - Positive panel

*♦

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

connection (30a), in wiring loom behind dash connection (15), in wiring loom behind dash connection (15), in wiring loom behind dash connection (86s), in wiring loom behind dash connection (50), in wiring loom behind dash connection (30a), in wiring loom behind dash connection (15), in wiring loom behind dash

- applies only to engine codes AZQ - Does not apply to models with daytime running lights

No.61/4

Current Flow Diagram

FABIA

Relief relay for X contact, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J59 S268 T5a T6j T12a T18a 80 81

white black red brown green blue grey purple yellow orange

-

Relief relay for X-contact Fuse -10- (30), in fuse holder on battery 5-pin connector, at electrical system control unit (black) 6-pin connector, at electrical system control unit (brown) 12-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel

135 199 332 335 354 357 606 A33 A34 P1

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Positive connection (30), in fuse holder on battery

Edition 06.04 S00.5324.01.20

FABIA

No.61/5

Current Flow Diagram

Light switch

ws sw ro br gn bl gr li ge or

E1 E23 L9 T6c

-

Light switch Front and rear fog light switch Lighting switch illumination bulb 6-pin connector, at electrical system control unit (black) T17a - 17-pin connector, at light switch

81

white black red brown green blue grey purple yellow orange

A43

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Positive connection (75), in wiring loom behind dash panel - Positive connection (75x), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A56

- Positive connection (30a), in wiring loom behind dash panel

A11 A33 A34

♦

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

- Does not apply to models with daytime running lights

No.61/6

Current Flow Diagram

FABIA

Low beam and headlight flasher switch, headlights, fuse holder, (does not apply to models with gas discharge lights)

ws sw ro br gn bl gr li ge or

E4 M1 M3 M5 M7 M29 M30 M31 M32 T10a T10b T11a T12a T12b 29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Headlight dipper/flasher switch Side light bulb, left Side light bulb, right Turn signal bulb, front left Turn signal bulb, front right Headlight dipped beam bulb, left Headlight main beam bulb, left Headlight dipped beam bulb, right Headlight main beam bulb, right 10-pin connector, at left headlight 10-pin connector, at right headlight 11-pin connector, at left of bulkhead (white) 12-pin connector, at left of bulkhead (white) 12-pin connector, at headlight dipper/flasher switch

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting)

85 A9

- Earth connection -1-, in wiring loom in left of engine compartment - Connection (56b), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

A95

- Connection (56a), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

- Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom D152

*♦

- Does not apply to models with bulb failure indicator - Does not apply to models with daytime running lights

Edition 06.04 S00.5324.01.20

FABIA

No.61/7

Current Flow Diagram

Turn signal light switch, parking light switch, hazard warning light pushbutton, side turn signal light

ws sw ro br gn bl gr li ge or

E2 E19 E229 K6 L76 M18 M19 T2b T2c T6c

-

T6e T11a T12b T16a

-

Turn signal switch Parking light switch Button for hazard warning lights Hazard warning light system warning lamp Switch/button illumination Side turn signal bulb, left Side turn signal bulb, right 2-pin connector, at left side turn signal light 2-pin connector, at right side turn signal light 6-pin connector, at electrical system control unit (black) 6-pin connector, at hazard warning light pushbutton 11-pin connector, at left of bulkhead (white) 12-pin connector, at turn signal light switch 16-pin connector, at electrical system control unit (black)

white black red brown green blue grey purple yellow orange

81

- Earth connection, in wiring harness behind dash panel

85

A43

- Earth connection -1-, in wiring loom in left of engine compartment - Earth connection, in wiring harness behind dash panel - Positive connection (right turn signal light), in wiring loom behind dash panel - Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

D57

- Connection (right turn signal light), in right engine compartment wiring loom - Connection (left turn signal light), in left engine compartment wiring loom

332 A5 A6

D58

♦

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

- Does not apply to models with daytime running lights

No.61/8

Current Flow Diagram

FABIA

Lighting rheostat - switches and instruments, headlight range control adjuster, headlight range control, headlight range control adjuster, fuse holder (does not apply to models fitted with gas discharge bulbs)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E20 E102 L54 T6d

-

T10a T10b T12a V48 V49

-

Switches and instruments lighting control Headlight range control adjuster Headlight range control regulator illumination 6-pin connector, at lighting control and headlight range control adjuster 10-pin connector, at left headlight 10-pin connector, at right headlight 12-pin connector, at left of bulkhead (white) Headlight range control motor, left Headlight range control motor, right

81 85 A3 A4 A9

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in wiring loom in left of engine compartment - Positive connection (58), in wiring loom behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (56b), in wiring loom behind dash panel

A11

- Positive connection (58b), in wiring loom behind dash panel D96 - Connection (headlight range control), in engine compartment wiring loom D152 - Positive connection (56bL), in left engine compartment wiring loom D153 - Positive connection (56bR), in right engine compartment wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.61/9

Current Flow Diagram

Brake light switch, left tail light, fuse holder

ws sw ro br gn bl gr li ge or

F F47 J... M6 M9 M16 M41 T4d T6l U10

-

Brake light switch Brake pedal switch Engine control units Turn signal bulb, rear left Brake light bulb, left Reversing light bulb left Left tail light and rear fog light bulb 4-pin connector, at brake pedal switch 6-pin connector, at left tail light Trailer socket

white black red brown green blue grey purple yellow orange

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

A6 A18

- Positive connection (left turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A84

- Connection (58L), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

* ** ♦

-

===

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to models with trailer coupling applies only to models with trailer coupling

No.61/10

FABIA

Current Flow Diagram

Right tail light, centre high-mounted brake light, licence plate light

ws sw ro br gn bl gr li ge or

M8 M10 M17 M25 M42 T2i T2j T2k T5d T6m T6o X

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Turn signal bulb, rear right Brake light bulb, right Reversing light bulb right Centre high-mounted brake light bulb Right tail light and rear fog light bulb 2-pin connector, at centre high-mounted brake light 2-pin connector, at licence plate light (left) 2-pin connector, at licence plate light (right) 5-pin connector, at left C pillar (pink) 6-pin connector, at right tail light 6-pin connector, at electrical system control unit (black) - Number plate light

61

- Earth point, C-pillar left

86

- Earth connection -1-, in rear interior wiring loom

98

A18

- Earth connection, in engine compartment wiring harness - Positive connection (right turn signal light), in wiring loom behind dash panel - Connection (54), in wiring loom behind dash panel

A85

- Connection (58R), in wiring loom behind dash panel

B182

- Connection (RF), in interior wiring loom

W11

- Connection (58), in tailgate wiring loom

A5

* ** ♦

===

-

Does not apply to models with bulb failure indicator Does not apply to models with automatic gearbox does not apply to Saloon models applies only to Saloon models

Edition 06.04 S00.5324.01.20

FABIA

No.61/11

Current Flow Diagram

Glove box light, luggage compartment light

ws sw ro br gn bl gr li ge or

F5 S218 T2e T2f T2g T2o T4c T5e T6k W3 W6 W18 W35

-

Luggage compartment light switch Central locking switch, in tailgate lock 2-pin connector, at glove box light 2-pin connector, at left luggage compartment light 2-pin connector, at right luggage compartment light Connector, 2-pin, at luggage compartment light 4-pin connector, at boot/tailgate lock 5-pin connector, at left C pillar (black) 6-pin connector, at electrical system control unit (red) Luggage compartment light Glove box light Luggage compartment light, left Luggage compartment light, right

Edition 06.04 S00.5324.01.20

98 335 A23 Q22 W15

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in engine compartment wiring harness - Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection -1-, in tailgate wiring loom - Connection -1- (luggage compartment light), in rear wiring loom

- Applies to tailgate models only with central locking - Applies only to Estate - applies only to Combi models with optional equipment n n n - Applies only to models with optional equipment = = = - applies only to Saloon models

* ** ♦

No.61/12

Current Flow Diagram

FABIA

Windshield wiper and rear window wiper switch, windshield wiper motor (does not apply to Notchback models)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E22 E34 E38 T4a T5a

-

T5c

-

T6a

-

T6v T8b

-

T12a T16a T18a V

-

Intermittent wiper switch Rear wiper switch Intermittent wiper control 4-pin connector, at windscreen wiper motor 5-pin connector, at electrical system control unit (black) 5-pin connector, at electrical system control unit (brown) 6-pin connector, at windscreen wiper intermittent switch 6-pin connector, at left of bulkhead (green) 8-pin connector, at windscreen wiper intermittent switch 12-pin connector, at left of bulkhead (white) 16-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (brown) Windscreen wiper motor

80

- Earth connection, in wiring harness behind dash panel 81 - Earth connection, in wiring harness behind dash panel A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

Edition 06.04 S00.5324.01.20

FABIA

No.61/13

Current Flow Diagram

Windshield wiper and rear window wiper switch, windshield wiper motor (applies only to Notchback models)

ws sw ro br gn bl gr li ge or

E22 E38 T4a T5a

-

T5c

-

T6a

-

T6v T8b

-

T12a T16a T18a V

-

Intermittent wiper switch Intermittent wiper control 4-pin connector, at windscreen wiper motor 5-pin connector, at electrical system control unit (black) 5-pin connector, at electrical system control unit (brown) 6-pin connector, at windscreen wiper intermittent switch 6-pin connector, at left of bulkhead (green) 8-pin connector, at windscreen wiper intermittent switch 12-pin connector, at left of bulkhead (white) 16-pin connector, at electrical system control unit (black) 18-pin connector, at electrical system control unit (brown) Windscreen wiper motor

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

80

- Earth connection, in wiring harness behind dash panel 81 - Earth connection, in wiring harness behind dash panel A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

No.61/14

FABIA

Current Flow Diagram

Rear window wiper motor, windscreen and rear window washer pump

ws sw ro br gn bl gr li ge or

T2a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- 2-pin connector, on windscreen and rear window washer pump T4b - 4-pin connector, at rear window wiper motor T5b - 5-pin connector, at left C pillar (brown) T12a - 12-pin connector, at left of bulkhead (white) V5 - Windscreen washer pump V12 - Rear window wiper motor V59 - Windscreen and rear window washer pump

98

- Earth connection, in engine compartment wiring harness A102 - Connection (wiper), in wiring loom behind dash panel A156

- Connection (53c), in wiring loom behind dash panel

- applies only to Saloon models - does not apply to Saloon models n n n - does not apply to Notchback models

*♦

Edition 06.04 S00.5324.01.20

FABIA

No.61/15

Current Flow Diagram

Heated rear window pushbutton, heated rear window

ws sw ro br gn bl gr li ge or

E230 K10 L76 T5c

-

T5d T6b T6c

-

Z1

-

Button for heated rear window Heated rear window warning lamp Switch/button illumination 5-pin connector, at electrical system control unit (brown) 5-pin connector, at left C pillar (pink) 6-pin connector, at heated rear window button 6-pin connector, at electrical system control unit (black) Heated rear window

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

62

- Earth point, at right C pillar

98

- Earth connection, in engine compartment wiring harness - Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel

332 A11

*= = =

- does not apply to Saloon models - applies only to Saloon models

No.61/16

Current Flow Diagram

FABIA

Heating

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E9 E159 F268 J248 J251 K114 L16 N24 T2u T4e T5h T6s

-

T10c T11c T16c V2 V154

-

Fresh air blower switch Fresh and recirculated air flap switch Heater element contact switch (PTC) Diesel direct injection system control unit Fresh/recirculating air flap control unit Fresh air and air recirculation operation warning lamp Fresh air control lighting Series resistor with overheating fuse 2-pin connector, at fresh air blower 4-pin connector, at fresh air blower series resistor 5-pin connector, at fresh air blower switch 6-pin connector, at fresh/recirculated air flap positioning motor 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (blue) 16-pin connector, at fresh air controls Fresh air blower Fresh and recirculated air flap motor

606

- Earth point, under the centre console, near gear stick

A11

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (75al), in fresh air blower wiring loom

L13

*♦

- Applies only to models with heating element (PTC) - does not apply to models with air conditioning

Edition 06.04 S00.5324.01.20

FABIA

No.61/17

Current Flow Diagram

Front interior light, door contact switch (does not apply to models with central locking)

ws sw ro br gn bl gr li ge or

F2 F3 J317 T3c T3d T3e T5a T6f T6g T6j T18a W W13 W19

-

Driver’s door contact switch Door contact switch, rear right Voltage supply relay terminal (30) 3-pin connector, at front interior light bulb 3-pin connector, at left front door contact switch 3-pin connector, at right front door contact switch 5-pin connector, at electrical system control unit (black) 6-pin connector, at left A pillar (brown) 6-pin connector, at right A pillar (brown) 6-pin connector, at electrical system control unit (brown) 18-pin connector, at electrical system control unit (brown) - Interior light, front - Front passenger’s reading light - Driver-side reading light

81 205 206 354 A23 A29

*♦ ♦♦ ===

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Earth connection, in wiring harness of door assembly wiring driver side - Earth connection, in door wiring loom - passenger side - Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel - not valid for vehicles Junior - Applies only to models with heated and adjustable exterior mirrors (without power windows) - Applies only to models without optional equipment - Applies only to models with optional equipment

No.61/18

FABIA

Current Flow Diagram

Horn

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

F138 F231 H H1 H2 H7 T2l T2m T2n T5c

-

T5f

-

T5g T6p T12b T18a

-

Airbag coil connector Horn operation slip contact Horn plate Horn High tone horn Low tone horn 2-pin connector, at horn 2-pin connector, at low tone horn 2-pin connector, at high tone horn 5-pin connector, at electrical system control unit (brown) 5-pin connector, at airbag coil connector in steering wheel 5-pin connector, in steering wheel 6-pin connector, at left of bulkhead (red) 12-pin connector, at manual dipper switch 18-pin connector, at electrical system control unit (brown)

12a

- Earth point -2-, in engine compartment, on left below battery (at side member) 124 - Earth connection, in engine compartment wiring harness 335 - Earth connection, in wiring harness behind dash panel D143 - Connection (71), in left engine compartment wiring loom nnn -

* ** ♦

Applies Applies Applies Applies

only only only only

to models without optional equipment to models with airbag to models without airbag to models with optional equipment

Edition 06.04 S00.5324.01.20

FABIA

No.61/19

Current Flow Diagram

Socket, cigarette lighter, ashtray illumination, glove box light, fuse holder

ws sw ro br gn bl gr li ge or

J301 L15 L42 T2d T3b U U1

-

AC control unit Earth point, at cylinder head Electric socket illumination bulb 2-pin connector, at bulb for ashtray illumination 3-pin connector, at socket Socket Cigarette lighter

white black red brown green blue grey purple yellow orange

80

- Earth connection, in wiring harness behind dash panel 354 - Earth connection, in wiring harness behind dash panel A4 - Positive connection (58b), in wiring loom behind dash panel A68 - Positive connection (30a, AC), in wiring loom behind dash panel A164 - Positive connection (30a), in wiring loom behind dash panel

* ** ♦

♦♦ #

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

-

does not apply to models with air conditioning not valid for vehicles Junior Applies only to models with air conditioning not valid for vehicles Junior und Classic Applies only to models with ESP

No.61/20

Current Flow Diagram

FABIA

Reversing lights switch, luggage compartment socket, fuse holder

ws sw ro br gn bl gr li ge or

F4 J248 J361 T2h T3w

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Reversing light switch Diesel direct injection system control unit Simos control unit 2-pin connector, at reversing light switch Plug connection, 3-pin, at 12 V socket, in luggage compartment T6n - 6-pin connector, at left of bulkhead (blue) T11b - 11-pin connector, at left of bulkhead (red) U5 - 12 V socket, in luggage compartment

86 A34 A70 A98

- Earth connection -1-, in rear interior wiring loom - Positive connection (75x), in wiring loom behind dash panel - Positive connection (15a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system)

♦♦ === nnn -

* ** ♦

Applies only to engine codes AMF, ASY, ATD, ASZ Does not apply to models with automatic gearbox does not apply to models with air conditioning applies only to engine codes AZQ applies only to Combi and Notchback models does not apply to Notchback models

Edition 06.04 S00.5324.01.20

FABIA

No.61/21

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, digital clock

ws sw ro br gn bl gr li ge or

J285 K K1 K13 K17 K60 K193 L10 T6r T8c T32a Y2

-

Control unit in dash panel insert Dash panel insert Main beam warning lamp Rear fog light warning lamp Fog light warning lamp Dipped beam and rear lights warning lamp

135

Edition 06.04 S00.5324.01.20

white black red brown green blue grey purple yellow orange

A9

- Earth connection, in wiring harness behind dash panel - Earth connection (sender earth) -1-, in wiring harness behind dash panel - Earth connection (sender earth), in engine compartment wiring harness - Connection (56b), in wiring loom behind dash panel

A88

- Connection (NSL), in wiring loom behind dash panel

B141

- Connection (56aL), in wiring loom behind dash panel

*

- Applies only to models with optional equipment

269 327

Rear seat backrest lock warning lamp

Dash panel insert illumination bulb 6-pin connector, at left of bulkhead (brown) 8-pin connector, at dash panel insert 32-pin connector, at dash panel insert Digital clock

= = = = = = = = = =

No.61/22

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, coolant temperature gauge, rev counter, driver side seat belt switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E24 G3 G5 J285 K K2 K18 K19 K47 K65 K75 K86 K92 K94 K116 K155 K166 T6w T16a

white black red brown green blue grey purple yellow orange

-

Driver side seat belt switch Coolant temperature gauge Rev counter Control unit in dash panel insert Dash panel insert Generator warning lamp Trailer operation warning lamp Seat belt warning system warning lamp ABS warning lamp Turn signal warning lamp, left Airbag warning lamp Traction control system warning lamp Servotronic warning lamp Turn signal warning lamp, right Tailgate unlocked warning light Warning lamp for stability programme Door open warning light 6-pin connector, below driver seat (red) 16-pin connector, at electrical system control unit (black) T32a - 32-pin connector, at dash panel insert

335

- Earth connection, in wiring harness behind dash panel A121 - Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel

*♦

♦♦

- Applies only to models with optional equipment - Applies only to models with TCS - Applies only to models with ESP

Edition 06.04 S00.5324.01.20

FABIA

No.61/23

Current Flow Diagram

Immobiliser, dash panel insert, control unit in dash panel insert, warning lights, buzzer/gong

ws sw ro br gn bl gr li ge or

D2 G17 H3 J285 J362 K K117 T2o T8c T16a

-

Immobiliser reader coil (at ignition/starter switch) Ambient temperature sensor Buzzer/gong Control unit in dash panel insert Immobiliser control unit Dash panel insert Immobiliser warning lamp 2-pin connector, at immobiliser reader coil 8-pin connector, at dash panel insert 16-pin connector, at electrical system control unit (black) T32a - 32-pin connector, at dash panel insert Y6 - Selector lever position indicator

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A43

- Connection (57L), in wiring loom behind dash panel

A44

- Connection (57R), in wiring loom behind dash panel

A83

- Connection (58, daytime running lights), in wiring loom behind dash panel on left

nnn -

* ** ♦

Applies only to models with multifunction display Does not apply to models with daytime running lights Applies only to models with automatic gearbox applies only to models with daytime running lights

No.61/24

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, handbrake indicator switch, brake fluid level warning contact, low coolant level indicator sender, windscreen washer fluid level sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F9 F34 G32 G33 J285 K K7 K28 K106 T2p T2r T2s T2t T6p T11b T18b T32a

white black red brown green blue grey purple yellow orange

-

Handbrake warning switch Brake fluid level warning contact Coolant shortage indicator sender Windscreen washer fluid level sender Control unit in dash panel insert Dash panel insert Twin circuit brake and handbrake warning lamp Coolant temperature/coolant shortage warning lamp Washer water shortage warning lamp 2-pin connector, at low coolant level indicator sender 2-pin connector, at brake fluid level warning contact 2-pin connector, at handbrake indicator switch 2-pin connector, at windscreen washer fluid level sender 6-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (red) 18-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert

131

- Earth connection -2-, in engine compartment wiring harness 327 - Earth connection (sender earth), in engine compartment wiring harness 332 - Earth connection, in wiring harness behind dash panel A115 - Connection (handbrake indicator), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*♦

- Applies only to models with optional equipment - Applies only to models with ESP

Edition 06.04 S00.5324.01.20

FABIA

No.61/25

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, bonnet contact switch, brake pad wear sender

ws sw ro br gn bl gr li ge or

F266 G34 J285 K K32 T2r T2v T6p T6v T8c T16a

-

Vermin repellent system contact switch Left front brake wear indicator sender Control unit in dash panel insert Dash panel insert Brake pad warning lamp Connector, 2-pin, at front left brake pad wear sender 2-pin connector, at bonnet contact switch 6-pin connector, at left of bulkhead (red) 6-pin connector, at left of bulkhead (green) 8-pin connector, at dash panel insert 16-pin connector, at electrical system control unit (black)

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

13

- Earth point, in front right of engine compartment

327

- Earth connection (sender earth), in engine compartment wiring harness

*

===

- does not apply to models with anti-theft alarm system - applies only to models with extended service interval (ESI)

No.61/26

Current Flow Diagram

FABIA

Plug connection for radio or navigation system control unit, plug connection for diagnostic socket, databus diagnostic interface (Gateway)

ws sw ro br gn bl gr li ge or

J533 T8d

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Databus diagnostic interface (Gateway) - 8-pin connector, for radio or navigation system control unit (black) T16a - 16-pin connector, at electrical system control unit (black) T16b - 16-pin connector, in glove box on driver’s side (diagnosis connection) T18a - 18-pin connector, at electrical system control unit (brown)

335 606 A11 A21 A27 A46 A76

- Earth connection, in wiring harness behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

No.62/1

1.2 l - Simos 3 Unit Injection/40 kW, engine code AWY, from August 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 06.04 S00.5324.01.20

4

- Fuel pump relay

12

- Simos power supply relay

No.62/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery, radiator fan (models not fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S177 S180 T1a T2v T3h T3i T6n T8a T11a T14a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T18a - 18-pin connector, at electrical system control unit (brown)

V7 12a P1

- Radiator fan - Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

n n n - Thermoswitch and radiator fan dependent on optional

===

equipment (does not apply to models fitted with air conditioning or fitted with trailer coupling) - does not apply to models fitted with air conditioning or not fitted with trailer coupling

Edition 06.04 S00.5324.01.20

FABIA

No.62/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan (models fitted with trailer coupling)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 06.04 S00.5324.01.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

===

- does not apply to models fitted with air conditioning or not fitted with trailer coupling

No.62/4

Current Flow Diagram

FABIA

Simos control unit, injectors, engine speed sender, coolant temperature sender

ws sw ro br gn bl gr li ge or

G28 G62 J361 N30 N31 N32 T2a T2b T2c T2y T3m T11a T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Simos control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

A121 A122 D140 D159 D160

- Connection panel on - Connection panel - Connection loom - Connection loom - Connection loom

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (injectors), in engine assembly wiring (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

Edition 06.04 S00.5324.01.20

FABIA

No.62/5

Current Flow Diagram

Simos control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G71 G72 G130 J361 N80 T2z

-

T4g

-

T4i T4k

-

T11a T11b T14a T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter Simos control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender 4-pin connector, close to lambda probe Connector, 4-pin, close to lambda probe downstream of catalytic converter 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom E28 - Connection (lambda probe heater), in engine compartment wiring loom A130

*n n n

- not valid for EU-2 DDK - Applies only to models with CCS

No.62/6

Current Flow Diagram

FABIA

Simos control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J361 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Simos control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.62/7

Current Flow Diagram

Simos control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G163 J361 T2e T3j T6n T11b T14a

-

Knock sensor I Camshaft position sender Simos control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom

No.62/8

Current Flow Diagram

FABIA

Simos control unit, throttle valve control unit, Simos power supply relay

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G186 - Throttle valve drive (electric throttle operation) G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J361 - Simos control unit J363 - Simos power supply relay T6r - 6-pin connector, at left of bulkhead (brown) T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T11c - 11-pin connector, at left of bulkhead (blue) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

354

- Earth connection -2-, in wiring loom behind dash panel A74 - Positive connection (15a), in wiring loom behind dash panel D106 - Connection -4- (87a), in wiring loom on left of engine compartment

Edition 06.04 S00.5324.01.20

FABIA

No.62/9

Current Flow Diagram

Simos control unit, Oil level/oil temperature sender, Ignition system

ws sw ro br gn bl gr li ge or

G266 J361 N70 N127 N291 Q T3f T4a T4b T4c T14a

-

Oil level/oil temperature sender Simos control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Spark plugs Connector, 3-pin, at oil level/oil temperature sender Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

19

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom 283 - Earth connection -2-, in engine pre-assembly wiring loom 304 - Earth connection (ignition coils), in engine preassembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness F36 - Connection (87a), in engine preassembly wiring loom

*

- applies only to models with extended service interval (ESI)

No.62/10

Current Flow Diagram

FABIA

Fuel pump relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A32 A98 A99 A139

D52

*

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (15a), in engine compartment wiring loom - applies only to models with extended service interval (ESI)

Edition 06.04 S00.5324.01.20

FABIA

No.62/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display - Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel 199

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

1.4 l - 4MV/55 kW, engine code BBY, from August 2003 1.4 l - 4MV/74 kW, engine code BBZ, from August 2003 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 06.04 S00.5324.01.20

4

- Fuel pump relay

9

- Fuel feed relay

No.63/1

No.63/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1

♦

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery - Does not apply to models with automatic gearbox

n n n - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 06.04 S00.5324.01.20

FABIA

No.63/3

Current Flow Diagram

4MV control unit, injectors, engine speed sender, coolant temperature sender, exhaust gas recirculation valve, exhaust gas valve recirculation potentiometer

ws sw ro br gn bl gr li ge or

G28 G62 G212 J687 N18 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3m T6a T14a

-

Engine speed sender Coolant temperature sender Exhaust gas recirculation potentiometer 4MV control unit EGR valve Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender Connector, 6-pin, at EGR valve Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

220

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection (sender earth), in engine pre-wiring wiring harness D140 - Connection (injectors), in engine assembly wiring loom D141 - Connection (5V), in engine assembly wiring loom

No.63/4

Current Flow Diagram

FABIA

4MV control unit, lambda probe, lambda probe downstream of catalytic converter, intake manifold pressure and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G39 G71 G72 G130 J687 N80 T2z

-

T4g

-

T4k

-

T6z T11a T11b T14a

-

T40a T81a Z19 Z29

-

Lambda probe Intake manifold pressure sender Intake manifold temperature sender Lambda probe downstream of catalytic converter 4MV control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve 4-pin connector, at intake manifold pressure and intake manifold temperature sender Connector, 4-pin, close to lambda probe downstream of catalytic converter Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

220

- Earth connection (sender earth), in engine pre-wiring wiring harness A130 - Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom D141 - Connection (5V), in engine assembly wiring loom E28

- Connection (lambda probe heater), in engine compartment wiring loom

n n n - Applies only to models with CCS

Edition 06.04 S00.5324.01.20

FABIA

No.63/5

Current Flow Diagram

4MV control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F36 F47 G79 G185 J687 SB2 T4d T4h T6n T6u T11c T81a

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -24MV control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

*

- Does not apply to models with automatic gearbox

No.63/6

FABIA

Current Flow Diagram

4MV control unit, knock sensor I, camshaft position sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G61 G163 J217 J687 T2e T3j T6n T11b T14a

white black red brown green blue grey purple yellow orange

-

Knock sensor I Camshaft position sender Automatic gearbox control unit 4MV control unit 2-pin connector, at knock sensor I 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 200 - Earth connection (screening), in engine pre-wiring wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D141 - Connection (5V), in engine assembly wiring loom D166

- Connection (K diagnosis wire), in engine compartment wiring loom

*

- Applies only to models with automatic gearbox

Edition 06.04 S00.5324.01.20

FABIA

No.63/7

Current Flow Diagram

4MV control unit, throttle valve control unit

ws sw ro br gn bl gr li ge or

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J338 - Throttle valve control unit J687 - 4MV control unit N79 - Crankcase breather heater element T2m - 2-pin connector, at crankcase breather heater element T6t - 6-pin connector, at throttle valve control unit T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner

Edition 06.04 S00.5324.01.20

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom A121

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring

No.63/8

Current Flow Diagram

FABIA

4MV control unit, Ignition system, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G266 J687 N70 N127 N291 N292 Q T3f T4a T4b T4c T4d T14a

white black red brown green blue grey purple yellow orange

-

Oil level/oil temperature sender 4MV control unit Ignition coil 1 with output stage Ignition coil 2 with output stage Ignition coil 3 with output stage Ignition coil 4 with output stage Spark plugs Connector, 3-pin, at oil level/oil temperature sender Connector, 4-pin, at ignition coil 1 Connector, 4-pin, at ignition coil 2 Connector, 4-pin, at ignition coil 3 Connector, 4-pin, at ignition coil 4 Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

19

- Earth point, near coil

281

- Earth connection -1-, in engine pre-assembly wiring loom 304 - Earth connection (ignition coils), in engine preassembly wiring loom D33 - Connection -2- (15a), in engine pre-assembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness

*

- applies only to models with extended service interval (ESI)

Edition 06.04 S00.5324.01.20

FABIA

No.63/9

Current Flow Diagram

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99 A139

D25 D52

*

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Connection (15a), in engine pre-assembly wiring loom - Positive connection (15a), in engine compartment wiring loom - applies only to models with extended service interval (ESI)

No.63/10

Current Flow Diagram

FABIA

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

Edition 06.04 S00.5324.01.20

FABIA

No.63/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display - Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel 199

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.64/1

2.0 l - Motronic/85 kW, engine code AZL, from August 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Relay holder: Relay position assignment

Edition 06.04 S00.5324.01.20

1

- Secondary air pump relay

2

- Motronic power supply relay

4

- Fuel pump relay

9

- Fuel feed relay

No.64/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

n n n - Does not apply to models with air conditioning

Edition 06.04 S00.5324.01.20

FABIA

No.64/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 06.04 S00.5324.01.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

n n n - Does not apply to models with air conditioning

No.64/4

Current Flow Diagram

FABIA

Motronic control unit, Injectors, Engine speed sender, Coolant temperature sender, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G28 G62 G266 J220 N30 N31 N32 N33 T2a T2b T2c T2d T2y T3f T3m T14a

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Oil level/oil temperature sender Motronic control unit Injector cylinder 1 Injector cylinder 2 Injector cylinder 3 Injector cylinder 4 2-pin connector, at injector cylinder 1 2-pin connector, at injector cylinder 2 2-pin connector, at injector cylinder 3 2-pin connector, at injector cylinder 4 2-pin connector, at coolant temperature sender Connector, 3-pin, at oil level/oil temperature sender 3-pin connector, at engine speed sender Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T40a - 40-pin connector, at engine control unit

220

- Earth connection (sender earth), in engine pre-wiring wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness D140 - Connection (injectors), in engine assembly wiring loom

*

- applies only to models with extended service interval (ESI)

Edition 06.04 S00.5324.01.20

FABIA

No.64/5

Current Flow Diagram

Motronic control unit, lambda probe, lambda probe downstream of catalytic converter, air mass meter and intake manifold temperature sender, activated charcoal filter system solenoid valve

ws sw ro br gn bl gr li ge or

G39 G70 G72 G130 J220 N80 T2z

-

T4k

-

T5m

-

T6z T11b T14a T81a Z19 Z29 -

Lambda probe Air mass meter Intake manifold temperature sender Lambda probe downstream of catalytic converter Motronic control unit Activated charcoal filter system solenoid valve 2-pin connector, at activated charcoal filter system solenoid valve Connector, 4-pin, close to lambda probe downstream of catalytic converter Plug connection, 5-pin, at air mass meter and intake manifold temperature sender Connector, 6-pin, close to lambda probe 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit Lambda probe heater Lambda probe heater downstream of catalytic converter

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

D52

- Positive connection (15a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom E28 - Connection (lambda probe heater), in engine compartment wiring loom

*

- Applies only to models with optional equipment

No.64/6

Current Flow Diagram

FABIA

Motronic control unit, accelerator pedal position sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F F36 F47 G79 G185 J220 SB2 T4d T4h T6n T6u T11c T81a

white black red brown green blue grey purple yellow orange

-

Brake light switch Clutch pedal switch Brake pedal switch Accelerator position sender Accelerator pedal position sender -2Motronic control unit Fuse, in fuse holder 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.64/7

Current Flow Diagram

Motronic control unit, knock sensor I, knock sensor II, camshaft position sender

ws sw ro br gn bl gr li ge or

G61 G66 G163 J220 T2e T2k T3j T6n T11b T40a T81a

-

Knock sensor I Knock sensor II Camshaft position sender Motronic control unit 2-pin connector, at knock sensor I 2-pin connector, at knock sensor II 3-pin connector, at camshaft position sender 6-pin connector, at left of bulkhead (blue) 11-pin connector, at left of bulkhead (red) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

29

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 220 - Earth connection (sender earth), in engine pre-wiring wiring harness A76 - Connection (K diagnosis wire), in wiring loom behind dash panel on left D145 - Connection (knock sensors), in engine pre-wiring wiring harness

No.64/8

Current Flow Diagram

FABIA

Motronic control unit, throttle valve control unit, secondary air pump motor

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

G187 - Angle sender -1- for throttle valve drive (electric throttle operation) G188 - Angle sender -2- for throttle valve drive (electric throttle operation) J220 - Motronic control unit J338 - Throttle valve control unit T2g - 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) T2l - 2-pin connector, at secondary air pump motor T6t - 6-pin connector, at throttle valve control unit T6w - 6-pin connector, at left of bulkhead (grey) T11a - 11-pin connector, at left of bulkhead (white) T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit V60 - Throttle valve positioner V101 - Secondary air pump motor

131 A121 A122 A130 D159 D160

- Earth connection -2-, in engine compartment wiring harness - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CCS), in wiring loom behind dash panel on left - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

n n n - Applies only to models with CCS

Edition 06.04 S00.5324.01.20

FABIA

No.64/9

Current Flow Diagram

Motronic control unit, ignition system, secondary air pump relay

ws sw ro br gn bl gr li ge or

J220 J271 J299 N79 N152 P Q T2m

-

T4f T6r T6w T11a T11c T14a

-

T40a T81a -

Motronic control unit Motronic power supply relay Secondary air pump relay Crankcase breather heater element Ignition transformer Spark plug connector Spark plugs 2-pin connector, at crankcase breather heater element 4-pin connector, at ignition transformer 6-pin connector, at left of bulkhead (brown) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

131

- Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom D173 - Connection (87), in engine assembly wiring loom

*

- Applies only to models with optional equipment

No.64/10

Current Flow Diagram

FABIA

Fuse holder

ws sw ro br gn bl gr li ge or

T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A2 A15 A98 A99

- Positive connection (15), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel

- Positive connection (15), in wiring loom behind dash panel A177 - Connection (87), in wiring loom behind dash panel A139

D52

*

- Positive connection (15a), in engine compartment wiring loom - applies only to models with extended service interval (ESI)

Edition 06.04 S00.5324.01.20

FABIA

No.64/11

Current Flow Diagram

Fuel pump relay, fuel feed relay

ws sw ro br gn bl gr li ge or

J17 J643 T6r T16a

-

Fuel pump relay Fuel feed relay 6-pin connector, at left of bulkhead (brown) 16-pin connector, at electrical system control unit (black)

A32 A56 A98 A99 A139

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a), in wiring loom behind dash panel on left - Positive connection (30a), in wiring loom behind dash panel - Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) - Connection (87), in wiring loom behind dash panel - Positive connection (15), in wiring loom behind dash panel

No.64/12

FABIA

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G6 G21 G22 J285 K K3 K38 K83 K105 K132 T1b T3l T4j T6v T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp Electric throttle control fault lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel 281 - Earth connection -1-, in engine pre-assembly wiring loom A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

No.65/1

1.9 l/47 kW - SDI, engine code ASY, from August 2003

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

8

- Low heating capacity relay

b

- S277 - Fuse -2- for heating element

9

- High heating capacity relay

c

- S278 - Fuse -3- for heating element

15

- Diesel direct injection system relay

Edition 06.04 S00.5324.01.20

No.65/2

Current Flow Diagram

FABIA

Starter, alternator, radiator fan, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D F18 S162 S176 S180 T1a T2v T2w T3h T3i T6n T8a T11a T18a V7

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Radiator fan thermoswitch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown) - Radiator fan

12a P1

- Earth point -2-, in engine compartment, on left below battery (at side member) - Positive connection (30), in fuse holder on battery

n n n - Thermoswitch and radiator fan vary according to

optional equipment (does not apply to models with air conditioning)

Edition 06.04 S00.5324.01.20

FABIA

No.65/3

Current Flow Diagram

Diesel direct injection system control unit, glow plug relay, glow plugs, EGR valve

ws sw ro br gn bl gr li ge or

J52 J248 N18 Q6 T2g

-

T2h T6w T11a T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit EGR valve Glow plugs 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 2-pin connector, at exhaust gas recirculation valve 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

D78

- Connection (87), in wiring loom behind dash panel

- Positive connection -1- (30a), in engine compartment wiring loom D103 - Connection -3- (87a), in engine compartment wiring loom

No.65/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, accelerator pedal position sender, intake manifold temperature sender, brake pedal switch, clutch pedal switch

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G72 G79 J248 SB2 T2i T4d T4h T6n T6u T11b T11c T81a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Intake manifold temperature sender Accelerator position sender Diesel direct injection system control unit Fuse, in fuse holder 2-pin connector, at fuel gauge sender 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 81-pin connector, at engine control unit

328 A18

- Earth connection -2- (sender earth), in engine compartment wiring harness - Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.65/5

Current Flow Diagram

Diesel direct injection system control unit, fuel temperature sender, modulating piston movement sender, quantity adjuster

ws sw ro br gn bl gr li ge or

F268 G81 G149 J248 N108 N109 N146 SB14 T6n T10c T10e T11a T11b T11c T16c T40a T81a

-

Heater element contact switch (PTC) Fuel temperature sender Modulating piston movement sender Diesel direct injection system control unit Commencement of injection valve Fuel cut off valve Quantity (metering) adjuster Fuse, in fuse holder 6-pin connector, at left of bulkhead (blue) 10-pin connector, behind dash panel on right 10-pin connector, at injection pump 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) 16-pin connector, at fresh air controls 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A130 - Connection (CCS), in wiring loom behind dash panel on left F25 - Connection -1-, in engine preassembly wiring loom F36

*n n n ===

- Connection (87a), in engine preassembly wiring loom - does not apply to models with air conditioning - Applies only to models with CCS - Applies only to models with heating element (PTC)

No.65/6

Current Flow Diagram

FABIA

Diesel direct injection system control unit, engine speed sender, coolant temperature sender, needle motion sender

ws sw ro br gn bl gr li ge or

G28 G62 G80 J248 T2j T2y T3m T11a T40a T81a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Engine speed sender Coolant temperature sender Needle lift sender Diesel direct injection system control unit 2-pin connector, at needle lift sender 2-pin connector, at coolant temperature sender 3-pin connector, at engine speed sender 11-pin connector, at left of bulkhead (white) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

- Connection panel on A122 - Connection panel D159 - Connection loom D160 - Connection loom F27 - Connection harness A121

(CAN-H), in wiring loom behind dash (CAN-L), in wiring loom behind dash (CAN-H), in engine compartment wiring (CAN-L), in engine compartment wiring (screening), in engine pre-wiring wiring

Edition 06.04 S00.5324.01.20

FABIA

No.65/7

Current Flow Diagram

Diesel direct injection system control unit, Intake manifold flap motor, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

G266 J248 T3f T4l T14a

-

Oil level/oil temperature sender Diesel direct injection system control unit Connector, 3-pin, at oil level/oil temperature sender 4-pin connector, at intake manifold flap motor Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T81a - 81-pin connector, at engine control unit V157 - Intake manifold flap motor

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

281

- Earth connection -1-, in engine pre-assembly wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness

*

- applies only to models with extended service interval (ESI)

No.65/8

Current Flow Diagram

FABIA

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J359 J360 S276 S277 S278 T3n TV2 Z35

white black red brown green blue grey purple yellow orange

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

606

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel = = = - Applies only to models with heating element (PTC)

Edition 06.04 S00.5324.01.20

FABIA

No.65/9

Current Flow Diagram

Diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J322 T3a T6r T11b T14a

-

Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

white black red brown green blue grey purple yellow orange

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

*

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

- applies only to models with extended service interval (ESI)

No.65/10

Current Flow Diagram

FABIA

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F1 G G1 G21 G22 J285 K K3 K29 K38 K83 K105 T1b T2f T3l T6v T11a T11b T14a

white black red brown green blue grey purple yellow orange

-

Oil pressure switch Fuel gauge sender Fuel gauge Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 2-pin connector, at fuel gauge sender 3-pin connector, at speedometer sender 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert

Y4

- Odometer display

- Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel 269

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

No.66/1

1.9 l - TDI with unit injection system/74 kW, engine code ATD, from August 2003

Fuse holder:

Fuse holder on battery:

Fuse colours

Fuse colours

30A 25A 20A 15A 10A 7.5A 5A

30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

-

green white yellow blue red brown beige

Relay holder:

Additional fuse holder:

Relay position assignment:

Fuse position assignment:

3

- Glow plug relay

a

- S276 - Fuse -1- for heating element

4

- Fuel pump relay

b

- S277 - Fuse -2- for heating element

8

- Low heating capacity relay

c

- S278 - Fuse -3- for heating element

9

- High heating capacity relay

15

- Diesel direct injection system relay

Edition 06.04 S00.5324.01.20

No.66/2

Current Flow Diagram

FABIA

Starter, alternator, fuse holder on battery

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

A B C C1 D S162 S176 S177 S180 T1a T2v T2w T6n T8a T11a T18a

white black red brown green blue grey purple yellow orange

-

Battery Starter Alternator Voltage regulator Ignition/starter switch Fuse -1- (30), in fuse holder on battery Fuse -4- (30), in fuse holder on battery Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery 1-pin connector, at starter 2-pin connector, at alternator 2-pin connector, in bracket at gearbox 6-pin connector, at left of bulkhead (blue) 8-pin connector, at ignition/starter switch 11-pin connector, at left of bulkhead (white) 18-pin connector, at electrical system control unit (brown)

P1

- Positive connection (30), in fuse holder on battery

n n n - Does not apply to models with air conditioning

Edition 06.04 S00.5324.01.20

FABIA

No.66/3

Current Flow Diagram

Radiator fan control unit, radiator fan thermoswitch, radiator fan

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

Edition 06.04 S00.5324.01.20

12a 108

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

n n n - Does not apply to models with air conditioning

No.66/4

Current Flow Diagram

FABIA

Diesel direct injection system control unit, glow plug relay, glow plugs

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J52 J248 Q6 SB14 T2g

-

T6w T11a T11b T14a

-

T81a -

Glow plug relay Diesel direct injection system control unit Glow plugs Fuse, in fuse holder 2-pin connector, in left of engine compartment (connection of engine assembly wiring loom/engine compartment wiring loom) 6-pin connector, at left of bulkhead (grey) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) 81-pin connector, at engine control unit

29

- Earth point, in left of engine compartment, behind battery (at suspension strut mounting) 131 - Earth connection -2-, in engine compartment wiring harness 281 - Earth connection -1-, in engine pre-assembly wiring loom A40 - Positive connection (30a), in wiring loom behind dash panel A101 - Connection (87), in wiring loom behind dash panel A151

- Connection (87), in wiring loom behind dash panel

D78

- Positive connection -1- (30a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment

* ♦

- applies only to models with extended service interval (ESI) - Applies only to models with optional equipment

Edition 06.04 S00.5324.01.20

FABIA

No.66/5

Current Flow Diagram

Control unit for Diesel direct injection system, Accelerator pedal position sender, Brake pedal switch, Clutch pedal switch, Oil level/oil temperature sender

ws sw ro br gn bl gr li ge or

F F8 F36 F47 F60 G79 G266 J248 SB2 T3f T4d T4h T6n T6u T11b T11c T14a

-

Brake light switch Kickdown switch Clutch pedal switch Brake pedal switch Idling speed switch Accelerator position sender Oil level/oil temperature sender Diesel direct injection system control unit Fuse, in fuse holder Connector, 3-pin, at oil level/oil temperature sender 4-pin connector, at brake pedal switch 4-pin connector, at clutch pedal switch 6-pin connector, at left of bulkhead (blue) 6-pin connector, at accelerator pedal position sender 11-pin connector, at left of bulkhead (red) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T81a - 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

D73

- Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom D107 - Connection -5- (Oil level/oil temperature sender), left in engine compartment wiring harness

*

- applies only to models with extended service interval (ESI)

No.66/6

Current Flow Diagram

FABIA

Diesel direct injection system control unit, coolant temperature sender, fuel temperature sender, exhaust gas recirculation valve, charge pressure control solenoid valve, intake manifold flap changeover valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F268 G62 G81 J248 N18 N75 N239 T2b T2y T6z T10c T11a T11c T14a

white black red brown green blue grey purple yellow orange

-

Heater element contact switch (PTC) Coolant temperature sender Fuel temperature sender Diesel direct injection system control unit EGR valve Boost pressure control solenoid valve Intake manifold flap changeover valve Plug connection, 2-pin, at fuel temperature sender 2-pin connector, at coolant temperature sender Connector, 6-pin, at valve block 10-pin connector, behind dash panel on right 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16c - 16-pin connector, at fresh air controls T40a - 40-pin connector, at engine control unit T81a - 81-pin connector, at engine control unit

- Connection (CCS), in wiring loom behind dash panel on left D103 - Connection -3- (87a), in engine compartment wiring loom A130

*n n n ===

- does not apply to models with air conditioning - Applies only to models with CCS - Applies only to models with heating element (PTC)

Edition 06.04 S00.5324.01.20

FABIA

No.66/7

Current Flow Diagram

Diesel direct injection system control unit, engine speed sender, camshaft position sender, air mass meter, intake manifold pressure and intake manifold temperature sender

ws sw ro br gn bl gr li ge or

G28 G40 G70 G71 G72 N79 J248 T2m

-

T3j T3m T4g

-

T5l T40a T81a -

Engine speed sender Camshaft position sender Air mass meter Intake manifold pressure sender Intake manifold temperature sender Crankcase breather heater element Diesel direct injection system control unit 2-pin connector, at crankcase breather heater element 3-pin connector, at camshaft position sender 3-pin connector, at engine speed sender 4-pin connector, at intake manifold pressure and intake manifold temperature sender 5-pin connector, at air mass meter 40-pin connector, at engine control unit 81-pin connector, at engine control unit

Edition 06.04 S00.5324.01.20

D52 F27 F36

♦

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (15a), in engine compartment wiring loom - Connection (screening), in engine pre-wiring wiring harness - Positive connection (87a), in engine assembly wiring loom - Applies only to models with optional equipment

No.66/8

Current Flow Diagram

FABIA

Diesel direct injection system control unit, unit injectors

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J248 N240 N241 N242 N243 T2c T2d T2e T2f T6n T8o T11a T11c T40a T81a

white black red brown green blue grey purple yellow orange

-

Diesel direct injection system control unit Unit injector, cylinder 1 Unit injector, cylinder 2 Unit injector, cylinder 3 Unit injector, cylinder 4 2-pin connector at unit injector valves, No. 1 cyl Plug connection, 2-pin, at unit injector, cylinder 2 Plug connection, 2-pin, at unit injector, cylinder 3 Plug connection, 2-pin, at unit injector, cylinder 4 6-pin connector, at left of bulkhead (blue) Plug connection, 8-pin, at cylinder head 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (blue) 40-pin connector, at engine control unit 81-pin connector, at engine control unit

A76 A121 A122 D159 D160

F26 ===

- Connection (K diagnosis wire), in wiring loom behind dash panel on left - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Connection (earth), in cylinder head wiring loom - Applies only to models with heating element (PTC)

Edition 06.04 S00.5324.01.20

FABIA

No.66/9

Current Flow Diagram

Low heating capacity relay, high heating capacity relay, heating element for additional heater (PTC), additional fuse holder

ws sw ro br gn bl gr li ge or

J359 J360 S276 S277 S278 T3n TV2 Z35

-

Low heating capacity relay High heating capacity relay Fuse -1- for heater element Fuse -2- for heater element Fuse -3- for heater element 3-pin connector, behind dash panel (at PTC heating element) - Terminal 30 junction, behind dash panel on left - Additional heating heater element (PTC)

Edition 06.04 S00.5324.01.20

606

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point, under the centre console, near gear stick

A98

- Positive connection (30a), in wiring loom behind dash panel (applies only to models with telephone system) A152 - Connection (87), in wiring harness behind dash panel ===

- Applies only to models with heating element (PTC)

No.66/10

Current Flow Diagram

FABIA

Fuel pump relay, diesel direct injection system relay, fuse holder

ws sw ro br gn bl gr li ge or

J17 J322 T3a T6n T6r T11b T14a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Fuel pump relay Diesel direct injection system relay 3-pin connector, at left of bulkhead (grey) 6-pin connector, at left of bulkhead (blue) 6-pin connector, at left of bulkhead (brown) 11-pin connector, at left of bulkhead (red) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom)

A15

- Positive connection (15), in wiring loom behind dash panel A32 - Positive connection (30a), in wiring loom behind dash panel on left A101 - Connection (87), in wiring loom behind dash panel D52

- Positive connection (15a), in engine compartment wiring loom D102 - Connection -2- (87a), in wiring loom in left of engine compartment D103 - Connection -3- (87a), in engine compartment wiring loom

*

- applies only to models with extended service interval (ESI)

Edition 06.04 S00.5324.01.20

FABIA

No.66/11

Current Flow Diagram

Dash panel insert, control unit in dash panel insert, warning lights, oil pressure switch, fuel gauge sender, fuel pump, speedometer sender, fuel gauge, speedometer, odometer display

ws sw ro br gn bl gr li ge or

F1 G G1 G6 G21 G22 J285 K K3 K29 K38 K83 K105 T1b T3l T4j T6v T11a T11b

-

Oil pressure switch Fuel gauge sender Fuel gauge Fuel pump Speedometer Speedometer sender Control unit in dash panel insert Dash panel insert Oil pressure warning lamp Glow period warning lamp Oil level indicator light Exhaust gas warning lamp Reserve fuel warning lamp 1-pin connector, at oil pressure switch 3-pin connector, at speedometer sender 4-pin connector, at fuel pump 6-pin connector, at left of bulkhead (green) 11-pin connector, at left of bulkhead (white) 11-pin connector, at left of bulkhead (red)

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T14a - Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T32a - 32-pin connector, at dash panel insert Y4 - Odometer display 199

- Earth connection, in wiring harness behind dash panel 269 - Earth connection (sender earth) -1-, in wiring harness behind dash panel A27 - Connection (vehicle speed signal), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel

* ♦

- applies only to models with extended service interval (ESI) - not valid for vehicles with ABS/ABS with EDL and TCS/ESP

FABIA

Current Flow Diagram

No.67/1

Anti-lock brake system (ABS) Antilock brake system(ABS) with differential lock (EDL) and traction control system (TCS), from August 2003 Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 06.04 S00.5324.01.20

-

green white yellow blue red brown beige

No.67/2

Current Flow Diagram

FABIA

ABS/ABS with EDL and TCS control unit, fuse holder on battery, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F J104 J105 J503 N99 N100 N101 N102 S178 S179 T4d T8e T9a T11c T26a T42a V39

white black red brown green blue grey purple yellow orange

-

Brake light switch ABS/ABS with EDL and TCS control unit Return delivery pump relay ABS Navigation system control unit ABS inlet valve, front right ABS outlet valve, front right ABS inlet valve, front left ABS outlet valve, front left Fuse -6- (30), in fuse holder on battery Fuse -7- (30), in fuse holder on battery 4-pin connector, at brake pedal switch Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (blue) 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS/ABS with EDL and TCS control unit - ABS return delivery pump

614

- Earth point -2-, in rear right of engine compartment

A18

- Connection (54), in wiring loom behind dash panel

A38

- Positive connection -2- (15a), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel D73 - Connection (54), in left of engine compartment wiring loom P1 - Positive connection (30), in fuse holder on battery

*

===

- Applies only to models with TCS - applies only to models with navigation system

Edition 06.04 S00.5324.01.20

FABIA

No.67/3

Current Flow Diagram

ABS/ABS with EDL and TCS control unit, wheel speed sensors

ws sw ro br gn bl gr li ge or

G44 G45 G46 G47 J104 J106 N133 N134 N135 N136 T2k T2l T2m T2n T9a T42a

-

Wheel speed sensor, rear right Wheel speed sensor, front right Wheel speed sensor, rear left Wheel speed sensor, front left ABS/ABS with EDL and TCS control unit ABS solenoid valves relay ABS inlet valve, rear right ABS inlet valve, rear left ABS outlet valve, rear right ABS outlet valve, rear left 2-pin connector, at rear right wheel speed sensor 2-pin connector, at rear left wheel speed sensor 2-pin connector, at front right wheel speed sensor 2-pin connector, at front left wheel speed sensor Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS/ABS with EDL and TCS control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

J3

- Connection, in rear right wiring loom

J5

- Connection, in rear right wiring loom

J7

- Connection, in rear left wiring loom

J8

- Connection, in rear left wiring loom

white black red brown green blue grey purple yellow orange

No.67/4

Current Flow Diagram

FABIA

ABS/ABS with EDL and TCS control unit, TCS switch, dash panel insert

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

E132 J104 J285 K K47 K86 L71 N166 N167 N168 N169 T6b T9a T11a T32a T42a

white black red brown green blue grey purple yellow orange

-

TCS switch ABS/ABS with EDL and TCS control unit Control unit in dash panel insert Dash panel insert ABS warning lamp Traction control system warning lamp TCS switch lighting Front right EDL changeover valve Front right EDL outlet valve Front left EDL changeover valve Front left EDL outlet valve Connector, 6-pin, at TCS switch Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (white) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS/ABS with EDL and TCS control unit

332 A4 A121 A122 D159 D160

*

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom - Applies only to models with TCS

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

No.68/1

Anti-lock brake system (ABS) with electronic differential lock (EDL), traction control system (TCS), electronic stabilisation program (ESP), from August 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 06.04 S00.5324.01.20

-

green white yellow blue red brown beige

No.68/2

Current Flow Diagram

FABIA

ABS with EDL and TCS/ESP control unit, fuse holder on battery, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J104 J105 J503 N99 N100 N101 N102 S178 S179 T8e T9a T26a T42a V39

white black red brown green blue grey purple yellow orange

-

ABS with EDL and TCS/ ESP control unit Return delivery pump relay - ABS Navigation system control unit ABS inlet valve, front right ABS outlet valve, front right ABS inlet valve, front left ABS outlet valve, front left Fuse -6- (30), in fuse holder on battery Fuse -7- (30), in fuse holder on battery Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS with EDL and TCS/ ESP control unit - ABS return delivery pump

614

- Earth point -2-, in rear right of engine compartment

A38

- Positive connection -2- (15a), in wiring loom behind dash panel A139 - Positive connection (15), in wiring loom behind dash panel P1 - Positive connection (30), in fuse holder on battery ===

- applies only to models with navigation system

Edition 06.04 S00.5324.01.20

FABIA

No.68/3

Current Flow Diagram

ABS with EDL and TCS/ ESP control unit, wheel speed sensors

ws sw ro br gn bl gr li ge or

G44 G45 G46 G47 J104 J106 N133 N134 N135 N136 T2k T2l T2m T2n T9a T42a

-

Wheel speed sensor, rear right Wheel speed sensor, front right Wheel speed sensor, rear left Wheel speed sensor, front left ABS with EDL and TCS/ ESP control unit ABS solenoid valves relay ABS inlet valve, rear right ABS inlet valve, rear left ABS outlet valve, rear right ABS outlet valve, rear left 2-pin connector, at rear right wheel speed sensor 2-pin connector, at rear left wheel speed sensor 2-pin connector, at front right wheel speed sensor 2-pin connector, at front left wheel speed sensor Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS with EDL and TCS/ ESP control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

J3

- Connection, in rear right wiring loom

J5

- Connection, in rear right wiring loom

J7

- Connection, in rear left wiring loom

J8

- Connection, in rear left wiring loom

white black red brown green blue grey purple yellow orange

No.68/4

Current Flow Diagram

FABIA

ABS with EDL and TCS/ ESP control unit, brake pedal switch

ws sw ro br gn bl gr li ge or

F F9 F47 J104 K SB2 T4d T8e T11c T32a T42a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Brake light switch Handbrake warning switch Brake pedal switch ABS with EDL and TCS/ ESP control unit Dash panel insert Fuse, in fuse holder 4-pin connector, at brake pedal switch Plug connection, 8-pin, at left of bulkhead (orange) 11-pin connector, at left of bulkhead (blue) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS with EDL and TCS/ ESP control unit

A18

- Connection (54), in wiring loom behind dash panel

A100

- Connection (87a), in wiring loom behind dash panel

- Connection (handbrake indicator), in wiring loom behind dash panel D73 - Connection (54), in left of engine compartment wiring loom D101 - Connection (brake pedal switch), in engine compartment wiring loom A115

Edition 06.04 S00.5324.01.20

FABIA

No.68/5

Current Flow Diagram

ABS with EDL and TCS/ESP control unit, brake pressure sender -1-, lateral acceleration sender, yaw rate sender

ws sw ro br gn bl gr li ge or

G200 G201 G202 J104 T3e

-

T6x

-

T8e T9a T42a -

Lateral acceleration sender, below driver seat Brake pressure sender -1-, at hydraulic unit Yaw rate sender, below driver seat ABS with EDL and TCS/ ESP control unit Connector, 3-pin, at brake pressure sender -1-, at hydraulic unit Connector, 6-pin, at lateral acceleration and yaw rate sender Plug connection, 8-pin, at left of bulkhead (orange) Connector, 9-pin, at left of bulkhead (yellow) Connector, 42-pin, at ABS with EDL and TCS/ ESP control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

No.68/6

Current Flow Diagram

FABIA

ABS with EDL and TCS/ESP control unit, steering angle sender

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

G85 J104 K N225 N226 N227 N228 SB1 T6y T8c

white black red brown green blue grey purple yellow orange

-

Steering angle sender ABS with EDL and TCS/ ESP control unit Dash panel insert Electronic stability programme, valve -1Electronic stability programme, valve -2Electronic stability programme high pressure valve -1Electronic stability programme high pressure valve -2Fuse, in fuse holder Connector, 6-pin, at steering angle sender 8-pin connector, at dash panel insert

- Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel A164 - Positive connection (30a), in wiring loom behind dash panel A121

Edition 06.04 S00.5324.01.20

FABIA

No.68/7

Current Flow Diagram

ABS with EDL and TCS/ESP control unit, TCS/ESP switch, dash panel insert

ws sw ro br gn bl gr li ge or

E256 J104 J285 K K47 K155 L115 T6b T9a T11a T32a T42a

-

TCS/ ESP switch ABS with EDL and TCS/ ESP control unit Control unit in dash panel insert Dash panel insert ABS warning lamp Warning lamp for stability programme TCS/ ESP switch illumination Connector, 6-pin, at TCS/ESP switch Connector, 9-pin, at left of bulkhead (yellow) 11-pin connector, at left of bulkhead (white) 32-pin connector, at dash panel insert Connector, 42-pin, at ABS with EDL and TCS/ ESP control unit

Edition 06.04 S00.5324.01.20

332 A4 A121 A122 D159 D160

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in wiring harness behind dash panel - Positive connection (58b), in wiring loom behind dash panel - Connection (CAN-H), in wiring loom behind dash panel on - Connection (CAN-L), in wiring loom behind dash panel - Connection (CAN-H), in engine compartment wiring loom - Connection (CAN-L), in engine compartment wiring loom

FABIA

Current Flow Diagram

Air conditioning, from August 2003

Fuse holder: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

-

green white yellow blue red brown beige

Fuse holder on battery: Fuse colours 30A 25A 20A 15A 10A 7.5A 5A

Edition 06.04 S00.5324.01.20

-

green white yellow blue red brown beige

No.69/1

No.69/2

Current Flow Diagram

FABIA

Air conditioning control unit, fresh air blower, fresh and recirculated air flap positioning motor, fuse holder

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

E9 E159 G56 G143

-

J301 K114 L16 N24 T2u T4e T5h T6s

-

T10c T18c V2 V42 V154

-

Fresh air blower switch Fresh and recirculated air flap switch Dash panel temperature sensor Fresh and recirculated air flap positioning motor potentiometer AC control unit Fresh air and air recirculation operation warning lamp Air conditioning control lighting Series resistor with overheating fuse 2-pin connector, at fresh air blower 4-pin connector, at fresh air blower series resistor 5-pin connector, at fresh air blower switch 6-pin connector, at fresh/recirculated air flap positioning motor 10-pin connector, behind dash panel on right 18-pin connector, at air conditioning control unit Fresh air blower Temperature sensor blower - dash panel Fresh and recirculated air flap motor

606

- Earth point, under the centre console, near gear stick

A34

- Positive connection (75x), in wiring loom behind dash panel - Connection (75al), in air conditioning wiring loom

L4 L5 L31

- Connection (sender earth), in air conditioning wiring loom - Connection (5V), in air conditioning wiring loom

Edition 06.04 S00.5324.01.20

FABIA

No.69/3

Current Flow Diagram

Air conditioning control unit, temperature flap positioning motor, temperature sender

ws sw ro br gn bl gr li ge or

E35 G92 G191 G192 G263 G267 J301 K84 SB3 T2h

-

T2i

-

T2j

-

T6u T16b T16e T18c V68 -

Air conditioner switch Temperature flap positioning motor potentiometer Centre outlet air temperature sender Footwell vent temperature sender Evaporator outlet air temperature sender Temperature selector rotary knob potentiometer AC control unit Air conditioning warning light Fuse, in fuse holder 2-pin connector at footwell vent temperatur sender 2-pin connector at evaporator out-flow temperature sender 2-pin connector at centre footwell vent temperatur sender 6-pin connector, at temperature flap positioning motor 16-pin connector, in glove box on driver’s side (diagnosis connection) 16-pin connector, at AC control unit 18-pin connector, at air conditioning control unit Temperature flap positioning motor

Edition 06.04 S00.5324.01.20

A68 L5 L6 L31

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Positive connection (30a, AC), in wiring loom behind dash panel - Connection (sender earth), in air conditioning wiring loom - Connection (sender earth), in air conditioning wiring loom - Connection (5V), in air conditioning wiring loom

No.69/4

FABIA

Current Flow Diagram

Air conditioning control unit, AC compressor control valve

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J301 N280 SB12 T2k T2l T11d T14a

white black red brown green blue grey purple yellow orange

-

AC control unit AC compressor control valve Fuse, in fuse holder 2-pin connector, in bracket at gearbox 2-pin connector, at compressor 11-pin connector, at left of bulkhead (brown) Connector, 14-pin, in left of engine compartment (connection of the engine pre-assembly wiring loom/ engine compartment wiring loom) T16e - 16-pin connector, at AC control unit T18b - 18-pin connector, at electrical system control unit (black)

82

- Earth connection, in front left wiring harness

281

- Earth connection -1-, in engine pre-assembly wiring loom 332 - Earth connection, in wiring harness behind dash panel A70 - Positive connection (15a), in wiring loom behind dash panel A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

*

===

- does not apply to engine code AWY - applies only to engine codes AWY

Edition 06.04 S00.5324.01.20

FABIA

No.69/5

Current Flow Diagram

Radiator fan control unit, fuse holder on battery, high-pressure sensor

ws sw ro br gn bl gr li ge or

G65 J293 S177 S180 S269 T3t T6v

-

High-pressure sensor Radiator fan control unit Fuse -5- (30), in fuse holder on battery Fuse -8- (30), in fuse holder on battery Fuse -11- (30), in fuse holder on battery 3-pin connector, at high-pressure sensor 6-pin connector, at radiator fan control unit

Edition 06.04 S00.5324.01.20

12a 82 D155

P1

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth point -2-, in engine compartment, on left below battery (at side member) - Earth connection, in front left wiring harness - Connection (15, high-pressure sender), in engine compartment wiring loom - Positive connection (30), in fuse holder on battery

No.69/6

Current Flow Diagram

FABIA

Radiator fan control unit, Radiator fan thermal switch, Radiator fan (not valid for engine code letters AMF)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T3u T4t T6v V7 V35

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan Radiator fan, right

82

- Earth connection, in front left wiring harness

- Connection (fan stage 1), in engine compartment wiring loom D168 - Connection (fan stage 2), in engine compartment wiring loom D167

Edition 06.04 S00.5324.01.20

FABIA

No.69/7

Current Flow Diagram

Radiator fan control unit, Radiator fan thermal switch, Radiator fan (only for engine code letters AMF)

ws sw ro br gn bl gr li ge or

F18 J279 J293 J513 T3h T3i T4t T6v V7

-

Radiator fan thermoswitch Radiator fan relay, stage 1 Radiator fan control unit Radiator fan relay, stage 2 3-pin connector, at radiator fan thermoswitch 3-pin connector, in bracket on left of radiator 4-pin connector, at radiator fan control unit 6-pin connector, at radiator fan control unit Radiator fan

Edition 06.04 S00.5324.01.20

82

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Earth connection, in front left wiring harness

FABIA

Current Flow Diagram

Radio system, from August 2003

Edition 06.04 S00.5324.01.20

No.70/1

No.70/2

Current Flow Diagram

FABIA

Radio, front speakers, aerial

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

R R11 R20 R21 R22 R23 R24 S92 SB45 T2m T2n T4m T4n T4u T4v T8d T8n

white black red brown green blue grey purple yellow orange

-

Radio Aerial Treble loudspeaker, front left Bass loudspeaker, front left Treble loudspeaker, front right Bass loudspeaker, front right Aerial amplifier Radio fuse Fuse, in fuse holder 2-pin connector, at front left treble loudspeaker 2-pin connector, at front right treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at right A pillar (black) 4-pin connector, at left front woofer 4-pin connector, at right front woofer 8-pin connector, at radio (black) 8-pin connector, at radio (brown)

A11 A21 A27 A46 A76

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 06.04 S00.5324.01.20

FABIA

No.70/3

Current Flow Diagram

Radio, rear speakers

ws sw ro br gn bl gr li ge or

J412

- Control unit for telephone operating electronics (interface box) K - Dash panel insert R - Radio R14 - Treble loudspeaker, rear left R15 - Bass loudspeaker, rear left R16 - Treble loudspeaker, rear right R17 - Bass loudspeaker, rear right T2o - 2-pin connector, at rear left treble loudspeaker T2p - 2-pin connector, at rear right treble loudspeaker T2r - 2-pin connector, at rear left bass loudspeaker T2s - 2-pin connector, at rear left bass loudspeaker T2t - 2-pin connector, at rear right bass loudspeaker T2u - 2-pin connector, at rear right bass loudspeaker T4o - 4-pin connector, at left B pillar (black) T4p - 4-pin connector, at right B pillar (black) T8d - 8-pin connector, at radio (black) T8n - 8-pin connector, at radio (brown) T18d - 18-pin connector, at control unit for telephone operating electronics (interface box) T20a - 20-pin connector, at radio

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

T32a - 32-pin connector, at dash panel insert 606

- Earth point, under the centre console, near gear stick

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

- Applies only to models with 8 speakers - Applies only to Symphony radio with CD and large information display in dash panel insert n n n - applies only to models with mobile phone preinstallation 2-Cullmann

*♦

FABIA

Current Flow Diagram

Radio system with CD changer, from August 2003

Edition 06.04 S00.5324.01.20

No.71/1

No.71/2

Current Flow Diagram

FABIA

Radio, front speakers, CD changer, aerial

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

R R11 R20 R21 R24 R41 S92 SB45 T2m T4m T4u T8d T8n T12k T20a

white black red brown green blue grey purple yellow orange

-

Radio Aerial Treble loudspeaker, front left Bass loudspeaker, front left Aerial amplifier CD changer Radio fuse Fuse, in fuse holder 2-pin connector, at front left treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at left front woofer 8-pin connector, at radio (black) 8-pin connector, at radio (brown) 12-pin connector, at CD changer 20-pin connector, at radio

A11 A21 A27 A46 A76

- Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left

Edition 06.04 S00.5324.01.20

FABIA

No.71/3

Current Flow Diagram

Radio, front speakers, CD changer

ws sw ro br gn bl gr li ge or

J412 K R R22 R23 R41 T2n T4n T4v T8d T8n T12k T18d T20a T32a

- Operating electronics/telephone control unit (Interface box) - Dash panel insert - Radio - Treble loudspeaker, front right - Bass loudspeaker, front right - CD changer - 2-pin connector, at front right treble loudspeaker - 4-pin connector, at right A pillar (black) - 4-pin connector, at right front woofer - 8-pin connector, at radio (black) - 8-pin connector, at radio (brown) - 12-pin connector, at CD changer - 18-pin connector, at control unit for telephone operating electronics (interface box) - 20-pin connector, at radio - 32-pin connector, at dash panel insert

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel V14 - Connection (screening), in CD changer wiring loom A146

V45

♦

- Connection -2- (screening), in CD changer wiring harness

- Applies only to Symphony radio with CD and large information display in dash panel insert n n n - applies only to models with mobile phone preinstallation 2-Cullmann

No.71/4

FABIA

Current Flow Diagram

Radio, rear speakers

ws sw ro br gn bl gr li ge or

R R14 R15 R16 R17 T2o T2p T2r T2s T2t T2u T4o T4p T8d T8n

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Radio Treble loudspeaker, rear left Bass loudspeaker, rear left Treble loudspeaker, rear right Bass loudspeaker, rear right 2-pin connector, at rear left treble loudspeaker 2-pin connector, at rear right treble loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear right bass loudspeaker 2-pin connector, at rear right bass loudspeaker 4-pin connector, at left B pillar (black) 4-pin connector, at right B pillar (black) 8-pin connector, at radio (black) 8-pin connector, at radio (brown)

255 606

*

- Earth connection -1-, in wiring loom behind dash panel - Earth point, under the centre console, near gear stick - Applies only to models with 8 speakers

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

Navigation system with CD changer, from August 2003

Edition 06.04 S00.5324.01.20

No.72/1

No.72/2

FABIA

Current Flow Diagram

Navigation system control unit

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

J412 J503 S258 SB45 T8d T18d T20a

white black red brown green blue grey purple yellow orange

- Control unit for telephone operating electronics (interface box) - Navigation system control unit - Fuse for navigation system - Fuse, in fuse holder - 8-pin connector, at navigation system control unit (black) - 18-pin connector, at control unit for telephone operating electronics (interface box) - 20-pin connector, at navigation system control unit

255 606 A11 A21 A27 A46 A76 ===

- Earth connection -1-, in wiring loom behind dash panel - Earth point, under the centre console, near gear stick - Positive connection (58b), in wiring loom behind dash panel - Positive connection (86s), in wiring loom behind dash panel - Connection (vehicle speed signal), in wiring loom behind dash panel - Positive connection (30 - from radio), in wiring loom behind dash panel - Connection (K diagnosis wire), in wiring loom behind dash panel on left - applies only to models with CD changer

n n n - applies only to models with mobile phone

preinstallation 2-Cullmann

Edition 06.04 S00.5324.01.20

FABIA

No.72/3

Current Flow Diagram

Navigation system control unit, front speakers

ws sw ro br gn bl gr li ge or

J503 R20 R21 R22 R23 T2m T2n T4m T4n T4u T4v T8n

-

Navigation system control unit Treble loudspeaker, front left Bass loudspeaker, front left Treble loudspeaker, front right Bass loudspeaker, front right 2-pin connector, at front left treble loudspeaker 2-pin connector, at front right treble loudspeaker 4-pin connector, at left A pillar (black) 4-pin connector, at right A pillar (black) 4-pin connector, at left front woofer 4-pin connector, at right front woofer 8-pin connector, at navigation system control unit (brown)

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

No.72/4

FABIA

Current Flow Diagram

Navigation system control unit, rear speakers

ws sw ro br gn bl gr li ge or

J503 R14 R15 R16 R17 T2o T2p T2r T2s T2t T2u T4o T4p T8n

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Navigation system control unit Treble loudspeaker, rear left Bass loudspeaker, rear left Treble loudspeaker, rear right Bass loudspeaker, rear right 2-pin connector, at rear left treble loudspeaker 2-pin connector, at rear right treble loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear left bass loudspeaker 2-pin connector, at rear right bass loudspeaker 2-pin connector, at rear right bass loudspeaker 4-pin connector, at left B pillar (black) 4-pin connector, at right B pillar (black) 8-pin connector, at navigation system control unit (brown)

*

- Applies only to models with 8 speakers

Edition 06.04 S00.5324.01.20

FABIA

No.72/5

Current Flow Diagram

Navigation system control unit

ws sw ro br gn bl gr li ge or

F4 J104 J503 M16 M17 SB12 T8e T26a T42a

-

Reversing light switch ABS/ABS with EDL and TCS/ESP control unit Navigation system control unit Reversing light bulb left Reversing light bulb right Fuse, in fuse holder Plug connection, 8-pin, at left of bulkhead (orange) 26-pin connector, at navigation system control unit Connector, 42-pin, at ABS/ABS with EDL and TCS/ ESP control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

A70

- Positive connection (15a), in wiring loom behind dash panel B182 - Connection (RF), in interior wiring loom

*

- Does not apply to models with automatic gearbox

No.72/6

Current Flow Diagram

FABIA

Navigation system control unit, Traffic information control unit

ws sw ro br gn bl gr li ge or

J503 J559

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Navigation system control unit - Control unit for traffic information radio, behind the dashboard K - Dash panel insert T12m - 12-pin connetor, at traffic information control unit T26a - 26-pin connector, at navigation system control unit T32a - 32-pin connector, at dash panel insert

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

Edition 06.04 S00.5324.01.20

FABIA

No.72/7

Current Flow Diagram

Navigation system control unit, traffic information control unit, aerial

ws sw ro br gn bl gr li ge or

J503 J559

- Navigation system control unit - Control unit for traffic information radio, behind the dashboard R50 - Navigation aerial (GPS) R51 - Radio/telephone aerial T13b - 13-pin connector, for telephone

Edition 06.04 S00.5324.01.20

* ** ♦

♦♦

-

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

Navigation system aerial cable Radio aerial cable Mobile phone aerial cable on Notchback models R50 is behind dash panel

No.72/8

FABIA

Current Flow Diagram

Navigation system control unit, CD changer

ws sw ro br gn bl gr li ge or

J503 R41 T12k T20a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

Navigation system control unit CD changer 12-pin connector, at CD changer 20-pin connector, at navigation system control unit

V14

- Connection (screening), in CD changer wiring loom

V45

- Connection -2- (screening), in CD changer wiring harness

===

- applies only to models with CD changer

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

CAN-Bus Networking - Convenience, from August 2003

Edition 06.04 S00.5324.01.20

No.73/1

No.73/2

Current Flow Diagram

FABIA

Dash panel insert, Control unit in dash panel insert, Data bus diagnostic interface, Connector for diagnostic connection, Connection for air conditioning system control unit

ws sw ro br gn bl gr li ge or

J285 J301 J533 K T16a

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

-

T16b T16e T18a T18b T32a -

Control unit in dash panel insert AC control unit Databus diagnostic interface Dash panel insert 16-pin connector, at electrical system control unit (black) 16-pin connector, in glove box on driver’s side (diagnosis connection) 16-pin connector, at AC control unit 18-pin connector, at electrical system control unit (brown) 18-pin connector, at electrical system control unit (black) 32-pin connector, at dash panel insert

A76

- Connection (K diagnosis wire), in wiring loom behind dash panel on left A146 - Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel

Edition 06.04 S00.5324.01.20

FABIA

No.73/3

Current Flow Diagram

Connection for: Driver door control unit, Front passenger door control unit, Rear left door control unit

ws sw ro br gn bl gr li ge or

J386 J387 J388 T6l T6n T6o T8h T8i T8j

-

Door control unit, driver’s side Door control unit, passenger’s side Door control unit, rear left 6-pin connector, at left B pillar (blue) Connector, 6-pin, at left A-pillar (blue) 6-pin connector, at right A pillar (blue) Connector, 8-pin, at door control unit, driver side Connector, 8-pin, at door control unit, front passenger side - Connector, 8-pin, at rear left door control unit

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

No.73/4

Current Flow Diagram

FABIA

Connection for: Rear right door control unit, Convenience system central control unit, Radio, Traffic information control unit

ws sw ro br gn bl gr li ge or

J389 J393 J559

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

- Door control unit, rear right - Convenience electrics central control unit - Control unit for traffic information radio, behind the dashboard R - Radio T6m - 6-pin connector, at right B pillar (blue) T8k - Connector, 8-pin, at rear right door control unit T12m - 12-pin connetor, at traffic information control unit T20a - 20-pin connector, at radio T23a - 23-pin connector, at convenience electrics central control unit

- Connection (CAN-H, convenience), in wiring loom behind dash panel A147 - Connection (CAN-L, convenience), in wiring loom behind dash panel A146

Edition 06.04 S00.5324.01.20

FABIA

Current Flow Diagram

Rear reading lights, from August 2003

Edition 06.04 S00.5324.01.20

No.74/1

No.74/2

Current Flow Diagram

FABIA

Rear reading lights (does not apply to Notchback models)

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

J317 M27 M28 SB4 T3c T3y T3z T5a

-

T5b T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Left door warning light Right door warning light Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 5-pin connector, at left C pillar (brown) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

98

- Earth connection, in engine compartment wiring harness 354 - Earth connection, in wiring harness behind dash panel A23 - Positive connection (30al), in wiring loom behind dash panel A29 - Connection (interior light 31), in wiring loom behind dash panel Q150 - Connection (30al), in boot lid/tailgate wiring loom Q151

- Connection (interior light 31), in boot lid/tailgate wiring loom

n n n - Applies only to models with door warning lights

Edition 06.04 S00.5324.01.20

FABIA

No.74/3

Current Flow Diagram

Rear reading lights (applies only to Notchback models)

ws sw ro br gn bl gr li ge or

J317 M27 M28 SB4 T3c T3y T3z T5a

-

T6j

-

W W11 W12 W13 W19

-

Terminal 30 voltage supply relay Left door warning light Right door warning light Fuse, in fuse holder 3-pin connector, at front interior light bulb Plug connection, 3-pin, at left rear reading light Plug connection, 3-pin, at right rear reading light 5-pin connector, at electrical system control unit (black) 6-pin connector, at electrical system control unit (brown) Interior light, front Reading light, rear left Reading light, rear right Front passenger’s reading light Driver-side reading light

Edition 06.04 S00.5324.01.20

= = = = = = = = = =

white black red brown green blue grey purple yellow orange

86

- Earth connection -1-, in rear interior wiring loom

354

- Earth connection, in wiring harness behind dash panel - Positive connection (30al), in wiring loom behind dash panel - Connection (interior light 31), in wiring loom behind dash panel

A23 A29

n n n - Applies only to models with door warning lights

FABIA

Current Flow Diagram

No.75/1

Inspection of the rear seat backrest lock, as of August 2003

Edition 06.04 S00.5324.01.20

No.75/2

Current Flow Diagram

FABIA

Backrest contact switch, Dash panel insert

ws sw ro br gn bl gr li ge or

= = = = = = = = = =

F315 F316 J285 K K193 T2s T2t T16a

white black red brown green blue grey purple yellow orange

-

Left backrest contact switch Right backrest contact switch Control unit in dash panel insert Dash panel insert

Rear seat backrest lock warning lamp

2-pin connector, at left backrest contact switch 2-pin connector, at right backrest contact switch 16-pin connector, at electrical system control unit (black) T18a - 18-pin connector, at electrical system control unit (brown) T32a - 32-pin connector, at dash panel insert

81 86

- Earth connection, in wiring harness behind dash panel - Earth connection -1-, in rear interior wiring loom

- Connection (CAN-H), in wiring loom behind dash panel on A122 - Connection (CAN-L), in wiring loom behind dash panel A121

*♦

- not valid for vehicles with separated backrest - not valid for vehicles without separated backrest

Edition 06.04 S00.5324.01.20

FABIA

No.1/1

Fault Finding Programme

Battery discharges itself Test requirements: ♦ Battery O. K. ♦ Interior lights and all systems are switched off

Possible causes of fault are: ♦ Corroded or contaminated contacts ♦ Chafed cables ♦ Internal closing in the units

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g V.A.G 1594 A ♦ Valid current flow diagram Measure battery discharge rate - Disconnect battery-earth strap. - Set measuring range selector switch of handheld multimeter to current test - Connect handheld multimeter (largest measuring range) to negative terminal and earth strap of battery. - Switch off all electrical components in the vehicle (e.g. radio, interior lights). - Shift down current measuring range until a readable display is carried out. Current max.25 mA.

Current above 25 mA.

▼ Test battery ⇒ Electrical System.

▼ - Interrupt the individual circuits by removing the fuses consecutively. Current drops to max. 25 mA.

Current remains above 25 mA.

▼

▼

Find the cause of fault in the circuit and eliminate it.

If no fault is found at secured circuits, disconnect cables to not secured units: Alternator, starter…- carry out fault finding according to current flow diagram.

End of fault finding program

Edition 07.03 S00.5324.00.20

FABIA

Fault Finding Programme

No.2/1

Starter cannot rotate Test requirements: ♦ Battery O. K. ♦ Cable connections at solenoid switch and earth strap between battery/body as well as between body/ gearbox must be tight and must not be oxidized.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g V.A.G 1594 A ♦ Valid current flow diagram

1 - Terminal 30, from battery 2 - Terminal 50, from ignition starter switch 3 - Connection for field winding

Continued on next page!

Edition 07.03 S00.5324.00.20

No.2/2

FABIA

Fault Finding Programme

Check voltage supply (terminal 50) of solenoid switch -

Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Connect red measuring tip to terminal 50 of solenoid switch. Connect black measuring tip to the body mass. Shift ignition lock into position 3 “Start engine”. Readout approx. battery voltage.

No voltage or smaller than 8 V.

▼

A

▼ Check voltage supply at field winding connection - Connect red measuring tip at field winding connection. - Connect black measuring tip to the body mass. - Shift ignition lock into position 3 “Start engine”. Readout approx. battery voltage.

No voltage or smaller than 8 V.

▼

▼

Starter defective, replace.

Solenoid switch defective, replace.

A ▼ Check voltage supply (terminal 50b) at ignition starter switch - Connect red measuring tip to terminal 50b of ignition starter switch. - Connect black measuring tip to the body mass. - Shift ignition lock into position 3 “Start engine”. Readout approx. battery voltage.

No voltage or smaller than 8 V.

▼

▼

Wirings between ignition starter switch and starter are defective, replace.

Ignition starter switch is defective, replace.

End of fault finding program

Edition 07.03 S00.5324.00.20

FABIA

No.3/1

Fault Finding Programme

Windshield wiper system faulty Test requirements: ♦ Fuse SB 15 (10 A) and SB 41 (20 A) O.K. ♦ Battery voltage O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for windscreen wiper motor -V- Set measuring range selector switch of handheld multimeter e.g. V.A.G 1526 A, to 20 DC voltage. - Switch on ignition. - Connect handheld multimeter with measuring aid set e.g. V.A.G 1594 A with black measuring tip to contact 4 and with red measuring tip to contact 2 of T4a connector at windscreen wiper motor. - Switch lever of windscreen wiper switch into wiper stage 1, measure voltage. - Connect handheld multimeter with red measuring tip to contact 1 of T4a connector at windscreen wiper motor. - Switch lever of windscreen wiper switch into wiper stage 2, measure voltage. Readout approx. battery voltage.

No voltage or smaller than 8 V.

▼ Windscreen wiper motor defective, replace.

▼ Check voltage supply of intermittent wiper switch -E22-

Switch off ignition. Remove steering column trim panel. Disconnect -T8b- connector from windscreen wiper switch. Connect handheld multimeter with measuring aid set e.g. V.A.G 1594 A with black measuring tip to contact 2 of T8b connector and with red measuring tip to contact 8 of T8b connector. - Switch on ignition. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Wiring to windscreen wiper switch defective, repair according to current flow diagram.

▼

A

Edition 07.03 S00.5324.00.20

No.3/2

FABIA

Fault Finding Programme

A ▼ Check intermittent wiper switch -E22-

Switch off ignition. Place -T8b- connector on windscreen wiper switch. Switch lever of windscreen wiper switch into wiper stage 1. Connect red measuring tip to contact 1/53 of T8b connector. Switch on ignition. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Windscreen wiper switch defective, replace.

▼ - Switch lever of windscreen wiper switch into wiper stage 2. - Connect red measuring tip to contact 6/53b of T8b connector. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Windscreen wiper switch defective, replace.

▼ Check the castor of the windscreen -V- wiper motor - Switch off ignition. - Set measuring range selector switch of handheld multimeter e.g. V.A.G 1526 A, electrical continuity test - Put the windscreen wiper in end position by briefly actuating the windscreen wiper switch - Lever of windscreen wiper switch in position “switch off“. - Connect red measuring tip to contact 3/31b of T4a connector. - Connect black measuring tip to contact 4/31 of T4a connector. No continuity.

Continuity.

▼

▼

Windscreen wiper motor -V- defective, replace.

Wiring from windscreen wiper motor to onboard supply control unit defective, repair according to current flow diagram.

END

Edition 07.03 S00.5324.00.20

FABIA

No.4/1

Fault Finding Programme

Windscreen washer system defective Test requirements: ♦ Fuse SB 15 (10 A) O.K. ♦ Battery voltage O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for windscreen and rear window washer pump -V59-

Switch off ignition. Disconnect T2a connector from the windscreen and rear window washer pump V59. Switch on ignition. Connect measuring tips at connector Pull lever of windscreen wiper switch in direction of steering wheel. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Windscreen and rear window washer pump V59- defective, replace.

▼ -

Switch off ignition. Place T2a connector on the windscreen and rear window washer pump -V59-. Remove steering column trim panel. Disconnect -T8b- connector from windscreen wiper switch. Switch on ignition. Connect red measuring tip to contact 8 (53a) of -T8b- connector at wiring harness. Connect black measuring tip to contact 2 (31) of -T8b- connector at wiring harness. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Wiring from fuse holder to windscreen wiper switch defective, repair.

▼

A

Edition 07.03 S00.5324.00.20

No.4/2

FABIA

Fault Finding Programme

A ▼ Check windscreen washing function -

Switch off ignition. Connect -T8b- connector at windscreen wiper switch. Switch on ignition. Connect red measuring tip to contact 4 (53c) of -T8b- connector of windscreen wiper motor. Connect black measuring tip to contact 5 (HW) of -T8b- connector of windscreen wiper switch. Pull lever of windscreen wiper switch in direction of steering wheel. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Windscreen wiper switch defective, replace.

▼ Check rear window washing function -

Switch off ignition. Connect red measuring tip to contact 4 (53c) of -T8b- connector of windscreen wiper motor. Connect black measuring tip to contact 5 (HW) of -T8b- connector of windscreen wiper switch. Switch on ignition. Push lever of windscreen wiper switch into 2nd position away from steering wheel and hold. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼

▼

Windscreen wiper switch defective, replace.

Wirings from T8b/4 and T8b/5 to windscreen and rear window washer pump defective, repair.

END

Edition 07.03 S00.5324.00.20

FABIA

No.5/1

Fault Finding Programme

Intermittent wiper defective Test requirements: ♦ Check voltage supply of windscreen wiper motor -V- and windscreen wiper switch -E22- according to fault finding program No. 3. ♦ The engine hood must be closed on vehicles fitted with alarm system. ♦ Battery voltage O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check windscreen wiper switch -E22-

Switch off ignition. Remove steering column trim panel. Disconnect -T8b- connector from windscreen wiper switch. Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Connect handheld multimeter with measuring aid set e.g. V.A.G 1594 A with black measuring tip to vehicle mass and red measuring tip to contact 7 of T8b connector. - Switch on ignition. - Switch lever of windscreen wiper switch into wiper stage “interval“. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Windscreen wiper switch defective, replace.

▼ Check intermittent wiper regulator -E38-

Switch off ignition. Place -T8b- connector on windscreen wiper switch. Disconnect -T6a- connector from windscreen wiper switch. Set measuring range selector switch of handheld multimeter to electrical continuity test. Connect red measuring tip to contact 5 of T6a connector. Connect black measuring tip to contact 7 of T8b connector. Connect red measuring tip to contact 6 of T6a connector. Connect black measuring tip to contact 18 of T18a connector Each time continuity.

At least once no continuity.

▼

▼

Intermittent wiper regulator -E38- defective, replace.

Wiring from windscreen wiper switch to onboard supply control unit defective, repair according to current flow diagram.

END

Edition 07.03 S00.5324.00.20

FABIA

No.6/1

Fault Finding Programme

Check rear window wiper Test requirements: ♦ Check voltage supply for windscreen wiper switch -E22- according to fault finding program No. 3. ♦ Fuses SB 15 (10 A), SB 32 (10 A) and SB 41 (20 A) O. K.

For fault finding the following is required: ♦ Handheld multimeter V.A.G 1526 ♦ Measuring aid set V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for rear window wiper motor (V12) -

Remove trim panel for rear panel flap ⇒ Body Work. Set measuring range selector switch of handheld multimeter e.g. V.A.G 1526 A to 20 V DC voltage Disconnect T4b connector from rear window wiper motor. Connect red measuring tip to contact 4 (15) of T4b connector. Connect black measuring tip to contact 1 (31) of T4b connector. Switch on ignition. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Test wiring according to current flow diagram, repair.

▼ Check windscreen wiper switch (E22) (intermittent) -

Switch off ignition. Set measuring range selector switch of handheld multimeter to electrical continuity test. Connect red measuring tip to contact 2 of T4b connector. Connect black measuring tip to contact 1 of T4b connector. Switch windscreen wiper switch into switch position “interval wiping for rear wiper“. No continuity.

Continuity.

▼ Windscreen wiper switch or wiring to rear window wiper motor defective.

▼

A

Edition 07.03 S00.5324.00.20

No.6/2

FABIA

Fault Finding Programme

A ▼ Check windscreen wiper switch (E22) (wipe-wash mode) -

Set measuring range selector switch of handheld multimeter e.g. V.A.G 1526 A to 20 V DC voltage Connect red measuring tip to contact 3 of T4b connector. Connect black measuring tip to contact 1 of T4b connector. Switch on ignition. Press windscreen wiper switch into switch position “wipe-wash mode for rear wiper“ and hold. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼

▼

Intermittent wiper switch (E22) defective or wiring to rear window wiper motor defective.

Rear window wiper motor -V12- defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.7/1

Fault Finding Programme

Heated rear window without function Test requirements: ♦ Fuse SB 39 (20 A) O.K. ♦ Battery voltage O.K. ♦ No other electrical component such as auxiliary heater element or seat heating is switched on.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check heated rear window button -E230-

Disconnect T6b connector from button -E230-. Set measuring range selector switch of handheld multimeter to electrical continuity test. Connect red measuring tip to contact 3 of push-button. Connect black measuring tip to contact 4 of push-button. Actuate button and hold pressed down. Continuity.

No continuity.

▼ Heated rear window button -E230- defective, replace.

▼ -

Place T6b connector on button -E230-. Connect red measuring tip to white supply line of heated rear window. Connect black measuring tip to the brown supply line of the heated rear window. Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Start engine and run at idling speed Switch on heated rear window. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼

▼

Test wiring from heated rear window button -E230- to onboard supply control unit, or from onboard supply control unit to heated rear window -Z1- defective, repair, earth cable to -Z1-. If all is O.K. then the onboard supply control unit is defective

Heated rear window -Z1- defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.8/1

Fault Finding Programme

Check fresh air blower Test requirements: ♦ Fuse SB 68 (25 A) O.K. ♦ Battery voltage O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for fresh air blower -V2-

Switch off ignition. Remove heater control. Disconnect T5h connector from fresh air blower switch -E9-. Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Connect red measuring tip to contact 5 of T5h connector at wiring harness. Connect black measuring tip to the vehicle mass. Switch on ignition. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Wiring between fresh air blower switch -E9and fuse SB 68 defective, repair.

▼ Check fresh air blower -E9-

Switch off ignition. Place T5h connector on fresh air blower switch -E9-. Connect black measuring tip to the vehicle mass. Switch on ignition. Connect red measuring tip to contact 4 of T5h connector and position fresh-air blower switch on speed 1. Read off voltage. - Connect red measuring tip to contact 3 of T5h connector and position fresh-air blower switch on speed 2. Read off voltage. - Connect red measuring tip to contact 2 of T5h connector and position fresh-air blower switch on speed 3. Read off voltage. - Connect red measuring tip to contact 1 of T5h connector and position fresh-air blower switch on speed 4. Read off voltage. Voltage is at least once not available or smaller than 8 V.

Readout approx. battery voltage

▼ Fresh air blower -E9- defective, replace.

▼

A Edition 07.03 S00.5324.00.20

No.8/2

FABIA

Fault Finding Programme

A ▼ Check fresh air blower motor -V2-

Disconnect T2u connector from the fresh air blower motor -V2-. Connect red measuring tip to contact 1 of T2u connector. Connect black measuring tip to contact 2 of T2u connector Switch fresh-air blower switch consecutively into all four positions. Read off the respective measuring result. Different voltages exist individually.

Voltage at least does not exist once.

▼

▼

Fresh air blower motor -V2- defective, replace.

Test wiring to fresh air blower series resistor -N24-, or fresh air blower series resistor -N24- defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.9/1

Fault Finding Programme

Check fresh air/recirculated air flap control motor Test requirements: ♦ Fuse SB 12 (5 A) O.K. ♦ Battery voltage O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for fresh air/recirculated air flap control motor -V154-

Switch off ignition. Remove heater control. Disconnect T16c connector from heater control. Set measuring range switch of handheld multimeter to 20 V DC voltage. Connect red measuring tip to contact 14 of T16c connector at wiring harness. Connect black measuring tip to contact 13 of T16c connector at wiring harness. Switch on ignition. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Inspect wirings to fuse SB 12 and to vehicle mass according to current flow diagram.

▼ Check fresh air/air recirculating flap switch -E159- with fresh/recirculating air flap control unit -J251-

Switch off ignition. Place T16c connector on the heater control. Connect red measuring tip to contact 9 of T16c connector at wiring harness. Connect black measuring tip to contact 12 of T16c connector at wiring harness. Switch on ignition. Actuate fresh air/air recirculating flap switch -E159-. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼

▼

Fresh air/air recirculating flap switch -E159or fresh/recirculating air flap control unit -J251- defective, replace.

Fresh air/recirculated air flap control motor -V154- defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.10/1

Fault Finding Programme

Check auxiliary heater element (PTC) -Z35Test requirements: ♦ Fuses S276, S277, S278 (40 A) O.K. ♦ Battery voltage O.K. ♦ All electrical components such as heated rear window, light or seat heating are switched off ♦ Coolant temperature below 70 °C ♦ Temperature control to max.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram

Check voltage supply for auxiliary heater element -Z35-

Disconnect high heat output relay -J360- from relay carrier, plug location 9 Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Connect red measuring tip to contact 1/30 relay plug location. Connect black measuring tip to the vehicle mass. Voltage not available or smaller than 8 V

Readout approx. battery voltage

▼ Inspect wiring to wiring junction TV2 terminal 3 according to current flow diagram.

▼ Check high heat output relay -J360- Position high heat output relay -J360- onto relay holder, plug location 9. - Connect a measuring adapter cable to contact 4/85 of relay plug location 9 and vehicle mass. Relay does not click.

Relay clicks.

▼ High heat output relay -J360- defective, replace.

▼

A

Edition 07.03 S00.5324.00.20

No.10/2

FABIA

Fault Finding Programme

A ▼ Check low heat output relay -J359- Connect a measuring adapter cable to contact 6/85 of relay plug location 8 and vehicle mass. Relay does not click.

Relay clicks.

▼ Low heat output relay -J359- defective, replace.

▼ Test wiring for auxiliary heater element -Z35- Set measuring range selector switch of handheld multimeter to electrical continuity test. - Connect red measuring tip to contact 2/87 of relay location plug 9 and black measuring tip to contact 3 of T3n connector. - Connect red measuring tip to contact 2/87 of relay location plug 9 and black measuring tip to contact 2 of T3n connector. - Connect red measuring tip to contact 8/87 of relay location plug 8 and black measuring tip to contact 1 of T3n connector. At least once no continuity.

Each time continuity

▼ Test wiring from relay holder to auxiliary heater element -Z35- according to current flow diagram.

▼ Check heater element contact switch (PTC) -F268- (only for vehicles without air conditioning system) -

Set temperature control to min. Remove heater control and disconnect connector T16c. Connect red measuring tip to contact 3 of T16c plug at heater control. Connect black measuring tip to contact 13 of T16c plug at heater control. No continuity.

Continuity.

▼

▼

Heater element contact switch (PTC) -F268- defective, replace.

Auxiliary heater element -Z35- defective, replace.

▼ Continues for vehicles fitted with air conditioning system

▼

B

Edition 07.03 S00.5324.00.20

FABIA

No.10/3

Fault Finding Programme

B ▼ Check temperature selection rotary knob potentiometer -G267- (only for vehicles fitted with air conditioning system) - Set temperature control to max. - Initiate self-diagnosis for air conditioning system, read measured value block, heating element for PTC. - Heating element for PTC must be switched on. Readout in Display: off.

Readout in display: on.

▼

▼

Air conditioning system control unit -J301defective, replace.

Auxiliary heater element -Z35- defective, replace or engine control unit defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.11/1

Fault Finding Programme

Electrically adjustable and heated exterior mirror (without power windows) Test requirements: ♦ Battery O. K. ♦ Fuses SB 11 and SB 38 O.K. ♦ Remove mirror adjustment switch ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A Note: If the specified values are not achieved, eliminate line interruption according to current flow diagram or replace mirror.

Test step 1

Tested is

Test conditions

Specified value

Fault finding

Current supply at switch

Ignition on

approx. 12 V

Line interruption

2

red measuring tip to -T10f- switch plug, contact 5 black measuring tip to -T10fswitch plug, contact 3

Switch functions for left mirror

-

Left switch position Ignition on

-

-

approx. red measuring tip to -T10f-, con12 V tact 2 black measuring tip to -T10f-, contact 10

Switch defective

approx. red measuring tip to -T10f-, con12 V tact 10 black measuring tip to -T10f-, contact 2

Switch defective

approx. red measuring tip to -T10f-, con12 V tact 10 black measuring tip to -T10f-, contact 7

Switch defective

approx. red measuring tip to -T10f-, con12 V tact 7 black measuring tip to -T10f-, contact 10

Switch defective

to the top

-

-

to the bottom

-

-

to the left

-

-

to the right

-

Edition 07.03 S00.5324.00.20

No.11/2

Test step 3

Tested is

Test conditions

Fault finding

Right switch position Ignition on

-

red measuring tip to -T10f-, conapprox. tact 2 12 V black measuring tip to -T10f-, contact 6

Switch defective

red measuring tip to -T10f-, conapprox. tact 6 12 V black measuring tip to -T10f-, contact 2

Switch defective

red measuring tip to -T10f-, conapprox. tact 9 12 V black measuring tip to -T10f-, contact 6

Switch defective

red measuring tip to -T10f-, conapprox. tact 6 12 V black measuring tip to -T10f-, contact 9

Switch defective

-

to the top

-

to the bottom

-

-

to the left

-

-

to the right

-

Current supply for mirror heating

-

5

Specified value

Switch functions for right mirror

-

4

FABIA

Fault Finding Programme

Mirror heating (in cold condition)

-

-

Ignition on Mirror adjustment switch in position “heated” Remove mirror glass disconnect both plugs connect red terminal to a connection cable connect black terminal to the other connection cable

approx. 12 V

3-6Ω Set measuring range selector switch of handheld multimeter to resistance measurement Mirror glass removed connect red terminal to a connection cable connect black terminal to the other connection plug at the mirror glass

-

Mirror adjustment switch defective Line interruption of mirror heating defective

Mirror heating defective, replace mirror glass

Edition 07.03 S00.5324.00.20

FABIA

No.12/1

Fault Finding Programme

Test electrical sliding roof Test requirements: ♦ Battery voltage O.K. ♦ Fuses SB 62 O.K.! ♦ Electrical sliding roof mechanically O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Note: The sliding sunroof adjustment control unit (J245) and the motor for the sliding roof (V1) are combined in one component and cannot be replaced individually.

Check voltage supply (terminal 30) for sliding sunroof adjustment control unit (J245) -

Remove sunroof and interior light switch Set measuring range switch of handheld multimeter to 20 V DC voltage. Disconnect -T6e- connector at sliding roof adjustment control unit (J245). Connect red measuring tip to contact 4 and black measuring tip to contact 1 of -T6e- connector. Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼ Check voltage supply (terminal 15) for sliding sunroof adjustment control unit (J245) - Switch on ignition. - Connect red measuring tip to contact 2 and black measuring tip to contact 1 of -T6e- connector. Voltage N.O.K..

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼

A

Edition 07.03 S00.5324.00.20

No.12/2

FABIA

Fault Finding Programme

A ▼ Check voltage supply for sliding sunroof adjustment regulator (E139) - Connect -T6e- connector at sliding roof adjustment control unit (J245). - Disconnect -T6f- connector at sliding roof adjustment regulator (E139). - Connect red measuring tip to contact 1 and black measuring tip to vehicle mass. Specified value: approx. 5 V. Voltage N.O.K..

Voltage O.K.

▼ Sliding sunroof adjustment control unit (J245) defective, replace.

▼ Check sliding sunroof adjustment regulator (E139) - Switch off ignition. - Set measuring range switch of handheld multimeter to resistance measurement. - Connect red measuring tip to contact 3 and black measuring tip to contact 1 at sliding sunroof adjustment regulator (E139). - Set sliding sunroof adjustment regulator to the maximum open position of the sliding roof Specified value: 200 W - Set sliding sunroof adjustment regulator to the maximum lifting position of the sliding roof Specified value: The resistance must increase equally. When reaching the maximum lifting position of the sliding roof: 2600 W Specified values N.O.K.

Specified values O.K.

▼ Sliding sunroof adjustment regulator (E139) defective, replace.

▼ - Connect red measuring tip to contact 3 and black measuring tip to contact 2 at sliding sunroof adjustment regulator (E139). - Set sliding sunroof adjustment regulator to the maximum open position of the sliding roof Specified value: 2600 W - Set regulator for adjusting the sliding roof in stages to the maximum lifting position of the sliding roof Specified value: The resistance must decrease equally. When reaching the maximum lifting position of the sliding roof: 200 Ω Specified values N.O.K.

Specified values O.K.

▼ Sliding sunroof adjustment regulator (E139) defective, replace.

▼

B

Edition 07.03 S00.5324.00.20

FABIA

No.12/3

Fault Finding Programme

B ▼ Test wiring in sliding sunroof adjustment regulator (E139) - Set measuring range switch of handheld multimeter to electrical continuity test. - Connect red measuring tip to contact 6 and black measuring tip to contact 2 at sliding sunroof adjustment regulator (E139). Signal does not sound.

Signal sounds.

▼

▼

Sliding sunroof adjustment regulator (E139) defective, replace.

Sliding sunroof adjustment control unit (J245) defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

No.13/1

Fault Finding Programme

Check seat heating Test requirements: ♦ Fuse SB63 (15 A) O.K.

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g V.A.G 1594 A ♦ Valid current flow diagram Note: The following fault finding program describes the fault finding for the driver side. In case of defective front passenger seat heating proceed analogously.

Left seat heating without or with defective function Check voltage supply for heated driver seat control unit (J131) -

Set measuring range selector switch of handheld multimeter to 20 V DC voltage. Disconnect T8I connector from heated driver seat control unit (J131) (under driver seat). Connect red measuring tip to contact 5 of T8l connector. Connect black measuring tip to the vehicle mass. Switch on ignition. Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram.

▼ Check earth distribution for heated driver seat control unit (J131) - Connect black measuring tip to contact 4 of T8l connector. Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram.

▼

A

Edition 07.03 S00.5324.00.20

No.13/2

FABIA

Fault Finding Programme

A ▼ Check voltage supply for left electrical seat heating regulator (E94) -

Switch off ignition. Place T8I connector on heated driver seat control unit (J131) Remove electrical seat heating regulator ⇒ Electrical System. Disconnect T6h connector from electrical seat heating regulator. Connect red measuring tip to contact 6 of T6h connector. Connect black measuring tip to the vehicle mass. Switch on ignition. Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼ Check earth distribution for left electrical seat heating regulator (E94) - Connect black measuring tip to contact 4 of T6h connector. Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼ Check left electrical seat heating regulator (E94) - Connect electrical seat heating regulator to T6h connector. - Connect red measuring tip to contact 5 of T6h connector. - Carry out voltage tests according to the table: Left seat heating regulator in switch position:

Measuring results:

Lowest heat output

Readout approx. battery voltage

Full heat output

Readout approx. 9 V

Seat heating off

Readout no voltage

Measuring results N.O.K.

Measuring results O.K.

▼ Left electrical seat heating regulator (E94) defective, replace.

▼

B

Edition 07.03 S00.5324.00.20

FABIA

No.13/3

Fault Finding Programme

B ▼ Test wiring for the illumination of the left electrical seat heating regulator (E94). - Connect red measuring tip to contact 3 of T6h connector. - Switch on light, set dimmer of instrument panel illumination to bright. Readout approx. battery voltage.

Voltage N.O.K.

▼

▼

If there was nevertheless a problem with the function of the lighting in the regulator, then left seat heating regulator (E94) is defective, replace

Test wirings according to current flow diagram.

▼ Test wiring from left electrical seat heating regulator (E94) to heated driver seat control unit -

Switch off ignition. Disconnect T8I connector from heated driver seat control unit (J131), Disconnect T6h connector from electrical seat heating regulator. Set measuring range selector switch of handheld multimeter to electrical continuity test. Connect red measuring tip to contact 5 of T6h connector. Connect black measuring tip to contact 6 of T8l connector. Signal does not sound.

Signal sounds.

▼ Inspect wirings according to current flow diagram.

▼ Check heater element of left seat surface (Z6) -

T2e connector, disconnect under driver seat Set measuring range selector switch of handheld multimeter to resistance measurement Connect red measuring tip to contact 7 of T8l connector. Connect black measuring tip to contact 2 of T2e connector. Specified value approx. 1.2 Ω. Specified value is not achieved.

Specified value is achieved.

▼ Heater element of left seat surface (Z6) defective, replace.

▼

C

Edition 07.03 S00.5324.00.20

No.13/4

FABIA

Fault Finding Programme

C ▼ Test driver seat backrest heating element (Z7) - Connect red measuring tip to contact 2 of T2e connector. - Connect black measuring tip to contact 1 of T2e connector. - Specified value approx. 1.2 Ω. Specified value is not achieved.

Specified value is achieved.

▼ Driver seat backrest heating element (Z7) faulty, replace.

▼ Test wiring of heater elements to vehicle mass - Set measuring range selector switch of handheld multimeter to electrical continuity test. - Connect red measuring tip to contact 1 of T2e connector. - Connect black measuring tip to the vehicle mass. Signal does not sound.

Signal sounds.

▼ Inspect wirings according to current flow diagram.

▼ Check temperature sensor (G59) of left seat heating -

Set measuring range selector switch of handheld multimeter to resistance measurement Connect red measuring tip to contact 4 of T8l connector. Connect black measuring tip to contact 2 of T6g connector. Specified value approx. 10 kΩ at 20 °C interior temperature. Specified value is not achieved.

Specified value is achieved.

▼ Temperature sensor (G59) of left seat heating defective, replace together with heater element of left seat surface (Z6).

▼ Test wiring from temperature sensor (G59) of left seat heating to vehicle mass. - Set measuring range selector switch of handheld multimeter to electrical continuity test. - Connect red measuring tip to contact 4 of T8l connector. - Connect black measuring tip to the vehicle mass. Signal does not sound.

Signal sounds.

▼

▼

Inspect wirings according to current flow diagram.

Heated driver seat defective, replace.

END Edition 07.03 S00.5324.00.20

FABIA

No.14/1

Fault Finding Programme

Check headlight washer system Test requirements: ♦ Battery voltage O.K. ♦ Fuse SB 64 O.K.! ♦ Function of dipped beam O.K.! ♦ Function of windcreen wiper and wash system O.K.!

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply (terminal 30) for headlight washer system relay (J39) - Disconnect headlight washer system relay (J39) from relay carrier. - Set measuring range switch of handheld multimeter to 20 V DC voltage. - Connect red measuring tip to contact 2/30 and black measuring tip to contact 4/86 of relay position for (J39). Voltage N.O.K.

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼ Check voltage supply for headlight washer system relay (J39) through switched on main beam - Switch on dipped beam. - Switch on ignition. - Connect red measuring tip to contact 6/85 and black measuring tip to contact 4/86 of relay position for (J39). - Switch on windscreen wiper and washing function for the windscreen and hold. Voltage O.K.

Voltage N.O.K.

▼ Test wiring according to current flow diagram, repair or onboard supply control unit (J519) defective, replace.

▼

A

Edition 07.03 S00.5324.00.20

No.14/2

FABIA

Fault Finding Programme

A ▼ Check voltage supply for headlight washer system pump (V11) - Disconnect T2g connector from the headlight washer system pump (V11). - Connect red measuring tip to contact 2 and black measuring tip to contact 1 of -T2g- connector. - Switch on windscreen wiper and washing function for the windscreen and hold, at the same time read off measuring result at handheld multimeter. Specified values N.O.K.

Specified values O.K.

▼

▼

Check earth connection of headlight washer system pump (V11) according to current flow diagram. If no fault can be found, then replace the headlight washer system relay (J39).

Replace headlight washer system pump (V11).

END

Edition 07.03 S00.5324.00.20

FABIA

No.15/1

Fault Finding Programme

Check warning concerning bulb failure Test requirements: ♦ Battery voltage O.K. ♦ Fuses according to Current Flow Diagram O.K.! ♦ Light bulbs for main beam, tail light and brake light O.K.!

For fault finding the following is required: ♦ Handheld multimeter, e.g. V.A.G 1526 A ♦ Measuring aid set, e.g. V.A.G 1594 A ♦ Valid current flow diagram Check voltage supply for bulb failure control unit (J571) - Set measuring range switch of handheld multimeter to 20 V DC voltage. - Disconnect warning lamp for bulb failure control unit (J571) from relay plug location 13/14. - Connect red measuring tip to contact 1/15 and black measuring tip to contact 2/31 of relay position for (J571). - Switch on ignition. Voltage N.O.K..

Voltage O.K.

▼ Test wiring according to current flow diagram, repair.

▼ Check output for left and right tail light - Switch on side light. - Connect a measuring adapter cable to contact 10/58R and contact 12/58R of relay plug location 13/14. - Connect a measuring adapter cable to contact 18/58L and contact 17/58L of relay plug location 13/14. Tail light does not light up.

Tail light lights up.

▼ Test wiring according to current flow diagram, repair.

▼

A

Edition 07.03 S00.5324.00.20

No.15/2

FABIA

Fault Finding Programme

A ▼ Check output for left and right dipped beam - Switch on ignition. - Switch on dipped beam. - Connect a measuring adapter cable to contact 14/56bR and contact 15/56bR of relay plug location 13/14. - Connect a measuring adapter cable to contact 11/56bL and contact 13/56bL of relay plug location 13/14. Dipped beam does not light up.

Dipped beam lights up.

▼ Test wiring according to current flow diagram, repair.

▼ Check output for left and right brake light - Switch off ignition. - Actuate the brake pedal. - Connect a measuring adapter cable to contact 5/54 and consecutively to contact 8/54L and 4/54R of relay plug location 13/14. Brake light does not light up.

Brake light lights up.

▼ Test wiring according to current flow diagram, repair.

▼ Check output for high mounted brake light - Actuate the brake pedal. - Connect a measuring adapter cable to contact 7/54 and contact 16/54H of relay plug location 13/14. High mounted brake light does not light up.

High mounted brake light lights up.

▼ Test wiring according to current flow diagram, repair.

▼

B

Edition 07.03 S00.5324.00.20

FABIA

No.15/3

Fault Finding Programme

B ▼ Check connection between bulb failure control unit (J571) and dash panel insert (K) - Set measuring range selector switch of handheld multimeter to electrical continuity test. - Disconnect T32a connector from dash panel insert (K). - Connect red measuring tip to contact 9/KS and black measuring tip to contact 29 of T32a connector. Signal does not sound.

Signal sounds.

▼ Test wiring according to current flow diagram, repair.

▼ - Connect red measuring tip to contact 3/KB and black measuring tip to contact 13 of T32a connector. Signal does not sound.

Signal sounds.

▼ Test wiring according to current flow diagram, repair.

▼ Check warning light for bulb failure -

Place T32a connector on dash panel insert (K). Switch on ignition. Connect a measuring adapter cable to contact 9/KS and contact 2/31 of relay plug location 13/14. Connect a second measuring adapter cable to contact 3/KB and contact 2/31 of relay plug location 13/14. Bulb failure warning lamp lights up.

Bulb failure warning lamp does not light up.

▼

▼

Dash panel insert (K) defective, replace.

Bulb failure control unit defective, replace.

END

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.1/1

Fuse Holder, Fuse holder on battery, Relay holder, Additional fuse holder Contents overview -

Fuse holder 08.02 ä 07.03 ....................................................................................................................... 1/2

-

Fuse holder 08.03 ä ................................................................................................................................. 1/4

-

Fuse holder on battery 08.02 ä 07.03 ...................................................................................................... 1/6

-

Fuse holder on battery 08.03 ä ................................................................................................................ 1/7

-

Relay holder 08.02 ä 07.03 ...................................................................................................................... 1/8

-

Relay holder 08.03 ä................................................................................................................................ 1/9

-

Additional fuse holder 08.02 ä 10.02 ....................................................................................................... 1/10

-

Additional fuse holder 11.02 ä ................................................................................................................. 1/10

Edition 06.04 S00.5324.01.20

No.1/2

FABIA

Fitting Locations

Fuse holder - Fuse assignment 08.02 ä 07.03

The fuse protection for the unlisted optional equipment is listed in the corresponding current flow diagram. 1 -

Dash panel insert, ESP

5A

13 -

Reversing lights

10 A

2 -

Brake lights

10 A

14 -

Engine control unit

10 A

3 -

Voltage supply diagnosis, Air conditioning system

5A

15 -

Wiper and washer system

10 A

4 -

Interior light, Glove box light, Luggage compartment light

10 A

16 -

Dash panel insert

5 -

Door warning lamp (up to 10.02) Not assigned (as of 11.02)

5A

17 -

Engine control unit Engine control unit for 1.2/40 kW, 1.2/47 kW

6 -

Headlight range control

5A

18 -

Telephone

7 -

Engine electronics, Power assisted steering

5A

19 -

Automatic gearbox

8 -

not assigned

20 -

Bulb failure warning lamp

5A

9 -

Lambda probe

10 A

21 -

Heated washer nozzles

5A

10 -

S contact (86s)

5A

22 -

not assigned

11 -

Heated and adjustable exterior mirrors

5A

23 -

Right main beam

10 A

12 -

Fresh and recirculated air flap, Air conditioning system, Navigation system, Telephone, Gas discharge lamps

5A

24 -

Engine electronics

10 A

5A 5A 15 A 5A 10 A

Edition 06.04 S00.5324.01.20

FABIA

25 -

ABS/TCS control unit ABS/ESP control unit

26 -

No.1/3

Fitting Locations

5A 10 A

47 -

not assigned

not assigned

48 -

Engine control unit

30 A

27 -

not assigned

49 -

Central locking

15 A

28 -

Brake pedal switch, Clutch pedal switch, Engine electronics

5A

50 -

Right main beam / right gas discharge lamp, right headlight range control

15 A

29 -

Engine control unit

5A

51 -

Socket in luggage compartment

15 A

30 -

Left main beam, main beam warning lamp

10 A

52 -

Petrol engine - ignition system

15 A

31 -

Rear lid central locking

10 A

53 -

Power windows

25 A

32 -

Rear window wiper

10 A

54 -

Left main beam / left gas discharge lamp, left headlight range control

15 A

33 -

Right parking light

5A

55 -

not assigned

34 -

Left side light

5A

56 -

Engine control unit

20 A

35 -

Petrol engine - injection valves

10 A

57 -

Trailer coupling

25 A

36 -

Number plate light

5A

58 -

Power windows

25 A

37 -

Rear fog light, rear fog light warning lamp

7,5 A

59 -

not assigned

38 -

Heated and adjustable exterior mirror

5A

60 -

Anti-theft alarm system

15 A

39 -

Rear window heater

20 A

61 -

Fuel pump

15 A

40 -

Horn

20 A

62 -

Sliding roof

25 A

41 -

Windscreen wiper

20 A

63 -

Seat heatings

15 A

42 -

Socket

15 A

64 -

Headlight washer system

20 A

43 -

Onboard supply control unit, Selectorlever lock

20 A

65 -

Fog light

15 A

44 -

Flashing lights

15 A

66 -

Power windows

25 A

45 -

Radio, Navigation system

20 A

67 -

not assigned

46 -

Power windows

25 A

68 -

Fresh air blower

Fuse colours 30 A

- green

10 A

- red

25 A

- white

7.5 A

- brown

20 A

- yellow

5A

- beige

15 A

- blue

Edition 06.04 S00.5324.01.20

25 A

No.1/4

FABIA

Fitting Locations

Fuse holder - Fuse assignment 08.03 ä

The fuse protection for the unlisted optional equipment is listed in the corresponding current flow diagram. 1 -

Dash panel insert, ESP

5A

13 -

Reversing lights

10 A

2 -

Brake lights

10 A

14 -

Engine control unit

10 A

3 -

Voltage supply diagnosis, Air conditioning system

5A

15 -

Wiper and washer system

10 A

4 -

Interior light, Glove box light, Luggage compartment light

10 A

16 -

Dash panel insert

5 -

not assigned

17 -

Engine control unit Engine control unit for 1.2/40 kW, 1.2/47 kW

6 -

Headlight range control

5A

18 -

Telephone

7 -

Engine electronics, Power assisted steering

5A

19 -

Automatic gearbox

8 -

not assigned

20 -

Bulb failure warning lamp

5A

9 -

Lambda probe

10 A

21 -

Heated washer nozzles

5A

10 -

S contact (86s)

5A

22 -

not assigned

11 -

Heated and adjustable exterior mirrors

5A

23 -

Right main beam

10 A

12 -

Fresh and recirculated air flap, Air conditioning system, Navigation system, Telephone, Gas discharge lamps

5A

24 -

Engine electronics

10 A

5A 5A 15 A 5A 10 A

Edition 06.04 S00.5324.01.20

FABIA

25 -

ABS/TCS control unit ABS/ESP control unit

26 -

No.1/5

Fitting Locations

5A 10 A

47 -

not assigned

not assigned

48 -

Engine control unit

30 A

27 -

not assigned

49 -

Central locking

15 A

28 -

Brake pedal switch, Clutch pedal switch, Engine electronics

5A

50 -

Right main beam / right gas discharge lamp, right headlight range control

15 A

29 -

Engine control unit

5A

51 -

Socket in luggage compartment

15 A

30 -

Left main beam, main beam warning lamp

10 A

52 -

Petrol engine - ignition system

15 A

31 -

Rear lid central locking

10 A

53 -

Power windows

25 A

32 -

Rear window wiper

10 A

54 -

Left main beam / left gas discharge lamp, left headlight range control

15 A

33 -

Right parking light

5A

55 -

not assigned

34 -

Left side light

5A

56 -

Engine control unit

20 A

35 -

Petrol engine - injection valves

10 A

57 -

Trailer coupling

25 A

36 -

Number plate light

5A

58 -

Power windows

25 A

37 -

Rear fog light, rear fog light warning lamp

7,5 A

59 -

not assigned

38 -

Heated and adjustable exterior mirror

5A

60 -

Anti-theft alarm system

15 A

39 -

Rear window heater

20 A

61 -

Fuel pump

15 A

40 -

Horn

20 A

62 -

Sliding roof

25 A

41 -

Windscreen wiper

20 A

63 -

Seat heatings

15 A

42 -

Socket

15 A

64 -

Headlight washer system

20 A

43 -

Onboard supply control unit, Selectorlever lock

20 A

65 -

Fog light

15 A

44 -

Flashing lights

15 A

66 -

Power windows

25 A

45 -

Radio, Navigation system

20 A

67 -

not assigned

46 -

Power windows

25 A

68 -

Fresh air blower

Fuse colours 30 A

- green

10 A

- red

25 A

- white

7.5 A

- brown

20 A

- yellow

5A

- beige

15 A

- blue

Edition 06.04 S00.5324.01.20

25 A

No.1/6

FABIA

Fitting Locations

Fuse holder on battery 08.02 ä 07.03

Fuse assignment in fuse holder on battery 1 -

Alternator

175 A

9 -

2 -

Interior compartment

110 A

10 -

Onboard supply control unit

5A

3 -

Power assisted steering

50 A

11 -

Air conditioning system

5A

4 -

Glow plugs / secondary air pump

40 A

12 -

not assigned

5 -

Radiator fan

40 A

13 -

Automatic gearbox

6 -

ABS/TCS/ESP

40 A

14 -

Wiper motor switch-over relay (up to 04.03)

7 -

ABS/TCS/ESP

25 A

15 -

not assigned

8 -

Radiator fan

30 A

16 -

not assigned

not assigned

5A 20 A

Edition 06.04 S00.5324.01.20

FABIA

No.1/7

Fitting Locations

Fuse holder on battery 08.03 ä

Fuse assignment in fuse holder on battery 1 -

Alternator

175 A

9 -

2 -

Interior compartment

110 A

10 -

Onboard supply control unit

5A

3 -

Power assisted steering

50 A

11 -

Air conditioning system

5A

4 -

Glow plugs / secondary air pump

40 A

12 -

not assigned

5 -

Radiator fan

40 A

13 -

Automatic gearbox

6 -

ABS/TCS/ESP

40 A

14 -

not assigned

7 -

ABS/TCS/ESP

25 A

15 -

not assigned

8 -

Radiator fan

30 A

16 -

not assigned

Edition 06.04 S00.5324.01.20

not assigned

5A

No.1/8

Fitting Locations

FABIA

Relay holder 08.02 ä 07.03

Relay position assignment on relay holder 1

- Secondary air pump relay

2

- Motronic power supply relay

3

- Glow plug relay

4

- Fuel pump relay

5

- Door warning light relay (up to 10.02) - Not assigned (as of 11.02)

6

- Headlight washer system relay

7

- Starter lockout relay

8

- Low heating capacity relay

9

- High heating capacity relay - Fuel feed relay

10 - not assigned (up to 10.02) - Additional fuse holder for heating element for additional heater (PTC) (as of 11.02) 11 - X contact relief relay 12 - Power supply relay for the Simos control unit (only for 1.2/40 kW, 1.2/47 kW) 13 - Bulb failure control unit 14 - Bulb failure control unit 15 - Diesel direct injection system relay

Edition 06.04 S00.5324.01.20

FABIA

Fitting Locations

Relay holder 08.03 ä

Relay position assignment on relay holder 1

- Secondary air pump relay

2

- Motronic power supply relay

3

- Glow plug relay

4

- Fuel pump relay

5

- not assigned

6

- Headlight washer system relay

7

- Starter lockout relay

8

- Low heating capacity relay

9

- High heating capacity relay - Fuel feed relay

10 - Auxiliary relay holder for heating element for auxiliary heater (PTC) 11 - X contact relief relay 12 - Power supply relay for the Simos control unit (only for 1.2/40 kW, 1.2/47 kW) 13 - Bulb failure control unit 14 - Bulb failure control unit 15 - Diesel direct injection system relay

Edition 06.04 S00.5324.01.20

No.1/9

No.1/10

FABIA

Fitting Locations

Additional fuse holder 08.02 ä 10.02 a -

S276

Heating element fuse -1-

b -

S277

Heating element fuse -2-

c -

S278

Heating element fuse -3-

a -

S276

Heating element fuse -1-

b -

S277

Heating element fuse -2-

c -

S278

Heating element fuse -3-

Additional fuse holder 11.02 ä

a b c S97-3341

Edition 06.04 S00.5324.01.20

FABIA

Fitting Locations

No.2/1

Multipin plug connections Contents overview -

Connector location and contact assignment of multipin connector on the left firewall ............................. 2/2

-

Contact assignment of multipin connector at dash panel insert ............................................................... 2/3

-

Contact assignment of multipin connector for Diagnostic connection ...................................................... 2/6

-

Contact assignment of multipin connector at Ignition/starter switch ......................................................... 2/6

-

Connector location and contact assignment of multipin connector at onboard supply unit ...................... 2/7

-

Signal description at onboard supply control unit ..................................................................................... 2/8

-

Contact assignment of multipin connector at engine control units ......................................................... 2/11

-

Plug contact assignment of central locking lock unit .............................................................................. 2/12

-

Plug contact assignment of convenience system central control unit J393 ............................................ 2/13

-

Plug contact assignment of ABS / ABS with EDL and TCS / ESP control unit ....................................... 2/15

-

Plug contact assignment of airbag control unit ....................................................................................... 2/16

-

Plug contact assignment of front left door control unit ............................................................................ 2/17

-

Plug contact assignment of front right door control unit ......................................................................... 2/19

-

Plug contact assignment of rear door control unit .................................................................................. 2/21

-

Plug contact assignment of power steering control unit ......................................................................... 2/22

-

Plug contact assignment of sliding sunroof adjustment control unit ....................................................... 2/24

-

Plug contact assignment of sliding sunroof adjustment regulator .......................................................... 2/24

Edition 07.03 S00.5324.00.20

No.2/2

Fitting Locations

FABIA

Connector location and contact assignment of multipin connector on the left firewall

A -

T8e

8-pin connector (orange)

B -

T6n

6-pin connector (blue)

C -

T6r

6-pin connector (brown)

D -

T11a

11-pin connector (white)

E -

T6v

6-pin connector (green)

F -

T3a

3-pin connector (grey)

G -

T6p

6-pin connector (red)

H I

Not assigned

-

T11c

11-pin connector (blue)

K -

T11b

11-pin connector (red)

L -

T11d

11-pin connector (brown)

M -

T9a

9-pin connector (yellow)

N -

T6w

6-pin connector (grey)

P -

T12a

12-pin connector (white)

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.2/3

Contact assignment of multipin connector at dash panel insert

13 -

T32a/13 Warning concerning failure of a brake light

14 -

T32a/14 not assigned

15 -

T32a/15 Fuel gauge sender

16 -

T32a/16 Coolant shortage indicator sender

17 -

T32a/17 Immobilizer reading coil

18 -

T32a/18 Rear fog light warning lamp

19 -

T32a/19 Fog light warning lamp

20 -

T32a/20 Seat belt warning system warning lamp

1 -

T32a/1

Immobilizer reading coil

21 -

T32a/21 Handbrake warning switch

2 -

T32a/2

Main beam warning lamp

22 -

T32a/22 Brake fluid level warning contact

3 -

T32a/3

Dipped beam warning lamp

23 -

T32a/23 Oil pressure switch

4 -

T32a/4

Oil level/oil temperature sender

24 -

T32a/24 wake up (wake up cable)

5 -

T32a/5

Speed signal - output

25 -

T32a/25 not assigned

6 -

T32a/6

Speed signal - input

26 -

T32a/26 not assigned

7 -

T32a/7

CAN L (engine)

27 -

T32a/27 Multifunction display

8 -

T32a/8

CAN H (engine)

28 -

T32a/28 not assigned

9 -

T32a/9

CAN H (comfort)

29 -

T32a/29 Headlight bulb failure warning lamp

10 -

T32a/10 CAN L (comfort)

30 -

T32a/30 Washer fluid level sender

11 -

T32a/11 Multifunction display

31 -

T32a/31 Ambient temperature sensor

12 -

T32a/12 Multifunction display

32 -

T32a/32 Terminal 31 for output sender

Edition 07.03 S00.5324.00.20

No.2/4

FABIA

Fitting Locations

Contact assignment of multipin connector at dash panel insert 1 -

T8c/1

Brake pad/lining warning lamp

2 -

T8c/2

not assigned

3 -

T8c/3

not assigned

4 -

T8c/4

Right parking light

5 -

T8c/5

Terminal 15 - input

6 -

T8c/6

Left parking light

7 -

T8c/7

Terminal 30 - input

8 -

T8c/8

Terminal 31 - input

Warning lamp control in dash panel insert

Warning lamp

Signal source

Main beam warning lamp (K1)

T32a/2

Alternator warning lamp (K2)

CAN bus (Onboard supply control unit)

Oil pressure warning lamp (K3)

T32a/23

Brake fluid level warning lamp (K7)

T32a/22, CAN bus (ABS control unit)

Handbrake warning lamp (K7)

T32a/21

Rear fog light warning lamp (K13)

T32a/18

Fog light warning lamp (K17)

T32a/19

Trailer operation warning lamp (K18)

CAN bus (Onboard supply control unit)

Seat belt warning system warning lamp (K19)

T32a/20, CAN bus (Airbag control unit)

Coolant temperature warning lamp (K28)

CAN bus (Engine control unit)

Coolant shortage warning lamp (K28)

T32a/16

Glow period warning lamp (K29)

CAN bus (Engine control unit)

Brake pad/lining warning lamp (K32)

T8c/1

Oil level warning lamp (K38)

T32a/4

ABS warning lamp (K47)

CAN bus (ABS control unit)

Edition 06.04 S00.5324.01.20

FABIA

No.2/5

Fitting Locations

Warning lamp control in dash panel insert

Warning lamp

Signal source

Dipped beam warning lamp (K60)

T32a/3

Left turn signal warning lamp (K65)

CAN bus (Onboard supply control unit)

Airbag warning lamp (K75)

CAN bus (Airbag control unit)

Exhaust emissions warning lamp (K83)

CAN bus (engine control unit)

TCS warning lamp (K86)/ESP warning lamp (K155)

CAN bus (ABS/TCS/ESP control unit)

Power steering warning lamp (K92)

CAN bus (Onboard supply control unit)

Right turn signal warning lamp (K94)

CAN bus (Onboard supply control unit)

Reserve fuel warning lamp (K105)

T32a/15

Washer fluid low warning lamp (K106)

T32a/30

Immobilizer warning lamp (K117)

Immobilizer control unit

Electronic power control fault lamp (K132)

CAN bus (engine control unit)

Door open warning lamp (K166)

CAN bus (Onboard supply control unit)

Rear lid open warning lamp (K116)

CAN bus(Onboard supply control unit)

Bulb failure warning lamp (K170)

T32a/13, 29

Rear seat backrest lock warning lamp (K193)

CAN bus (Onboard supply control unit)

Read out control in dash panel insert

Read out

Signal source

Fuel gauge (G1)

T32a/15

Coolant temperature gauge (G3)

CAN bus (Engine control unit)

Rev. Counter (G5)

CAN bus (engine control unit)

Speedometer (G21)

T32a/6

Buzzer/gong (H3)

Control unit in dash panel insert

Digital clock (Y2)

Control unit in dash panel insert

Odometer display (Y4)

Control unit in dash panel insert

Multifunction display (J119)

T32a/11, 12, 27, 31, CAN bus (Engine control unit), control unit in dash panel insert

Selector lever position indicator (Y6)

CAN bus (control unit for automatic gearbox)

Edition 06.04 S00.5324.01.20

No.2/6

FABIA

Fitting Locations

Contact assignment of multipin connector for diagnostic connection

4 -

T16b/4

Terminal 31

5 -

T16b/5

Terminal 31

6 -

T16b/6

CAN H (engine, switched on)

7 -

T16b/7

K- diagnostic cable

14 -

T16b/14 CAN L (engine, switched on)

16 -

T16b/16 Terminal 30

Contact assignment of multipin connector at ignition/starter switch

1 -

T8a/50

2 -

T8a/75

3 -

T8a/30

4 -

T8a/P

5 -

T8a/50b

6 -

T8a/15

7 -

T8a/30

8 -

T8a/86s

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.2/7

Connector location and contact assignment of multipin connector at onboard supply

XS1 -

T6c

6-pin connector (black)

XS2 -

T18b

18-pin connector (black)

XS3 -

T6y

6-pin connector (brown)

XS4 -

T18a

18-pin connector (brown)

XS5 -

T6k

6-pin connector (red)

XS6 -

T16a

16-pin connector (black)

XP1 -

T6o

6-pin connector (black)

XP2 -

T6j

6-pin connector (brown)

XP3 -

T6x

6-pin connector (red)

XP4 -

T5a

5-pin connector (black)

XP5 -

T5c

5-pin connector (brown)

Edition 07.03 S00.5324.00.20

No.2/8

Fitting Locations

FABIA

Signal description on onboard supply control unit Connector XS1 T6c/1

Signal Input of light switch (for headlight washer system)

T6c/2

Input of regulator for lighting - switches and instruments (58b)

T6c/3

Output of warning lamp + hazard warning light button illumination

T6c/4

Input of heated rear window button (31)

T6c/5

Output for heated rear window warning lamp

T6c/6

Input of hazard warning light button (31)

XS2 T18b/1

Output for selector level lock

T18b/2

Output (release) for sliding sunroof adjustment control unit (15)

T18b/3

Output (block) for heated driver seat control unit

T18b/4 T18b/5 T18b/6 T18b/7 T18b/8 T18b/9

CAN-L, comfort

T18b/10

Output (block) for heated driver seat control unit

T18b/11 T18b/12

CAN-H, comfort

T18b/13

Input of multi-function switch for automatic gearbox (31)

T18b/14

Output for headlight washer system relay

T18b/15 T18b/16 T18b/17

Output for start interlock relay

T18b/18 XS3 T6Y/1 T6Y/2

Input of CCS switch (Off)

T6Y/3

Input of CCS switch (On/Off)

T6Y/4 T6Y/5

Input of CCS switch (support/accelerate)

T6Y/6

Input of CCS switch (set)

Continued on next page! Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

Connector XS4 T18a/1

Signal K-cable

T18a/2

Input of ignition starter switch (86s)

T18a/3

Input of rear right door contact switch (31)

T18a/4

Input of front right door contact switch (31)

T18a/5

Input of fuse in fuse holder on battery (30 analogous)

T18a/6

Input of front left door contact switch (31)

T18a/7

Input of left backrest contact switch (31)

T18a/8

Input (31 analogous)

T18a/9

Input of alternator (D+)

T18a/10

Input of right backrest contact switch (31)

T18a/11

Input of ignition starter switch (75)

T18a/12

Input of ignition starter switch (15)

T18a/13

Input of rear left door contact switch (31)

T18a/14

Input of ignition starter switch (50)

T18a/15

Input of windscreen wiper switch, output for rear window wiper

T18a/16

Input of castor contact of windscreen wiper motor

T18a/17

Input of actuating the horn (31)

T18a/18

Input of regulator for the windscreen wiper interval switching

XS5 T6k/1 T6k/2 T6k/3

Input of central locking switch, in rear lid lock (31)

T6k/4

Input of central luggage compartment illumination switch, in rear lid lock

T6k/5 T6k/6

Input of rear lid handle release button (31)

XS6 T16a/1 T16a/2

CAN-L, switched

T16a/3

CAN-L

T16a/4 T16a/5

CAN-L

T16a/6

CAN-H, switched

T16a/7

Input of windscreen wiper switch (1st stage)

T16a/8

Input of windscreen wiper switch (2nd stage)

T16a/9

Output for fuel feed relay (31)

T16a/10

Input of turn signal switch (left turn signal) (31)

Continued on next page! Edition 06.04 S00.5324.01.20

No.2/9

No.2/10

Connector XS6 T16a/11

Signal Output for dash panel insert (Wake up)

T16a/12

Input of turn signal switch (right turn signal) (31)

T16a/13

Input of engine hood contact switch (31)

T16a/14

Output for right turn signal

T16a/15

Input of fuse 44a (30)

T16a/16

Output for left turn signal

XP1 T6o/1 T6o/2

FABIA

Fitting Locations

Input of fuse 13a (15) (only for vehicles fitted with automatic gearbox) Input of reversing light switch (not valid for vehicles with automatic gearbox), Output for reversing light switch (only for vehicles with automatic gearbox)

T6o/3 T6o/4 T6o/5

Output for rear lid central locking motor

T6o/6

Input of fuse 31a (30)

XP2 T6j/1

Input of fuse 43a (30)

T6j/2 T6j/3 T6j/4

Input of fuse 4a (30)

T6j/5 T6j/6 XP3 T6x/1 T6x/2

Output for interior light, luggage compartment light, glove box light (30al) Input of exterior mirror heating button Output for left heated exterior mirror

T6x/3 T6x/4

Output for right heated exterior mirror

T6x/5 T6x/6 XP4 T5a/1

Input of fuse 38a (30) Output for front interior light (31)

T5a/2

Input (31)

T5a/3

Input of fuse 41a (30)

T5a/4

Output for windscreen wiper motor (1st stage)

T5a/5

Output for windscreen wiper motor (2nd stage)

XP5 T5c/1

Input of windscreen wiper motor (31) (brake application)

T5c/2

Output for horn

T5c/3

Input of fuse 40a (30)

T5c/4

Output for heated rear window

T5c/5

Input of fuse 39a (30)

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.2/11

Contact assignment of multipin connector on the engine control units

Note: Refer to the appropriate current flow diagram for the exact contact assignment.

Edition 07.03 S00.5324.00.20

No.2/12

FABIA

Fitting Locations

Plug contact assignment of central locking lock unit, driver side T8f and front passenger side T8g 1 -

T8f/1 or T8g/1

Central locking motor

2 -

T8f/2 or T8g/2

Central locking motor

3 -

T8f/3 or T8g/3

free

4 -

T8f/4 or T8g/4

Close (without resistance), open (above resistance 180 Ω)

5 -

T8f/5 or T8g/5

Feedback for -closed(without resistance), feedback for -closed with Safe- (with resistance 180 Ω)

6 -

T8f/6 or T8g/6

free

7 -

T8f/7 or T8g/7

Earth

8 -

T8f/8 or T8g/8

Door contact switch earth

Plug contact assignment of central locking lock unit, rear left T6c and rear right T6d

1 -

T6c/1 or T6d/1

Central locking motor

2 -

T6c/2 or T6d/2

Central locking motor

3 -

T6c/3 or T6d/3

Feedback for -closed(without resistance), feedback for -closed with Safe- (with resistance 180 Ω),

4 -

T6c/4 or T6d/4

free

5 -

T6c/5 or T6d/5

Earth

6 -

T6c/6 or T6d/6

Door contact switch earth

Edition 07.03 S00.5324.00.20

FABIA

No.2/13

Fitting Locations

23-pin plug contact assignment of convenience system central control unit J393,

Edition 07.03 S00.5324.00.20

1 -

T23a/1

Driver side central locking motor

2 -

T23a/2

Feedback for -closed- (without resistance), feedback for -closed with Safe- (with resistance 180 Ω), front passenger side

3 -

T23a/3

Door warning light relay (only for vehicles with door warning lights) (up to 10.02)

4 -

T23a/4

Central locking warning lamp in driver door

5 -

T23a/5

Close (without resistance), open (above resistance 180 Ω), front passenger side

6 -

T23a/6

Close (without resistance), open (above resistance 180 Ω), driver side

9 -

T23a/9

Feedback for -closed- (without resistance), feedback for -closed with Safe- (with resistance 180 Ω), driver side

10 -

T23a/10 Data bus CAN-Low, comfort

11 -

T23a/11 Data bus CAN-High, comfort

12 -

T23a/12 Sliding sunroof adjustment control unit (actuation)

13 -

T23a/13 K-diagnostic cable connection

17 -

T23a/17 Earth

19 -

T23a/19 Front passenger side central locking motor

21 -

T23a/21 Front passenger side central locking motor

22 -

T23a/22 Driver side central locking motor

23 -

T23a/23 Positive connection 30a, via fuse SB 49

No.2/14

FABIA

Fitting Locations

12-pin plug contact assignment of convenience system central control unit J393, (black)

1 -

T12c/1

Feedback for -closed- (without resistance), feedback for -closed with Safe- (with resistance 180 Ω), rear right

3 -

T12c/3

Feedback for -closed- (without resistance), feedback for -closed with Safe- (with resistance 180 Ω), rear left

9 -

T12c/9

Rear right central locking motor

10 -

T12c/10 Rear left central locking motor

11 -

T12c/11 Rear right central locking motor

12 -

T12c/12 Rear left central locking motor

12-pin plug contact assignment of convenience system central control unit J393, only for vehicles fitted with central locking remote control or with anti-theft alarm system (brown) On vehicles fitted with anti-theft alarm system no plug is placed on.

1 -

T12i/1

Interior monitoring sensor

2 -

T12i/2

Interior monitoring sensor

6 -

T12i/6

Alarm horn

8 -

T12i/8

Interior monitoring sensor

10 -

T12i/10 Positive connection 30a, via fuse SB 60

11 -

T12i/11

T6v/4 connector, on left firewall

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.2/15

Plug contact assignment of ABS/ABS with EDL and TCS/ESP control unit

14 -

T42a/14 Rear left speed sensor

15 -

T42a/15 Front right speed sensor

16 -

T42a/16 Front right speed sensor

19 -

T42a/19 Signal for navigation system control unit

21 -

T42a/21 Lateral acceleration and yaw rate sender, steering angle sender

23 -

T42a/23 Positive connection 15a, via fuse SB 25

24 -

T42a/24 Data bus CAN-High

25 -

T42a/25 Sender -1- for brake pressure

26 -

T42a/26 Sender -1- for brake pressure

27 -

T42a/27 ASR / ESP switch

28 -

T42a/28 Front left speed sensor

30 -

T42a/30 Rear right speed sensor

1 -

T42a/1

Earth

31 -

T42a/31 Rear right speed sensor

2 -

T42a/2

Positive connection 30, via fuse S178

32 -

T42a/32 Brake light switch

34 -

5 -

T42a/5

Earth

T42a/34 Signal for navigation system control unit

6 -

T42a/6

Positive connection 30, via fuse S179

37 -

T42a/37 Brake pedal switch

38 -

T42a/38 Handbrake warning switch

8 -

T42a/8

Lateral acceleration and yaw rate sender

39 -

T42a/39 Lateral acceleration and yaw rate sender, steering angle sender

9 -

T42a/9

Lateral acceleration and yaw rate sender

40 -

T42a/40 Data bus CAN-Low

41 -

T42a/41 Lateral acceleration and yaw rate sender

42 -

T42a/42 Sender -1- for brake pressure

10 -

T42a/10 Lateral acceleration and yaw rate sender

12 -

T42a/12 Front left speed sensor

13 -

T42a/13 Rear left speed sensor

Edition 07.03 S00.5324.00.20

No.2/16

FABIA

Fitting Locations

Plug contact assignment of airbag control unit

26 -

T75a/26 Positive connection 15

27 -

T75a/27 Side airbag igniter, front passenger side

28 -

T75a/28 Side airbag igniter, front passenger side

29 -

T75a/29 Side airbag igniter, driver side

30 -

T75a/30 Side airbag igniter, driver side

31 -

T75a/31 Airbag igniter, front passenger side

32 -

T75a/32 Airbag igniter, front passenger side

33 -

T75a/33 Airbag igniter, driver side, via coil connector in steering wheel

34 -

T75a/34 Airbag igniter, driver side, via coil connector in steering wheel

41 -

T75a/41 Belt tensioner igniter, driver side

42 -

T75a/42 Belt tensioner igniter, driver side

43 -

T75a/43 Belt tensioner igniter, front passenger side

44 -

T75a/44 Belt tensioner igniter, front passenger side

51 -

T75a/51 Earth

56 -

T75a/56 Front passenger side airbag deactivated warning lamp

60 -

T75a/60 Front passenger side airbag deactivation key switch

70 -

T75a/70 Side airbag crash sensor, driver side

71 -

T75a/71 Side airbag crash sensor, front passenger side

74 -

T75a/74 Data bus CAN-High

75 -

T75a/75 Data bus CAN-Low

Edition 07.03 S00.5324.00.20

FABIA

No.2/17

Fitting Locations

12-pin plug contact assignment of front left door control unit, black plug

1 -

T12d/1

Front left window regulator switch

2 -

T12d/2

Illumination for central switch for window regulator

3 -

T12d/3

Front left window regulator switch, driver

4 -

T12d/4

Illumination - mirror adjustment switch

5 -

T12d/5

Driver side interior locking switch

6 -

T12d/6

Rear window regulator isolation switch

7 -

T12d/7

Rear right window regulator switch, driver

8 -

T12d/8

Rear left window regulator switch, driver

9 -

T12d/9

Earth

10 -

T12d/10 Mirror adjustment switch

11 -

T12d/11 Exterior mirror heating button

12 -

T12d/12 Mirror adjustment change-over switch (left, right)

12-pin plug contact assignments of front left door control unit, brown plug 1 -

T12e/1

Driver side mirror adjustment motor

5 -

T12e/5

Driver side mirror adjustment motor

6 -

T12e/6

Driver side mirror adjustment motor

8 -

T12e/8

Driver side heated exterior mirror

10 -

Edition 07.03 S00.5324.00.20

T12e/10 Driver side heated exterior mirror

No.2/18

FABIA

Fitting Locations

8-pin plug contact assignment of front left door control unit

1 -

T8h/1

Positive connection 30a, via fuse SB 58

2 -

T8h/2

Earth

4 -

T8h/4

Data bus CAN-High, comfort

5 -

T8h/5

Onboard supply control unit

6 -

T8h/6

Data bus CAN-Low, comfort

Edition 07.03 S00.5324.00.20

FABIA

No.2/19

Fitting Locations

12-pin plug contact assignment of front right door control unit

1 -

T12f/1

Front passenger side mirror adjustment motor

5 -

T12f/5

Front passenger side mirror adjustment motor

6 -

T12f/6

Front passenger side mirror adjustment motor

8 -

T12f/8

Front passenger side heated exterior mirror

10 -

T12f/10 Front passenger side heated exterior mirror

8-pin plug contact assignment of front right door control unit

Edition 07.03 S00.5324.00.20

1 -

T8i/1

Positive connection 30a, via fuse SB 46

2 -

T8i/2

Earth

4 -

T8i/4

Data bus CAN-High, comfort

5 -

T8i/5

Onboard supply control unit

6 -

T8i/6

Data bus CAN-Low, comfort

No.2/20

FABIA

Fitting Locations

6-pin plug contact assignment of front right door control unit

1 -

T6p/1

Window regulator switch in front passenger door

2 -

T6p/2

Window regulator switch light bulb

4 -

T6p/4

Earth

Edition 07.03 S00.5324.00.20

FABIA

No.2/21

Fitting Locations

8-pin plug contact assignment of rear left or right door control unit

1 -

T8j/1 or T8k/1

Positive connection 30a, via fuse SB 66 or SB 53

2 -

T8j/2 or T8k/2

Earth

4 -

T8j/4 or T8k/4

Data bus CAN-High, comfort

6 -

T8j/6 or T8k/6

Data bus CAN-Low, comfort

6-pin plug contact assignment of rear left or right door control unit

Edition 07.03 S00.5324.00.20

1 -

T6r/1 or T6s/1

Rear window regulator isolation switch

2 -

T6r/2 or T6s/2

Window regulator switch light bulb

4 -

T6r/4 or T6s/4

Earth

No.2/22

FABIA

Fitting Locations

4-pin plug contact assignment of power steering control unit (TRW, KOYO)

1 -

T4r/1

Data bus CAN-Low

2 -

T4r/2

Data bus CAN-High

4 -

T4r/4

Positive connection 15a, via fuse SB7

3-pin plug contact assignment of power steering control unit (TRW)

1 -

T3s/1

Power steering sensor

2 -

T3s/2

Power steering sensor

3 -

T3s/3

Power steering sensor

Edition 07.03 S00.5324.00.20

FABIA

No.2/23

Fitting Locations

4-pin plug contact assignment of power steering control unit (KOYO)

1

2

3

1 -

T4z/1

Power steering sensor

2 -

T4z/2

Power steering sensor

3 -

T4z/3

Power steering sensor

4 -

T4z/4

Power steering sensor

4 S97-3339

2-pin plug contact assignment of power steering control unit (TRW, KOYO)

Edition 07.03 S00.5324.00.20

1 -

T2a/1

Positive connection 30, via fuse S164 on battery

2 -

T2a/2

Earth

No.2/24

FABIA

Fitting Locations

Plug contact assignment of sliding sunroof adjustment control unit

1 -

T6e/1

Earth

2 -

T6e/2

Onboard supply control unit

3 -

T6e/3

Convenience system central control unit (only for vehicles with central locking)

4 -

T6e/4

Positive connection 30a, via fuse SB 62

6 -

T6e/6

Vehicle speed signal

Plug contact assignment of sliding sunroof adjustment regulator

1 -

T6f/1

5 Volt Voltage supply

2 -

T6f/2

Earth

3 -

T6f/3

Potentiometer

5 -

T6f/5

Press function emergency closed

6 -

T6f/6

Earth

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.3/1

Earth points Contents overview -

Overview of earth points in engine compartment ..................................................................................... 3/2

-

Overview of earth points in interior compartment ..................................................................................... 3/2

-

Overview of earth points in interior compartment ..................................................................................... 3/3

-

Overview of earth points in luggage compartment - Fabia ....................................................................... 3/3

-

Overview of earth points in luggage compartment - Fabia Estate ............................................................ 3/4

-

Overview of earth points in luggage compartment - Fabia Saloon ........................................................... 3/4

Edition 07.03 S00.5324.00.20

No.3/2

FABIA

Fitting Locations

Overview of earth points in engine compartment

14 19 11 13 29 614 14b

14a

12

12a

S97-3342

Overview of earth points in interior

606

S97-3343

Edition 07.03 S00.5324.00.20

FABIA

Fitting Locations

No.3/3

Overview of earth points in interior

62

S97-3344

Overview of earth points in luggage compartment - Fabia

61

S97-3345

Edition 07.03 S00.5324.00.20

No.3/4

FABIA

Fitting Locations

Overview of earth points in luggage compartment - Fabia Estate.

61

S97-3346

Overview of earth points in luggage compartment - Fabia Saloon

61

S97-3347

Edition 07.03 S00.5324.00.20